Rola 59004 User manual

Product Code:
Product Name:
59004
Roof Top Cargo Box
WARNING
DO NOT EXCEED the lowest of vehicle manufacturer’s cross bar rating or cargo box weight limit of 110 Lb / 50 Kg.
DO NOT transport people, animals, or flammable liquids.
Before Transport You MUST: Securely fasten all loads in cargo box. Make sure all bolts, straps, knobs, and
locks are firmly attached and locked before every trip.
Distribute your cargo evenly inside the cargo box. Heavier items should be placed in the center.
Check the security of load, bolts, straps, knobs, and locks at fuel and rest stops.
Check for proper clearance between sunroof and cargo box before operating sunroof (if equipped).
TOOLS REQUIRED:
Tape Measure
Please read all instructions carefully before assembly, installation and/or use of this product.
PARTS LIST:
1•Unpack cargo box.
• Open cargo box and remove mounting
hardware, keys, & instruction sheet.
Hole Plug117964126
Nylon Strap11793525
Rubber Gasket11793344
Clamp Block11793243
Clamping Knob, M8‐1.2511793182
U‐Bolt, M8 x 1.25 x 75mm11793041
DESCRIPTIONPART NO.QTY.
ITEM
NO.
MAXIMUM LOAD LIMITS:
+
THIS PRODUCT 23 Lbs. / 10 Kg
Weight of Cargo =Total Weight
DO NOT EXCEED
Your Rack’s Limit
•With the help of another person place
cargo box on top of roof rack.
• Line up the mounting holes in bottom of
cargo box with vehicle cross bars.
2
IMPORTANT NOTE:
This product will not fit vehicle:
•If vehicle cross bar size exceeds:
‐width of 3‐1/4” (82mm)
‐height of 1‐1/4” (32mm)
•If cross bars will not adjust to:
‐27‐1/2” (700mm) Minimum Spacing
‐34‐1/2” (876mm) Maximum Spacing
See step 3 for bar spacing

Product Code:
Product Name:
59004
•If cross bars are adjustable, set to widest
position of 34-1/2” (876mm) center to center of
cross bar.
• This product fits the following cross bar
spacing's:
- 27-1/2” (700mm) Minimum
- 29-1/4” (743mm)
- 31” (787mm)
- 32-3/4” (832mm)
- 34-1/2” (876mm) Maximum
6
Please read all instructions carefully before assembly, installation and/or use of this product.
Minimum bar spacing = 27-1/2” (700mm)
3
Roof Top Cargo Box
5•Check for rear hatch and front hood
clearance. Adjust cross bars for proper
clearance.
• NOTE: Interference is unavoidable on some
vehicles.
• NOTE: Mount box towards the rear of vehicle
to minimize wind resistance.
4•Slide cross bars forward or backward to line up
holes in cargo box with cross bars.
•To secure Cargo Box to cross bars, install the
u-bolts around cross bars and through holes
in bottom of Cargo box.
• Place the gasket, clamp block, and clamping
knobs onto u-bolts as shown.
• Firmly hand tighten clamping knobs.
• Install hole plugs into remaining unused holes
in bottom of cargo box.

Product Code:
Product Name:
59004
Please read all instructions carefully before assembly, installation and/or use of this product.
•Install the nylon straps through loops in clamp
blocks. Use straps to secure cargo to inside of
cargo box.
7
8•Make sure that loads are distributed evenly
inside the cargo box. DO NOT EXCEED cargo
box weight limit of 110 Lb / 50 Kg.
•Keep the unit clean and remove road salt and debris.
• Do not allow harsh chemicals, road salt, or mud to accumulate on the product for an extended period of time.
• Wash the product with mild soap and water only and a non-abrasive cloth after use.
• The lock and hinges should be lubricated with graphite or similar dry lubricant.
CARE AND USAGE
GUIDELINES
• Be careful when driving in or near low clearance branches, bridges, and parking garages as they can affect your cargo
carrier and load. All cargo can affect the vehicles driving behavior.
• Never drive with any lock, lid, or knob in the unlocked or open position.
• Remove your cargo box and gear before entering an automatic car wash or when not in use.
TO LOCK:
•Turn key counter clockwise.
• To unlock, insert key and turn clockwise.
Roof Top Cargo Box
30
30 50
9
RELEASE/SECURE FRONT LATCH
ROLA CARGO CARRIERS ROOF RACKS