Saxby Lighting Magma 43784 Manual

• Thissystemcontainsnon-replaceablepartsand
cannotbeserviced.Ifdamageoccursthepartshould
bescrapped.
Instructionleaflet
Magma Flood Light
43784
www.saxbylighting.com
Foryoursafety,alwaysswitchoffthesupplybeforecleaning.
Wasteelectricalproductsshouldnotbedisposedofwithhouseholdwaste.Pleaserecyclewherefacilities
exist.CheckwithyourLocalAuthorityorretailerforrecyclingadvice.
Recycling advice
Safety information
SaxbyLightingLtd.BH233PE
Werecommendcleaningwithasoftdrycloth.
Donotusesolventsorabrasivecleanersasthesecould
damagethefinish.
The LED's are protected by a lens. This part must be replaced immediately should the lens become
cracked or damaged. This fitting must not be used without the lens in place.
ReplaceCracked
Shade
Fitting/replacing bulbs
Iss.109052012
• Refitthebaseontotheproductusingscrews(A).
• Locate the product over the drilled holes and fix in
positionusingscrews(C).
• Adjustthefloodlightheadtothedesiredangle.
• Replacefuse orcircuit breaker and switchon. Your
lightisnowreadyforuse.
Commissioning
Check that...
• Youhavecorrectlyidentifiedthewires.
• Theconnectionsaretight.
• Noloosestrandshavebeenleftoutoftheconnection
block.

Thankyouforpurchasingthislightfitting.Pleasereadtheinstructionscarefullybeforeusetoensuresafeand
satisfactoryoperationofthisproduct.Pleaseretaintheseinstructionsforfuturereference.
Warning
This is a Class 1 product and must be earthed.
Pleasereadtheseinstructionscarefullybefore
commencinganywork.
Thisunitmustbefittedbyacompetentandqualified
electrician.
InstallinaccordancewithIEEWiringregulationsand
currentBuildingRegulations.
Topreventelectrocutionswitchoffatmainssupply
beforeinstallingormaintainingthisfitting.Ensure
otherpersonscannotrestoretheelectricalsupply
withoutyourknowledge.Ifyouareinanydoubt,
pleaseconsultaqualifiedelectrician.
Thislightfittingshouldbeconnectedtoacircuitwitha
30mARCDfitted.
Ifreplacinganexistingfitting,makeacarefulnoteof
theconnections.
Theunitcannotbedimmed.
Thissystemcontainsnon-replaceablepartsand
cannotbeserviced.Ifdamageoccursthepartshould
bescrapped.
Wasteelectricalproductsshouldnotbedisposedof
withhouseholdwaste.Pleaserecyclewherefacilities
exist.Checkwithyourlocalauthorityorretailerfor
recyclingadvice.
ThisproductisratedatIP65.
Thisproductisnotsuitableforlocationinorneara
marineenvironment.
Theentireunitgetshotwhilstonforaperiodoftime.
Specification
Voltage: 240V~50Hz
Lamp: 15x1WCreeLED’s
IPrating: 65
Layout
• Planthedesiredlayoutofthisfittingcarefully,
ensuringthecableswillreachthedistancebetween
thejunctionboxandthelightfitting.
• Avoidlocatinganycablesinpositionsthatwould
causeahazard.Positioncablesandoutdoorrated
junctionboxes(notsupplied)awayfromareas
wheretheymaybeatriskfrombeingcut,trappedor
damaged.
• Theinstallationofthepowercableandconduitmust
meetnationalandlocalstandards.Anyillustrations
showingtheconduitandcableareonlyaguide.The
typeanddepthofconduitandcablemayvaryfrom
areatoarea.Contactaqualifiedelectriciantocarry
outthiswork.
• Thisisafloodlightproduct,andthereforeshouldbe
positionedwhereitwillnotcauseaglarehazard.
Existingfittingsmustbecompletelyremovedbefore
installationofanewproduct.Beforeremovingthe
existingfitting,carefully note the position of each set
of wires.
• Decideontheoptimumlocationfortheproduct.
• Undothethreescrews(A),andsetside.Remove
baseplate.
• Theproductmustbemountedontoaconcretebase
orpavingslab.Itshouldnotbedirectlyinstalledon
thesoil.Detailsoffixingpositionsaregivenbelowin
Fig1.Verifythebasefitsbeforedrilling.
• Drillandplug(B)theatthemarkedpositions.
• Wireasdetailedbelow.
Installation
NEUTRAL
EARTH(GREEN/YELLOW)
SWITCHEDLIVE
BLUE(N)
GREEN/YELLOW
BROWN(L)
SUPPLY LIGHTFITTING
Removethecoverfromtheconnectorblockontopof
theunit.Connecttheoutputcableofthetransformerto
theterminalsindicatedbelow:
Wiring
120˚
120˚
120˚
116mm Dia
1. 2.
A
B
C