Sealey MAC01 User manual

 WARNING! Ensure you have read and understood
the safety instructions.
3.1. Positioncompressoronarm,atsurfaceandsothat
the air hose reaches the tyre valve.
3.2. Check that the compressor On/Off switch is in the OFF
position and plug the 12V plug into the vehicle's cigarette lighter socket.
3.3. Removethevalvedustcapandlifttheconnectorlockingleverintotheuprightposition(g.1).
3.4. Pushconnectorfullyontothevalveandlockinplacebypressingdownthelockinglever(g.2).
IMPORTANT:Inationwillonlybeeffectiveiftheconnectorisfullyttedandlockedontothevalve.
3.5. Press the compressor On/Off switch to the ON position and the compressor will begin to operate.
 InatethetyretothedesiredpressureandturnoffthecompressorbypressingtheswitchtotheOFFposition.
NOTE: Thegaugemaybesubjecttouctuationwhilstpumping.
3.6. Remove the air hose from the tyre valve by releasing the locking lever and gently twisting and pulling the
 connectorfromthetyrevalve,takingcarenottoloseanyairintheprocess.Replacethedustcap.
3.7. Disconnect the 12V plug from the vehicle's cigarette lighter socket.
WARNING!Thecompressormustbeswitchedoffforfteenminutesaftereachsixtyminuteperiodof
 continuousoperationtopreventexcessiveheatbuild-up.
3.8. TheLEDlightshavetwoselectablefunctions-whiteLEDsforilluminationorredashingLEDsfor
 emergencywarning.Thelightswitchcyclesthrough:OFF-WhiteLED-RedashingLED-OFF.
INSTRUCTIONS FOR:
MINI AIR COMPRESSOR 12V
Model No: MAC01
1. SAFETY INSTRUCTIONS
 Keep the compressor clean and in good condition.
Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous
and will invalidate the warranty.
 Keepchildrenandnon-essentialpersonsawayfromtheworkarea.
WARNING! This compressor is capable of producing a high pressure. DO NOT inflate any item beyond
 it'smaximumspecified pressure.
The 12volt cigarette lighter plug must not be replaced with any other type of plug or electrical supply.
 DO NOTusenearflammablesolids,liquidsorgases.
 DO NOTdirectinflationhoseconnectorheadatyourself,othersoranimals.
 DO NOT leave the compressor operating unattended. Always monitor it and the inflation pressure.
 DO NOTcarrybythehose,oryankthehosefromaninflationvalve.
 DO NOT pull the plug from the cigarette lighter socket using the lead.
 DO NOT get the compressor wet or use in the rain.
 DO NOT use the compressor for a task that it is not designed for.
 DO NOToperatethecompressorwhenyouaretiredorundertheinfluenceofalcohol,drugsorintoxicating
medication.
 DO NOT operatethecompressorifanypartsaremissingorthecompressorisdamaged,asthismay
cause failure and/or personal injury.
 DO NOT open the unit.
2. INTRODUCTION
3. OPERATION
IMPORTANT: PLEASE READ THESE INSTRUCTIONSCAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGSAND CAUTIONS. USE THIS
PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT ISINTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR PERSONAL
INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS FOR FUTURE USE.
12Volt Mini air compressor with a delivery of 25ltr/min. Stylish housing with integral storage for supply lead and air
output hose. Features a work light to illuminate work area in low light areas. Light can also be set to flash red for
emergencyuse.Pressuregaugereadsupto8bar/120psi.Suitableforinflatingtyresoncars,vansand4x4's.
Air output hose length: 600mm
Power supply lead length: 3.3M
fig.2
fig.1
MAC01Issue:1-23/10/09
Original Language Version

General Information:
a) Wheninatingatotallyattyrestillttedonavehicle,thereshouldnotbeanyweightonit.Thevehicle
 must,therefore,bejackeduptotaketheweightoffthetyre.
b) Thetimetakentoinateatyrewilldependuponthevolumeofairandpressurerequired.
c) Ifthecompressordoesnotworkwhenitispluggedin,checktheoperationofthelightersocket,itmay
 requiretheignitionswitchtobeinthe‘ON’positionforittowork.
NOTE:Thecompressormayalsobeusedonitemssuchasinatabledinghies,sportsballs,airbedsetc.usingoneof
the two adaptors supplied.
NOTE: The pressure gauge is not a calibrated instrument. It is recommended to use a calibrated tyre pressure gauge
foranaccuratenalreading.
CAUTION: Some items may not indicate the pressure required or the safe maximum pressure. Be very careful
not to over-inflate.
Environmental Protection.
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
a recycle centre and disposed of in a manner which is compatible with the environment.
  Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.
Original Language Version
01284 757500
01284 703534
[e-mail]
www.sealey.co.uk
Web
email
NOTE: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior notice.
IMPORTANT: No liability is accepted for incorrect use of this product.
WARRANTY: Guaranteeis12monthsfrompurchasedate,proofofwhichwillberequiredforanyclaim.
INFORMATION:Foracopyofourlatestcatalogueandpromotionscalluson01284757525andleaveyourfullnameandaddress,includingpostcode.
Sole UK Distributor, Sealey Group,
KempsonWay,SuffolkBusinessPark,
BurySt.Edmunds,Suffolk,
IP327AR
MAC01Issue:1-23/10/09
01284 757500
01284 703534
[e-mail]
www.sealey.co.uk
Web
email