Separett VILLA User manual

Separett®VILLA
Model 9220
www.separett.com
ENG
Art nr 11236-03
©SEPARETT AB 2007 SEPARETT is a registered trademark for Separett AB

This is included with the product
USA/CANADA x2
x1 x1 x1 x1 x1 x2 Ca 3,5 inches
x2 x1 x1 x1
x3
3,5
90
43 x2
1,7
45
72
Ca 3,2 inches
2 m x1 x1 x1
10580
6,4
16
5
4
7
6,1
15
4
6
2
24,
618
331
25,
658
906
0,31
8
5
3,
8
2
2
48
,50
0,31
8
5
1,29
3
9
3
922,9
76
Useful tools
Material
Upper/lower sections:
High impact,
high gloss polypropylene
Seat:
Gloss polypropylene
Inner bucket/cover:
Polypropylene
All materials can be recycled
Weight
28.7 pounds/13 kg
Dimensions
Ventilation pipe: Ca Ø 3 inches/75 mm
Urine drain: Ø 1.25 inches/32 mm
Electrical equipment
9220: Fan, 120V, 60 Hz, 14.6/18.9W
9220: Fan, 12V, 2.5W/210 mA
Electrical connection
9220: 4-foot/1.22 metre lead with
grounding plug; 4-foot/1.22 metre cable.
9220: Battery cable
Energy consumption
9220: 0.350/0.453 kWh/24 hrs.
9220: 0.06 kWh/24 hrs.
Art nr 11236-03
©SEPARETT AB 2007 SEPARETT is a registered trademark for Separett AB
INSTALLATION
•Can be installed in both warm and cold areas.
•Only use plastic pipes.
Please refer to the installation film on www.separett.com
6,457
164
618
24,331
0,315
8
0,315
8
3,248
82,50
2,992
76
1,299
33
3,543
90
156
1,772
6,142
45
658
25,906
USA/CANADA
10580
3,54” (90mm)
17,95” (456mm)
26,46” (672mm)
1,10” (28mm)
2,36” (60mm)
21,3” (541mm)
17,32”
(440mm)
13,46”
(342mm)
6,30”
(160mm)
TECHNICAL DATA
•Model 9220

1
• First decide where you want to
install the urine outlet and
ventilation pipe together with
the waste pipe.
• If the urine outlet or ventilation
pipe pass through a wall, use the
dimensioned drawing in Figure B:
Ventilation pipe (1)
Urine outlet (2).
• If the unit is permanently installed
against a wall, please refer to the
dimensioned drawing in Figure B
(3).
ABC
Alt.1 Alt.2
x3
1
2
3
Art nr 11236-03
©SEPARETT AB 2007 SEPARETT is a registered trademark for Separett AB
Installation advice
4Drainpipes
• In the accessorie kit (not
included) there are parts to
connect the pipe about 1m
between the toilet and the
container.
The pipe is pushed up against the
funnel sitting in the toliet and is
sealed with silicone. (1)
The pipe is screwed underneath
the floor bottom with bracket and
screws. (2)
1
•2
1m
•
3
the pipe and the lid of the
container.This pipe can be
pushed up on the pipe and be
locked with knobs on each side. (3)
• The lower pipe is applied between
2Urine outlet AGreywater system BSoak-away CCollection
Separett®
EJEKTORTANK
50 cm
Stones
3Alt.CSeparett®ROOF FLASHING
Ventilation
Alt.D
1Alt.A, B& D
2Alt.B
Alt.A
Alt.C
for use with a 12 V fan. 2
• Horizontal pipes must be installed with
enough fall to ensure that any condensation
runs back towards the toilet.
Condensed water runs out through the
urine outlet.
1
•Silicon !
• The urine outlet (alternatives A,B
or C) must have a fall along its
entire length.
• Use pipes when the drain passes
through walls, floor, and for long
distances. A larger diameter pipe
is recommended for outdoor
installation.
• Winter use: For winter use,
increase the pipe diameter or
increase the pipe diameter to
Ø50-75 mm. It may be
necessary to add a heating loop
as well.
• Please ask the Environmental
Protection, Public Health and
Buildning departments about the
rules applicable to your area.
• Several components for alternative A
are included in the package.
• Pipes can be connected to pipes from
a previous toilet, minimum diameter
Ø55 mm.
• Alternatives A, B and C are recommended
50 cm

6Before use
Separett® BIO DRAIN CLEANER
USE • The fan should run continually.
AB C D
Alt.1
Alt.2
Compost
Art nr 11236-03
©SEPARETT AB 2007 SEPARETT is a registered trademark for Separett AB
PROCESSING WASTE MATERIAL
• Please ask the Environmental Protection, Public Health and Buildning departments about the rules applicable to your area.
If the toilet does not work
The Separett Villa has been made and tested for best possible function and reliability. If it does not work as intended, however,
please check the points below before contacting your dealer or Separett AB. NOTE! Disconnect the electric supply before doing anything else!
If ies have got into the toilet
1) Check that an insect net is installed.
2)Change to a new solid waste container. Use insecticide in the toilet and the bucket. Shut the fan off while the insecticide is
working. Repeat the treatment after a few days.
3) If the fan is shut off, the container must be lifted out. Flies will otherwise be attracted to the contents.
If there is a smell in the bathroom
1)Is the fan running?
2) Has the lter on the fan housing been cleaned?
3)Have the joints on the ventilation pipe and urine outlet been sealed with silicone sealer?
4) If there is a oor outlet, check that you have a correctly-functioning water trap.
5) Check that the insect net on the ventilation pipe mouth has been cleaned.
If the container lls up too fast
1)Be economical with paper.
2)If urine constantly ends up in the container, it will take up too much space.
If urine ends up in the container
1)Slide the seat forwards by undoing the yellow nuts underneath, which will allow the user to sit in a position that encourages the urine to end up in
the correct place.
If a smell occurs outdoors
1)Latrine smell. If urine ends up in the solid waste container there will be a latrine smell. Rectify this as above. We also recommend the use of
Separett Absorb, which helps to keep the contents dry and smell-free.
2) Wastewater odour. If the urine outlet is connected to the soak-away, a bad smell might come from it. Install a water trap (“U” pipe) on the urine
outlet.
If unwanted noise/vibration comes from the fan
1)Is the toilet correctly installed?
2) Clean the lter on the fan housing and the insect netting on the ventilation pipe mouth.
If the urine outlet is blocked
1)Use a drain unblocking preparation or a drain cleaning rod.
NOTE! Reduce the risk of deposits/blockage in the urine outlet by flushing with a small mug of water each time the toilet is used. We also recommend the
use of Separett Bio drain cleaner, a biological block that is put in the urine bowl. The block decomposes and the enzymes
counteract the problem of urine deposits in the waste pipe.
06 month
5
ABC
Check list

Product
Model
Serial no
Date purchased
Thank you for choosing a product from Separett AB. This
product has a 5 year warranty for manufacturing and/or
material faults (not labour). However, the
warranty does not cover normal wear and tear,
incorrect use or care, and if the customer has caused any
damage or modification to the product. If you have any
questions about spare parts or the warranty, please contact
the place where the product was purchased, or Separett’s
distributors. Please refer to the list at www.separett.com.
Do not forget to save your receipt!
Warranty
Art nr 11236-03
©SEPARETT AB 2007 SEPARETT is a registered trademark for Separett AB
www.separett.com
Separett®
Dear Customer!
IMPORTANT SAFEGUARDS
When using electricasl products, especially when children are present, basic safety precautions
should always be followed, including the following:
- READ ALL INSTRUCTIONS BEFORE USING -
Warning - To reduce the risk of burns, electrcution, re or injury to persons:
1) Never though cigarettes, cigarett butts or other burning or hot objects in the toliet.
2) Never put ngers inside fan openings.
3) Close supervision is necessary when this product is being used by or near children or
invalids.
4) Use this product only for its intended use as descibed in this manual.
Use only attachments recommended by the manufacturer.
5) Never block the air openings of the product or place it on a soft surface, such as bed or couch,
where the air openings may be blocked. Keep the air openings free of lint, hair and the like.
6) Never drop or insert any objects into ventilation openings.
7) Unplug this product before cleaning.
8) Never operate this product if it has a damaged cord or plug, if it is not workning properly,
if it has been dropped or damaged, or if it has been dropped into water.
Return the product to a service center for examination and repair.
9) Keep the cord away from heated surfaces.
10) Connect this product to a properly gounded outlet only.
11) Unplug this product before lling. Fill with water only, unless otherwise species by the
manufacturer. Do not overll.
- SAVE THESE INSTRUCTIONS -