Sharp AF-R125CX User manual

1
AF-R125CX
AIR CONDITIONER
S2204AFR125CX
SUPPLEMENTAL SERVICE MANUAL
AF-R125CX
MODEL
SHARP CORPORATION This document has been published to be used for after
sales service only.
The contents are subject to change without notice.
In the interest of user-safety the air conditioner should be restored to
itsoriginalconditionandonlypartsidenticaltothosespecifiedshould
be used.
This is supplemental Service Manual for Model AF-R125CX.
AF-R125CX are quite similar to base Model AF-R120CX. (Refer No.S2203AFR12CX/).
Use this supplemental manual together with the base Model Service Manual.
Refer to the base Model Servive Manual for complete operation, service information, etc.
Page
SPECIFICATIONS .................................................................................................................................................2
WIRING DIAGRAM................................................................................................................................................3
EXTERNAL DIMENSIONS ....................................................................................................................................3
OPERATION INSTRUCTIONS..............................................................................................................................4
REPLACEMENT PARTS LIST ..............................................................................................................................5
TABLE OF CONTENTS

2
AF-R125CX
Models AF-R125CX
Cooling capacity BTU/h 12000
Moisture removal Pints/h 3.3
ELECTRICAL DATA
Phase Single
Rated frequency Hz 60
Rated voltage Volts 115
Rated current Amps 11.5
Rated input Watts 1200
Power factor % 91
EER BTU/Wh 10.0
COMPRESSOR
Type (Hermetically sealed rotary type)
Model, Remarks 44B124HX1EF, 1000 W
REFRIGERANT SYSTEM
Evaporator Slit fin, Grooved tube, ø 9.53 mm Hair pin
Condenser Louver fin,Grooved tube,7mm Hair pin
Control O.D. x I.D. x Length x Q'ty(mm) Capillary tube 2.7 x 1.2 x 800 x 2
Refrigerant volume R-22(OZ) 19.4 (Factory charged)
NET DIMENSIONS
Width Height Depth inches(mm) 22-1/16(560) x 14-3/4(375) x 24-5/16(617)
Net Weight lbs 85
GROSS DIMENSIONS
Width Height Depth inches(mm) 25-25/32(655) x 18-29/32(480) x 27-7/8(708)
Gross Weight lbs 96
FAN SYSTEM
Indoor side(Evaporator) Centrifugal fan
Outdoor side(Condenser) Propeller fan
Air flow rate(indoor side) CFM (High/Med/Low) 318 / 254 / 219
OTHERS
Safety devices Compressor: Overload relay
Fan motor: Internal thermal protector
Air filter Polypropylene net
Power cord length ft 4.3
Power plug type 125V, 15A
ELECTRICAL PARTS
Running capacitor 370V-50µF
Fan capacitor 250V-6µF x 2
Thermistor 15k at 78˚F
Fan motor ARS030ZUEA/SHP(MLA895)
Overload relay MRA98693-12007
SPECIFICATIONS

3
AF-R125CX
OVERLOAD
PROTECTOR
A.C
M.C
CONNECTOR
HM
L
FAN MOTOR
CAPACITOR
250V 6µF x 2
FAN MOTOR
RUNNING
CAPACITOR
370V 50µF
THERMAL
PROTECTOR
BL
BL
BL
BLBK
BK
BK
BK
GY RE OR
WH
COMPRESSOR
MOTOR
BK
BL
RE
WH
GR
GY
OR
: BLACK
: BLUE
: RED
: WHITE
: GREEN
: GRAY
: ORANGE
POWER SUPPLY CORD
115V 60Hz
3A 125V
IN
GR MRY CONTROL
BOAD UNIT
NR
C1
CN1
CN2
CN3
TR
OUT
RIBBED
NON RIBBED
BK
BK
C
R
RE
WH
GY
BCN1
BCN2
BCN3
WH
OR
RE
GY
S
FU1
123654
WIRE COLOR
YELLOW TH1
RY3
RY2
RY1
CNR3
CNR2
CNR1
THERMISTOR
(ROOM TEMP)
8
7
1
3
5
DISPLAY
BOARD
UNIT
Figure W-1
WIRING DIAGRAM
EXTERNAL DIMENSIONS
24-5/16"
5-3/16"
14-3/4"
19/32" 1-3/8"
16-23/32"
22-1/16"
38-19/32"
27-5/32"

4
AF-R125CX
OPERATION INSTRUCTIONS
8
12
1
2
3
456
7
9
10
11
1
UNIT
CONTROL PANEL
Front panel
2 Air inlet (Indoor side)
3 Louvers
4 Air inlet (Outdoor side)
5 Exhaust lever
6 Control panel
7 Cabinet
8 Air outlet (Outdoor side)
9 Air inlet (Outdoor side)
10 Filter (Pull the filter handle to the right to remove.)
11 Filter handle
12 Power cord
1 Selector indicator
2 Receiver window for remove control
signal
3 Display
4 SELECTOR pad
5 TIMER ON/OFF pad
6 TIMER indicator
7 TEMPERATURE setting pad
Lower temp.
Raise temp.
8 ENEGRY SAVER pad
9 ENEGRY SAVER indicator
10 POWER ON/OFF pad
11 POWER indicator
HIGH COOL
MED COOL
LOW COOL
FAN ONLY
SELECTOR
ENERGY
SAVER
POWER
ON/OFF
TEMP
F
hr
TIMER
ON/OFF
1 2 3
4 5 6 7 8 9 10 11

5
AF-R125CX
REPLACEMENT PARTS LIST
CABINET AND UNIT PARTS
1- 1 CMOTLA895JBEZ Fan motor 1 BN
1- 2 DCHS-A440JBTA Base pan ass’y 1 BC
1- 3 DCAB-A094JBTA Cabinet ass’y 1 BF
1- 4 PSEL-B150JBE0 Cabinet seal 2 AD
1- 5 HPNLCA770JBFB Control panel 1 AF
1- 6 PSEL-C059JBEZ Evaporator insulator 1 AD
1- 7 LANG-A459JBWZ Conecting stay 1 AC
1- 8 LANG-A355JBTA Top inst. Angle 1 AP
1- 9 LHLD-A482JBFZ Thermistor holder 1 AE
1-10 CLEV-A039JBKZ Damper ass’y 1 AG
1-11 NFANPA092JBFZ Propeller fan 1 AV
1-12 NFANSA030JBFZ Centrifugal fan 1 AU
1-13 PFILMA116JBEC Air filter 1 AN
1-14 PFPFPB466JBE0 Insulator 2 AC
1-15 PKESPA082JBTA Condenser shroud 1 AV
1-16 PKESPA083JBFA Orifice 1AQ
1-17 LBND-A046JBE0 Wire fixing band 1 AE
1-18 LCOV-A002JBF0 Shroud cover 1 AM
1-19 PCOV-A320JBP0 Motor cover 1 AC
1-20 PSEL-C057JBEZ Tube insulator 1 AD
1-21 LANG-A356JBTA Bottom inst. angle 1 AE
1-22 PSKR-A207JBFA Bulkhead 1 BA
1-23 PSRA-A120JBFZ Drain tray 1 AE
1-24 TLAB-C276JBRZ Energy card 1 AC
1-25 TSPC-E154JBRZ Name badge 1 AC
1-26 GWAKPA136JBFC Louver duct 1 AL
1-27 GWAKPA135JBFC Front panel 1 AX
1-28 TLABBA110JBRA SHARP badge 1 AB
1-29 LANGAA038JBFB Left closure frame 1 AK
1-30 LANGAA039JBFB Right closure frame 1 AK
1-31 PPLTPA013JBFB Closure 2AL
1-32 PSPRCA010JBE0 Spring 1AD
1-33 TLABKA564JBE0 Number card 1 AC
1-34 PFPFPB446JBE0 Insulator 1 AC
1-35 CWAK-C132JBKZ Front panel ass’y 1 AZ
1-36 MJNTPA074JBFC Louver link 2 AC
1-37 MLOV-A252JBFC Vertical louver A 4 AC
1-38 MLOV-A253JBFC Vertical louver B 2 AC
1-39 PSEL-B360JBE0 Cabinet insulator 1 AB
1-40 PSEL-C064JBEZ Drain tray insulator 1 AC
1-41 PSEL-B361JBE0 Cabinet insulator 2 AE
1-42 PSEL-B367JBE0 Cabinet insulator 2 AC
1-43 PSEL-B516JBE0 Base pan insulator 2 AC
1-44 PFPFPB443JBE0 Insulator 1 AC
1-45 PSEL-C063JBEZ Bulkhead insulator 1 AC
1-46 PSEL-B519JBE0 Angle insulator 1 AD
1-47 PSEL-C056JBEZ Motor seal 1 AE
1-48 LHLDW0367JBE0 Wire holder 1 AA
1-49 LHLDW0368JBE0 Wire holder 1 AA
1-50 PFPFPB528JBE0 Panel insulator 1 AD
1-51 PSEL-A432JBE0 Damper insulator 1 AC
1-52 PFPFPB611JBE0 Insulator 1 AG
1-53 PSEL-B532JBE0 Damper insulator 1 AB
1-54 PSEL-B394JBE0 Panel insulator 1 AB
1-55 PSEL-B560JBE0 Damper insulator 1 AB
1-56 LANG-A507JBWZ Fan motor angle 1 AH
1-57 HPNLCA828JBEA Decoration panel 1 AD
1-58 PSEL-B366JBE0 Panel insulator 1 AD
1-59 PSEL-C104JBEZ Insulator 1 AB
1-60 PSEL-C105JBEZ Cabinet insulator 1 AE
1-61 LHLDW0363JBE0 Wire holder 1 AA
1-62 PSHE-A191JBEZ Sheet 1AE
1-63 LHLD-A356JBE0 Wire holder 1 AE
CONTROL BOX PARTS
2- 1 LBNDKA096JBWZ Capacitor clamp 1 AC
2- 2 LPLTMA128JBW0 Control box cover 1 AK
2- 3 DPLT-A047JBW0 Cont. box angle ass’y 1 AS
REF. NO. PART NO. DESCRIPTION Q'TY CODE

6
AF-R125CX
REF. NO. PART NO. DESCRIPTION Q'TY CODE
2- 4 QACC-A263JBZZ Power supply cord 1 AT
2- 5 RH-HXA011JBZZ Thermistor 1 AL
2- 6 QW-VZD104JBE0 Lead wire 1 AD
2- 7 QW-IZA036JBZZ Lead wire 1 AS
2- 8 RC-HZA256JBE0 Fan motor capacitor 2 AM
2- 9 RC-HZA407JBZZ Running capacitor 1 AY
2-10 TLABCB377JBRZ Wiring diagram 1 AC
2-11 DPWBFA193JBKZ Control board unit 1 BC
2-12 PSPA-A084JBE0 Spacer 2AC
2-13 PSPA-A085JBE0 Spacer 1AC
2-14 QFS-AA048JBE0 Fuse 1AB
2-15 LBND-A042JBE0 Wire fixing band 4 AC
CYCLE PARTS
3- 1 PCMPRA359JBEZ Compressor 1 CC
3- 2 PPIPCF655JB1Z Discharge tube 1 AR
3- 3 PPIPCF654JB1Z Suction tube 1 AS
3- 4 RHOG-A198JBZZ Overload relay 1 AT
3- 5 DCON-A167JBKZ Condenser ass’y 1 BT
3- 6 PEVA-A424JBEZ Evaporator 1 BQ
3- 7 GLEG-A105JBE0 Compressor cushion 3 BQ
3- 8 LPLTMA114JBW0 Condenser stay 2 AH
3- 9 PCOV-A321JBE0 Terminal cover 1 AR
3-10 PSEL-A971JBE0 Terminal gasket 1 AN
3-11 DCPY-A234JBKZ Capillary tube ass’y 1 AW
3-12 MSPR-A129JBE0 Cycle spring 1 AD
3-13 PGUM-0034JBE0 Damper rubber 1 AF
3-14 MSPR-A136JBE0 Protector spring 1 AF
ACCESSORY PARTS
4- 1 TINSEA320JBRZ Operation manual 1 AD
4- 2 PSEL-A349JBE0 Window insulator 1 AE
4- 3 PSEL-A350JBE0 Window insulator 1 AD
4- 4 PSEL-B365JBE0 Window insulator 1 AD
4- 5 TCAD-A351JBEZ Consummer card 1 AB
4- 6 DX-BZA027JBK0 Screws kit 1 AE
4- 7 CRMC-A526JBEZ Remote control 1 AT
4- 8 LHLD-A389JBFB Controller holder 1 AE
4- 9 SSAKAA017YDE0 Bag 1AC
4-10 UBATUA027JBE0 Battery pack 1 AE
PACKING PARTS
5- 1 CPADBA688YDK0 Top pad ass’y 1 AL
5- 2 CPADBA009JBK0 Bottom pad ass’y 1 AT
5- 3 SPAKCB066JBEZ Packing case 1 AY
5- 4 SSAKHA314YDE0 Protect 1AD
5- 5 PPAK-A007JBE0 Inner packing 1 AG
5- 6 TLABMA333JBRZ Color label 1 AC
5- 7 SSAKAA053YDE0 Bag 1AB
5- 8 TLABMA309JBRZ Feature card 1 AB
SCREWS AND NUTS
6- 1 XTTSD40P12000 Tapping screw 22 AA
6- 2 LX-BZA236JBE0 Special screw 1 AC
6- 3 XHTSD40P08000 Tap tight screw 8 AA
6- 4 LX-NZA136JBE0 Special nut 1 AL
6- 5 LX-HZA001JBE0 Special screw 6 AB
6- 6 XCTSD40P10000 Tapping screw 19 AA
6- 7 LX-NZA074JBE0 Special nut 1 AB
6- 8 LX-NZA028JBE0 Special nut 3 AB
6- 9 XTPSD40P08000 Tapping screw 3 AA
6-10 XCTSD40P06000 Tapping screw 16 AA
6-11 XBPSD40P12J00 Machine screw 2 AB
6-12 LX-CZA038WRE0 Special screw 6 AA
6-13 XHTSD40P10000 Tap tight screw 2 AA
6-14 XTPSD40P12000 Tapping screw 2 AA
HOW TO ORDER REPLACEMENT PARTS
To have your order filled promptly and correctly, please furnish the following information.
1. MODEL NUMBER 2. REF. NO.
3. PART NO. 4. DESCRIPTION

7
AF-R125CX
5-4
6-6
1-38
1-38
1-37
1-37
1-36
1-27
1-10
1-55 1-53
1-51
1-16
1-12
1-22
1-1
1-7
1-39
1-49
1-8
1-28
1-3
1-25
1-2
1-23
1-11
1-21
1-48
1-35
1-26
1-32
1-50
1-58
6-2
5-8
6-1
6-12
1-14
1-14
1-4
1-4
6-10
6-1 6-1
1-63
6-6
6-1
6-1
6-12
6-1 6-12
6-6
6-6
6-12
6-6
6-5
6-5
6-5
6-6
1-18
1-15
6-6
6-6
6-12
6-7
6-1
6-5
6-6 1-19
6-6
6-5
6-1
1-20
1-45
1-59
1-34
1-52
1-60
1-13
1-62
1-54
1-6
1-17
1-47
1-40
1-43
1-43
1-46
1-42
1-41
1-41
4-6
4-5
4-7
4-8
4-4
5-5
5-3
1-33
1-24
5-6
5-2 5-1
5-7
2-4
1-30
4-2
4-3
4-1
4-10
4-9 1-29
1-31
1-42
1-56
1-56
6
45
123
6
45
123
A
B
C D E F
G H
A
B
C D E F
G H
CABINET PARTS

8
AF-R125CX
6
45
123
6
45
123
A
B
C
D
E
F
G
H
A
B
C
D
E
F
G
H
CONTROL BOX PARTS
2002 SHARP CORP. (2S1.600E) Printed in U.S.A.
CYCLE PARTS
2-10
6-3
2-2 2-14 6-3
6-3
6-3
6-3
6-13
2-11
6-9
1-5
1-57
2-3
2-12
2-4
2-6
2-4
2-15
6-11
6-1
6-14
6-3
2-7
2-9
2-1
2-8
2-13
3-12
3-13
3-1
3-7 6-8
3-3
3-6
6-1
6-3
2-6
6-1
6-1
1-9
2-5
6-1
1-61
3-4
3-14
3-10
1-44
3-9
6-4
3-2
3-5
3-8
6-10
6-10
6-10
2-7
3-11