Siemens CZM-4 User manual

P/N 315-090726-12
OPERATION
The Model CZM-4 Conventional Zone Module from
Siemens Building Technologies, Inc. is used with the
MXL to provide four Class A (Style D) or Class B
(Style B) conventional initiating device circuits. Each
circuit can monitor up to thirty 2-wire photoelectric or
ionization smoke detectors and an unlimited number
of normally open contact devices. Projected beam
and flame detectors, detector relay bases, and
remote indicator lamps may also be used with the
CZM-4.
Activation of any device on the circuit initiates
a zone alarm and causes any previously pro-
grammed functions to operate. Any circuit in
alarm or trouble condition is identified by a user-
specified, 32-character, alphanumeric message
displayed on the MXL LCD annunciator.
The CZM-4 is designed to function in a local de-
grade mode during failure of the MXL main proces-
sor or during the loss of the System communication
network. While in the degrade mode, the CZM-4 can
report both alarm and trouble conditions and can
activate local outputs on other modules within the
same enclosure.
Note: When verification is used on a CZM-4
zone, do not use shorting devices on
that circuit.
Any or all of the CZM-4 circuits may be programmed
to operate with Alarm Verification.
This allows the automatic verification of alarm
conditions caused by smoke detectors in order to
prevent nuisance alarms.
The CZM-4 has five LEDs which indicate alarm,
transmit, trouble, and two user programmable
functions, respectively.
For additional information on the MXL/MXLV
System, refer to the MXL/MXLV Manual, P/N 315-
092036.
INSTALLATION
Remove all system power before installation,
first battery and then AC. (To power up, first
connect the AC and then the battery.)
The CZM-4 module plugs into two half-width slots,
forming one full slot on the MOM-4 (See Figure 1).
As many as two CZM-4 modules may be plugged
into a MOM-4 Card Cage.
Each CZM-4 can be in either the upper or lower
slots of the MOM-4. The position it is in deter-
mines whether the device loops are on TB1 or
TB2 of the MOM-4.
Setting the Address
Before the CZM-4 is installed into the MOM-4,
set the network address on switch S1 (See
Figure 2). Set the address to the one selected in
the CSG-M for this particular CZM-4. Follow the
switch positions in Table 1 on the back to set
the address.
Installation Instructions
Model CZM-4
Conventional Zone Module
Fire Safety
Siemens Building Technologies, Inc.
8 Fernwood Road
Florham Park, New Jersey 07932
Siemens Building Technologies, Ltd.
2 Kenview Boulevard
Brampton, Ontario L6T 5E4 Canada

2
Mounting the CZM-4
After the address is set, install the CZM-4 into the
MOM-4 module, being sure that the CZM-4 is firmly
seated in the card edge connector.
ELECTRICAL RATINGS
tnerruCeludoMCDV5evitcAAm01
tnerruCeludoMCDV42evitcA Am081+Am54
enozevitcarep
tnerruCeludoMCDV42ybdnatSAm05
Initiating Circuits
Voltage range: 21.7-22.8 V unfiltered
full wave
Supervisory circuit: 4mA max
Alarm current: 180mA per zone max
INITIATING DEVICES
Up to 30 detectors, listed in Table 2 (except the
PBA-1191), may be used on a CZM-4 zone. Manual
fire alarm stations and smoke detectors can be
mixed on zones where local codes allow. Detectors
of different models are not to be mixed or matched
Figure 1
MOM-4 PC Board
2ELBAT
4-MZCROFSROTCETEDELBITAPMOC
rotceteDesaB
noitallatsnI
snoitcurtsnI
rebmuNtraP
*H3/3-IDS3-BD349180-513
*H3A/3A-IDS3-BD349180-513
*H3B/3B-IDPLI
3/I3-DA
I3-AS
432390-513
472690-513
‡*11-TD11-BD
TPDA-BD+S3-BD
924590-513
924590-513
†1911-ABP1911-BBP424590-513
*T3/3-EP*53-BD
PLI3-DA
PR3-DA
578090-513
432390-513
195680-513
*T11/11-EP11-BD
TPDA-BD+S3-BD
RP11/P11-DA
P11-AS
8
91490-513
891490-513
956590-513
472690-513
.1911-ABPtubepytynafosrotceted03otpuesuyaM*
.noitacifirevmralahtiwesutonoD‡
.)3erugiFeeS(enozrep1911-AB
PenoylnO†
on a system. Up to five waterflow switches and any
number of direct shorting thermal detectors also may
be used with each zone on the CZM-4. Only one
PBA-1191 may be used on a zone. The model
numbers listed are the UL compatibility identifiers.

3
Refer to Figure 3. All circuits are power limited to
NFPA 70 per NEC 760. Each detector or group
of detectors must use a 2-wire circuit of at least
18 AWG, thermoplastic fixture wire, enclosed in
conduit. If permitted by local building codes, 18
AWG limited energy, shielded cable without conduit
may also be used.
Total circuit resistance must not exceed 70
ohms—40 ohms if relay bases are used.
NOTES:
1. All circuits can be Class A or Class B.
2. All circuits are power limited per NEC 760.
3. All circuits are supervised.
4. Do not connect more than one PBA-1911 to each zone. (Refer to PBA-1191 Instructions,
P/N 315-095424, for further information.)
5. Do not mix smoke detectors with the PBA-1191.
6. Maximim resistance: 70 ohms/circuit.
7. The PBA-1191 requires Rev. 3 or higher of CZM-4 software.
8. Positive and negative ground fault detected at <20 ohms for terminals 1-16.
Figure 2
CZM-4 PC Board
Figure 3
Wiring Diagram
Refer to Wiring Specification for
MXL, MXL-IQ and MXLV
Systems, P/N 315-091772
revision 6 or higher, for
additional wiring information.

P/N 315-090726-12
TA B L E 1
NETWORK ADDRESS PROGRAMMING
ADDR 87654321 ADDR 87654321 ADDR 87654321 ADDR 87654321
000 ILLEGAL 064 OXOOOOOO 128 XOOOOOOO 192 XXOOOOOO
001 ILLEGAL 065 OXOOOOOX 129 XOOOOOOX 193 XXOOOOOX
002 ILLEGAL 066 OXOOOOXO 130 XOOOOOXO 194 XXOOOOXO
003
004
005
006
007
008
009
010
011
012
013
014
015
016
017
018
019
020
021
022
023
024
025
026
027
028
029
030
031
032
033
034
035
036
037
038
039
040
041
042
043
044
045
046
047
048
049
050
051
052
053
054
055
OOOOOOXX
OOOOOXOO
OOOOOXOX
OOOOOXXO
OOOOOXXX
OOOOXOOO
OOOOXOOX
OOOOXOXO
OOOOXOXX
OOOOXXOO
OOOOXXOX
OOOOXXXO
OOOOXXXX
OOOXOOOO
OOOXOOOX
OOOXOOXO
OOOXOOXX
OOOXOXOO
OOOXOXOX
OOOXOXXO
OOOXOXXX
OOOXXOOO
OOOXXOOX
OOOXXOXO
OOOXXOXX
OOOXXXOO
OOOXXXOX
OOOXXXXO
OOOXXXXX
OOXOOOOO
OOXOOOOX
OOXOOOXO
OOXOOOXX
OOXOOXOO
OOXOOXOX
OOXOOXXO
OOXOOXXX
OOXOXOOO
OOXOXOOX
OOXOXOXO
OOXOXOXX
OOXOXXOO
OOXOXXOX
OOXOXXXO
OOXOXXXX
OOXXOOOO
OOXXOOOX
OOXXOOXO
OOXXOOXX
OOXXOXOO
OOXXOXOX
OOXXOXXO
OOXXOXXX
067
068
069
070
071
072
073
074
075
076
077
078
079
080
081
082
083
084
085
086
087
088
089
090
091
092
093
094
095
096
097
098
099
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
OXOOOOXX
OXOOOXOO
OXOOOXOX
OXOOOXXO
OXOOOXXX
OXOOXOOO
OXOOXOOX
OXOOXOXO
OXOOXOXX
OXOOXXOO
OXOOXXOX
OXOOXXXO
OXOOXXXX
OXOXOOOO
OXOXOOOX
OXOXOOXO
OXOXOOXX
OXOXOXOO
OXOXOXOX
OXOXOXXO
OXOXOXXX
OXOXXOOO
OXOXXOOX
OXOXXOXO
OXOXXOXX
OXOXXXOO
OXOXXXOX
OXOXXXXO
OXOXXXXX
OXXOOOOO
OXXOOOOX
OXXOOOXO
OXXOOOXX
OXXOOXOO
OXXOOXOX
OXXOOXXO
OXXOOXXX
OXXOXOOO
OXXOXOOX
OXXOXOXO
OXXOXOXX
OXXOXXOO
OXXOXXOX
OXXOXXXO
OXXOXXXX
OXXXOOOO
OXXXOOOX
OXXXOOXO
OXXXOOXX
OXXXOXOO
OXXXOXOX
OXXXOXXO
OXXXOXXX
131
132
133
134
135
136
137
138
139
140
141
142
143
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
181
182
183
XOOOOOXX
XOOOOXOO
XOOOOXOX
XOOOOXXO
XOOOOXXX
XOOOXOOO
XOOOXOOX
XOOOXOXO
XOOOXOXX
XOOOXXOO
XOOOXXOX
XOOOXXXO
XOOOXXXX
XOOXOOOO
XOOXOOOX
XOOXOOXO
XOOXOOXX
XOOXOXOO
XOOXOXOX
XOOXOXXO
XOOXOXXX
XOOXXOOO
XOOXXOOX
XOOXXOXO
XOOXXOXX
XOOXXXOO
XOOXXXOX
XOOXXXXO
XOOXXXXX
XOXOOOOO
XOXOOOOX
XOXOOOXO
XOXOOOXX
XOXOOXOO
XOXOOXOX
XOXOOXXO
XOXOOXXX
XOXOXOOO
XOXOXOOX
XOXOXOXO
XOXOXOXX
XOXOXXOO
XOXOXXOX
XOXOXXXO
XOXOXXXX
XOXXOOOO
XOXXOOOX
XOXXOOXO
XOXXOOXX
XOXXOXOO
XOXXOXOX
XOXXOXXO
XOXXOXXX
195
196
197
198
199
200
201
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
218
219
220
221
222
223
224
225
226
227
228
229
230
231
232
233
234
235
236
237
238
239
240
241
242
243
244
245
246
247
XXOOOOXX
XXOOOXOO
XXOOOXOX
XXOOOXXO
XXOOOXXX
XXOOXOOO
XXOOXOOX
XXOOXOXO
XXOOXOXX
XXOOXXOO
XXOOXXOX
XXOOXXXO
XXOOXXXX
XXOXOOOO
XXOXOOOX
XXOXOOXO
XXOXOOXX
XXOXOXOO
XXOXOXOX
XXOXOXXO
XXOXOXXX
XXOXXOOO
XXOXXOOX
XXOXXOXO
XXOXXOXX
XXOXXXOO
XXOXXXOX
XXOXXXXO
XXOXXXXX
XXXOOOOO
XXXOOOOX
XXXOOOXO
XXXOOOXX
XXXOOXOO
XXXOOXOX
XXXOOXXO
XXXOOXXX
XXXOXOOO
XXXOXOOX
XXXOXOXO
XXXOXOXX
XXXOXXOO
XXXOXXOX
XXXOXXXO
XXXOXXXX
XXXXOOOO
XXXXOOOX
XXXXOOXO
XXXXOOXX
XXXXOXOO
XXXXOXOX
XXXXOXXO
XXXXOXXX
056 OOXXXOOO 120 OXXXXOOO 184 XOXXXOOO 248 ILLEGAL
057 OOXXXOOX 121 OXXXXOOX 185 XOXXXOOX 249 ILLEGAL
058 OOXXXOXO 122 OXXXXOXO 186 XOXXXOXO 250 ILLEGAL
059 OOXXXOXX 123 OXXXXOXX 187 XOXXXOXX 251 ILLEGAL
060 OOXXXXOO 124 OXXXXXOO 188 XOXXXXOO 252 ILLEGAL
061 OOXXXXOX 125 OXXXXXOX 189 XOXXXXOX 253 ILLEGAL
062 OOXXXXXO 126 OXXXXXXO 190 XOXXXXXO 254 ILLEGAL
063 OOXXXXXX 127 OXXXXXXX 191 XOXXXXXX 255 ILLEGAL
O = OPEN (or OFF) X = CLOSED ( or ON)