Siemens Sirius 3RS1440 User manual

SIRIUS
Temperaturüberwachungsrelais für IO-Link
Temperature monitoring relay for IO-Link
Relais thermostatique pour IO-Link
Relé de vigilancia/monitorización de temperatura para IO-Link
Relè di controllo temperatura per IO-Link
Relé de controle de temperatura para IO-Link
IO-Link için sıcaklık denetleme rölesi
Реле контроля температуры c IO-Link
适用于 IO-Link 的温度监视继电器
3RS1440
3RS1441
3RS1540
Betriebsanleitung Operating Instructions Instructions de service Instructivo Istruzioni operative
Instruções de Serviço İşletme kılavuzu Инсрукция по эксплуатации 使用说明
A5E02792455000B-02 Last update: 22 June 2011
3ZX1012-0RS20-1AA1
Deutsch English Français
Vor der Installation, dem Betrieb oder der
Wartung des Geräts muss diese Anleitung
gelesen und verstanden werden.
Read and understand these instructions
before installing, operating, or maintaining
the equipment.
Ne pas installer, utiliser ou intervenir sur cet
équipement avant d'avoir lu et assimilé les
présentes instructions et notamment les
conseils de sécurité et mises en garde qui y
figurent.
GEFAHR DANGER DANGER
Gefährliche Spannung.
Lebensgefahr oder schwere
Verletzungsgefahr.
Vor Beginn der Arbeiten Anlage und Gerät
spannungsfrei schalten.
Hazardous voltage.
Will cause death or serious injury.
Turn off and lock out all power supplying this
device before working on this device.
Tension électrique.
Danger de mort ou risque de blessures
graves.
Mettre hors tension avant d’intervenir sur
l’appareil.
VORSICHT CAUTION PRUDENCE
Eine sichere Gerätefunktion ist nur mit
zertifizierten Komponenten gewährleistet. Reliable functioning of the equipment is only ensured with certified components.
La sécurité de fonctionnement de l'appareil
n'est garantie qu'avec des composants
certifiés.
Español Italiano Português
Leer y comprender este instructivo antes de
la instalación, operación o mantenimiento
del equipo.
Leggere con attenzione queste istruzioni
prima di installare, utilizzare o eseguire
manutenzione su questa apparecchiatura.
Ler e compreender estas instruções antes
da instalação, operação ou manutenção do
equipamento.
PELIGRO PERICOLO PERIGO
Tensión peligrosa.
Puede causar la muerte o lesiones
graves.
Desconectar la alimentación eléctrica antes
de trabajar en el equipo.
Tensione pericolosa.
Può provocare morte o lesioni gravi.
Scollegare l’alimentazione prima di
eseguire interventi sull'apparecchiatura.
Tensão perigosa.
Perigo de morte ou ferimentos graves.
Desligue a alimentação elétrica e proteja
contra o religamento, antes de iniciar o
trabalho no equipamento.
PRECAUCIÓN CAUTELA CUIDADO
El funcionamiento seguro del aparato sólo
está garantizado con componentes
certificados.
Il funzionamento sicuro dell'apparecchiatura
è garantito soltanto con componenti
certificati.
O funcionamento seguro do aparelho
apenas pode ser garantido se forem
utilizados os componentes certificados.
Türkçe Русский 中文
Cihazın kurulumundan, çalıştırılmasından
veya bakıma tabi tutulmasından önce, bu
kılavuzun okunmuşve anlaşılmışolması
gerekmektedir.
Перед установкой, вводом в
эксплуатацию или обслуживанием
устройства необходимо прочесть и
понять данное руководство.
安装、使用和维修本设备前必须先阅
读并理解本说明。
TEHLİKE ОПАСНО 危险
Tehlikeli gerilim.
Ölüm tehlikesi veya ağır yaralanma
tehlikesi.
Çalışmalara başlamadan önce, sistemin ve
cihazın gerilim beslemesini kapatınız.
Опасное напряжение.
Опасность для жизни или
возможность тяжелых травм.
Перед началом работ отключить подачу
питания кустановке икустройству.
危险电压。
可能导致生命危险或重伤危险。
操作设备时必须确保切断电源。
ÖNEMLİDİKKAT ОСТОРОЖНО 小心
Cihazın güvenli çalışmasıancak sertifikalı
bileşenler kullanılmasıhalinde garanti
edilebilir.
Безопасность работы устройства
гарантируется только при использовании
сертифицированных компонентов.
只有使用经过认证的部件才能保证设
备的正常运转。
!
!
!
!
!
!
!
!
!
Technical Assistance: Telephone: [phone] (8°° - 17°° CET) SIEMENS AG
Fax: [phone] Technical Assistance
E-mail: technical-assistanc[email protected] Würzburger Str. 121
Internet: www.siemens.com/industrial-controls/technical-assistance D-90766 Fürth
s

23ZX1012-0RS20-1AA1
DE Montage ES Montaje TR Montaj
EN Assembly IT Montaggio РУ Монтаж
FR Montage PT Montagem 中文 安装
DE Anschließen ES Conexión TR Bağlantı
EN Connect IT Collegamento РУ Подключение
FR Branchement PT Conexão 中文 连接
3RP1903
1. U = 0 V
2. a, b, c, d
A
C
D
B
c
d
a
b
3RS1901-1A/1C: 3RS1440/1540
3RS1901-1B/1D: 3RS1441
0,5 mm
3,0 mm
Ø 3,0 x 0,5 [mm]
ar




3RS1...-1... 3RS1...-2...
∅5 ... 6 mm / PZ2
0,8 ... 1,2 Nm
7 to 10.3 lb in —
1 x 0,5 ... 4,0 mm²
2 x 0,5 ... 2,5 mm² 2 x 0,25 ... 1,5 mm²
2 x 0,5 ... 1,5 mm²
1 x 0,5 ... 2,5 mm² 2 x 0,25 ... 1,5 mm²
— 2 x 0,25 ... 1,5 mm²
AWG 2 x 20 to 14 2 x 24 to 16
10
10
10
DE Kodiert
EN Coded
FR Codé
ES Cifrado
IT Codificato
PT Codificado
TR Kodlanmış
РУ Кодировки
中文 带编码的
A
C
D
B
A, B, C, D:

3ZX1012-0RS20-1AA1 3
L+ CL-
28NO 26NC
25C 36NC
IO-LinkIO-Link
22
11
3RS1440-1HB50
RUNRUN
22
11
HYSTERESISHYSTERESIS
DELAYDELAY
CIRCUIT PRIN.:CIRCUIT PRIN.:
OPENOPEN
CLOSEDCLOSED
WINDOWWINDOW
OVEROVER
UNDERUNDER
MODE:MODE:
SENSOR TYPESENSOR TYPE
38NO 35C
T3
T2
Y4
Y3
T1
SIRIUS
18NO 15C 16NC
28NO 26NC
25C 36NC38NO 35C
Y4
Y3
L+ CL- 18NO 15C 16NC
IO-LinkIO-Link
22
11
3RS1441-1HB50
22
11
HYSTERESISHYSTERESIS
DELAYDELAY
CIRCUIT PRIN.:CIRCUIT PRIN.:
OPENOPEN
CLOSEDCLOSED
WINDOWWINDOW
OVEROVER
UNDERUNDER
MODE:MODE:
SENSOR TYPESENSOR TYPE
1T2 1T3 2T1 2T2 2T3
3T1 3T2 3T3
1T1
SIRIUS
RUN
STATUS
SENSOR NO.
L+ CL-
28NO 26NC
25C 36NC
IO-LinkIO-Link
22
11
3RS1540-1HB80
RUNRUN
22
11
HYSTERESISHYSTERESIS
DELAYDELAY
CIRCUIT PRIN.:CIRCUIT PRIN.:
OPENOPEN
CLOSEDCLOSED
WINDOWWINDOW
OVEROVER
UNDERUNDER
MODE:MODE:
SENSOR TYPESENSOR TYPE
38NO 35C
T+
Y4
Y3
T-
SIRIUS
18NO 15C 16NC
1
Hyst
2
Hyst
Y3
AUTORESET
1 > 2
Y4
RESET
Y3 Y4
35
38
35
38
K3
K3
36
36
LED 1
LED 2
15/18
15/16
Delay
25/28
25/26
Delay
LED 1
LED 2
15/18
15/16
Delay
25/28
25/26
Delay
3RS1440 / 1441
xT2
xT1 xT3 3 x max.
1 x
ϑ
xT2
xT1 xT3
ϑ
3RS1540
T– T+
TC
ϑ

43ZX1012-0RS20-1AA1
DE Menüführung / Inbetriebnahme ES Guía menú / P. en servicio TR Menü yardımı
EN Menu-based operation / Startup IT Guida menu / Messa in servizio РУ Меню параметрирования
FR Guidage par menu / Mise en
service PT Guia de menu / Acionamento 中文 菜单导航
3RS1440
Default
3RS1441
Default
3RS1540
Default
3RS1440 / 3RS1441 3RS1540
BETRIEB
RUN
MARCHE
MARCHA
FUNZIONAMENTO
OPERAÇÃO
İşletim
Рабочий режим
运行
Aktueller Messwert
Actual measured value
Mesure actuelle
Valor medido actual
Valore attuale di misura
Valor medido atual
Güncel ölçüm değeri
Текущее измеряемое значение
实际测量值
ϑ1
80 °C/176 °F 80 °C/176 °F 80 °C/176 °F
Warngrenzwert für ϑ11)
Warning limit for ϑ 1
1)
Seuil d'alarme pour ϑ 1
1)
Valor límite de aviso para ϑ 1
1)
Valore limite di avviso per ϑ 1
1)
Val. lim. para advertência para ϑ 1
1)
ϑ 1 için ikaz eşik değeri
1)
Предельное значение предуп-
реждения для
ϑ 1
1 )
ϑ1 的警告限值 1)
75°C/167 °F 75 °C/167 °F 75 °C/167 °F
ϑ2
50 °C/122 °F 50 °C/122 °F 50 °C/122 °F
Warngrenzwert für ϑ21)
Warning limit for ϑ21)
Seuil d'alarme pour ϑ21)
Valor límite de aviso para ϑ21)
Valore limite di avviso per ϑ21)
Val. lim. para advertência para ϑ21)
ϑ2 için ikaz eşik değeri1)
Предельное значение предуп-
реждения для ϑ21)
ϑ2 的警告限值 1)
45 °C/113 °F 45 °C/113 °F 45 °C/113 °F
HYSTERESE
HYSTERESIS
HYSTERESIS
HISTÉRESIS
ISTERESI
HISTERESE
HİSTEREZİS
ГИСТЕРЕЗИС
滞后
5 °C/5 °F 5 °C/5 °F 5 °C/5 °F
Power On (A1,A2)
3
1
2
4—> RUN
ϑ1, ϑ2, HYSTERESIS, DELAY, CIRCUIT PRIN.,
MODE, SENSORTYPE, SENSOR NO.: STATUS
nur / only / seulement / sólo / solo / apenas / sadece / только / 仅限
3RS1441
ϑ
1 x
ϑϑϑ
3 x max.
1 x
TC ϑ
2
4
3
°C
°F
°C
°C
°F °F
°C
°C
°F°F
°C
°C
°F °F
°C
°C
°F°F
°C
°C
°F °F
°C
°C
°F°F
°C
°C
°F °F
°C
°C
°F°F
°F
°F
°C °C
1) nur IO-Link / only IO-Link / seulement IO-Link / sólo IO-Link / solo IO-Link / apenas IO-Link/ sadece IO-Link / только для стандарта IO-Link / 仅限 IO-Link

3ZX1012-0RS20-1AA1 5
VERZ.-ZEIT
DELAY
TEMPORISATION
TEMPORIZACIÓN
TEMPORIZZAZIONE
TEMPO RETARD.
GECİKM.SÜRE.
Время задежки
延迟
Sekunden
Seconds
Secondes
Segundos
Secondi
Segundos
Saniye
Секунды
秒
000
STROMPRINZIP
CIRCUIT PRIN.
MONTAGE
TIPO CIRCUITO
TIPO DI CIRCUITO
PRIN. CORRENTE
AKIM PRENSİBİ
Принцип работы
电流原理
ARBEITS-
OPEN
COURANT TRAVAIL
N. ABIERTO
C. DI LAVORO
CORR. TRAB.
ÇALIŞMA
РАБОЧИЙ ТОК
打开
RUHE-
CLOSED
COURANT REPOS
N. CERRADO
C. DI RIPOSO
CORR. REPOUSO
KAPALI DEVRE
ТОК ПОКОЯ
闭合
CLOSED CLOSED CLOSED
TEMPERAT.MODUS
MODE
MODE TEMPERATURE
MODO
MODO TEMPERAT.
MODO TEMPERATURA
SICAKLIK MODU
РЕЖИМ Т-РЫ
模式
OVER OVER OVER
FÜHLERTYP
SENSOR TYPE
TYPE SONDE
TIPO DE SENSOR
TIPO DI SENSORE PT100 PT100
—
TIPO DE SENSOR
SENSÖR TİPİ
ТИП ДАТЧИКА
传感器类型
2)
——
J
FÜHLERZAHL
SENSOR NO.
NB. SONDES
Nº DE SENSORES
N. DI SENSORI
N.º SENSOR
SENSÖR SAYISI
КОЛ-ВО ДАТЧИКОВ
传感器编号
—
3
—
3RS1440
Default
3RS1441
Default
3RS1540
Default
3RS1440 / 3RS1441 3RS1540
ϑ
1 x
ϑϑϑ
3 x max.
1 x
TC ϑ
2
4
3
UNTERSCHREIT.
UNDER ÜBERSCHREIT.
OVER FENSTER
WINDOW
DEPASS. BAS DEPASS. HAUT FENETRE
REBASE BAJO. REBASE ALTO VENTANA
°F
°C
°F
°C
°F
°C
SOTTO IL LIMITE
EXCED. INFERIOR
SOPRA IL LIMITE
EXCED. SUPERIOR
FINESTRA
JANELA
ALTINA DÜŞÜLDÜ
ЗАНИЖЕНИЕ
欠温
AŞILDI
ПРЕВЫШЕНИЕ
过温
PENCERE
ВПРЕДЕЛАХ
窗口
PT100 PT1000 KTY83 KTY84 NTC 1)
JK TEN
SRB
321
NTC Type: B 57227-K333-A1
ϑ
R
1) 1)
Q 63022-K7182-S1 2)
3RS1540
nur / only / seulement / sólo / solo / apenas / sadece / только / 仅限

63ZX1012-0RS20-1AA1
DE Funktionsdiagramme ES Diagramas de funcionamiento TR Fonksiyon diyagramları
EN Functional diagrams IT Diagrammi funzionali РУ Функциональные диаграммы
FR Diagrammes fonctionnels PT Diagramas funcionais 中文 功能图表
3RS1440 /
3RS1441
Ruhestromprinzip / Closed-circuit principle /
Montage à courant de repos / Principio corriente de reposo /
Principio corrente di riposo / Princípio de corrente de repouso /
Hareketsiz akım prensibi / Принцип тока покоя /
闭合电路原理
Arbeitsstromprinzip / Open-circuit principle /
Montage à courant de travail / Principio corriente
de trabajo / Principio corrente di lavoro / Princípio
de corrente de trabalho / Çalışma akımıprensibi /
Принцип рабочего тока / 工作电流原理
Mem = no
CIRCUIT
PRIN.
CIRCUIT
PRIN.
°F
°C
 1
Hyst
 1 >  2
 2
Hyst
LED 2
25/28
25/26
Delay
LED 1
Delay
15/18
15/16
onDelay
onDelay
L+/L-
1
Hyst
1 > 2
2
Hyst
LED 2
25/28
25/26
Delay
LED 1
Delay
15/18
15/16
onDelay
onDelay
L+/L-
°F
°C
Hyst
1
Hyst
2
1 > 2
LED 2
25/28
25/26
Delay
LED 1
Delay
15/18
15/16
L+/L-
onDelay
onDelay
Hyst
1
Hyst
2
1 > 2
LED 2
25/28
25/26
Delay
LED 1
Delay
15/18
15/16
L+/L-
onDelay
onDelay

3ZX1012-0RS20-1AA1 7
°F
°C
LED 1
LED 2
 1
Hyst
Hyst
2
1 > 2
Delay
15/18
15/16
Delay
25/28
25/26
L+/L-
onDelay
onDelay
LED 1
LED 2
 1
Hyst
Hyst
2
1 > 2
Delay
15/18
15/16
Delay
25/28
25/26
L+/L-
onDelay
onDelay
2
Hyst
Hyst
1
1 < 2
LED 2
25/28
25/26
Delay
LED 1
15/18
15/16
Delay
L+/L-
onDelay
onDelay
2
Hyst
Hyst
1
1 < 2
LED 2
25/28
25/26
Delay
LED 1
15/18
15/16
Delay
L+/L-
onDelay
onDelay

83ZX1012-0RS20-1AA1
DE Funktionsdiagramme ES Diagramas de funcionamiento TR Fonksiyon diyagramları
EN Functional diagrams IT Diagrammi funzionali РУ Функциональные диараммы
FR Diagrammes fonctionnels PT Diagramas funcionais 中文 功能图表
3RS1540
Ruhestromprinzip / Closed-circuit principle /
Montage à courant de repos / Principio corriente de reposo /
Principio corrente di riposo / Princípio de corrente de repouso /
Hareketsiz akım prensibi / Принцип тока покоя /
闭合电路原理
Arbeitsstromprinzip / Open-circuit principle /
Montage à courant de travail / Principio corriente
de trabajo / Principio corrente di lavoro / Princípio de
corrente de trabalho / Çalışma akımıprensibi /
Принцип рабочего тока / 工作电流原理
CIRCUIT
PRIN.
CIRCUIT
PRIN.
°F
°C
1
Hyst
2
Hyst
1 > 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
LED ϑ1
LED ϑ2
15/18
15/16
Delay
25/28
25/26
Delay
Delay
MODE
Delay
1
Hyst
2
Hyst
1 > 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
LED ϑ1
LED ϑ2
15/18
15/16
Delay
25/28
25/26
Delay
Delay
MODE
Delay
°F
°C
1
Hyst
2
Hyst
1 > 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
MODE
LED ϑ1Delay
15/18
15/16
Delay
LED ϑ2
25/28
25/26
Delay
Delay
1
Hyst
2
Hyst
1 > 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
MODE
LED ϑ1Delay
15/18
15/16
Delay
LED ϑ2
25/28
25/26
Delay
Delay

3ZX1012-0RS20-1AA1 9
°F
°C
1
Hyst
2
Hyst
1 > 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
LED ϑ1
LED ϑ2
15/18
15/16
Delay
25/28
25/26
Delay Delay
Delay
MODE
1
Hyst
2
Hyst
1 > 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
LED ϑ1
LED ϑ2
15/18
15/16
Delay
25/28
25/26
Delay Delay
Delay
MODE
1
Hyst
2
Hyst
1 < 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
LED ϑ1
15/18
15/16
Delay Delay
LED ϑ2
25/28
25/26
Delay Delay
MODE
1
Hyst
2
Hyst
1 < 2
Y3 Y4
Reset
Y3 Y4
Autoreset
Power
LED ϑ1
15/18
15/16
Delay Delay
LED ϑ2
25/28
25/26
Delay Delay
MODE

10 3ZX1012-0RS20-1AA1
DE Geräteschaltplan ES Esquema de conexiones TR Cihaz devre planı
EN Device circuit diagram IT Schema delle connessioni РУ Принципиальная схема
FR Schéma des connexions PT Esquema elétrico do equipamento 中文 仪表接线图
5HVHW
7
< <

.
.
.










7
7
5HDG\
/ &4 /
< <
5HVHW


5HDG\
.
.
.









7
7
7
7
7
7
7
7
7
/ &4 /
3RS14413RS1440
< <


5HVHW
5HDG\
.
.
.









7
7
/ &4 /
3RS1540

Technische Änderungen vorbehalten. Zum späteren Gebrauch aufbewahren.
Subject to change without prior notice. Store for use at a later date.
3ZX1012-0RS20-1AA1
© Siemens AG 2010
DE Maßzeichnungen
(Angaben in mm) ES Dibujos dimensionales (medidas en mm) TR Ölçü resimleri (Bilgiler mm olarak)
EN Dimension drawings
(all dimensions in mm) IT Disegni quotati (indicazioni in mm) РУ Габаритные чертежи
(все размеры вмм)
FR Encombrements
(indications en mm) PT Desenhos cotados (dimensões em mm) 中文 尺寸图
( 单位：mm)
DE 3ZX1012-0RS14-0AB0 www.siemens.de/industrial-controls/support
EN 3ZX1012-0RS14-0AC0 www.siemens.com/industrial-controls/support
FR 3ZX1012-0RS14-0AD0 www.siemens.com/industrial-controls/support
ES 3ZX1012-0RS14-0AE0 www.siemens.com/industrial-controls/support
6
b
a
86
28,8
c
d
102
6
45
7,2
68,2 91,5
118,5x37
138,5x37
2,9
7,2
75,1
98,4
abcd
3RS1...-1... 65 36 82,6 105,9
3RS1...-2... ——
84,4 107,7