SKY-HERO Little Six User manual
Quick start
Lile Six ENGLISH
2
TABLE OF CONTENTS
INTRODUCTION.
SAFETY ADVICE
GENERAL INSTRUCTIONS AND GUIDELINES FOR USE
PARTS CHECKLIST
IDENTIFYING THE SCREWS, BOLTS & WASHERS
TOOLS REQUIRED FOR ASSEMBLY
PLANNING YOUR INSTALLATION
ASSEMBLING THE TOP FRAME
INSTALLING THE MOTORS
CONNECTING THE ESCS TO THE MOTORS
CHECKING THE DIRECTION OF ROTATION FOR YOUR MOTORS
OVERVIEW OF AIRCRAFT ARMS DIRECTION OF ROTATION
ASSEMBLY OF THE COMPLETE ARM WITH MOTOR & ESC
AIRCRAFT MOTOR ROTATION AND IDENTIFICATION
MOUNTING THE ARMS ONTO THE FRAME
CABLES POSITIONING
COG LOCATION & NAZA FLIGHT CONTROLLER INSTALLATION
ATTACHING THE LOWER FRAME
ATTACHING THE CANOPY SUPPORTS
ATTACHING THE LANDING SKIDS TO THE LOWER FRAME
ATTACHING A CAMERA TO THE FRAME USING THE CAM PLATE
IDENTIFYING THE PROPELLER’S DIRECTION OF ROTATION
ATTACHING THE PROP ADAPTER AND PROPELLER ON THE MOTOR
ATTACHING THE CANOPY
INSTALLING THE BATTERY
CHECKS BEFORE THE FIRST FLIGHT
REGULAR MAINTENANCE
LIMITED WARRANTY
3
3
4
5
6
7
7
7
8
9
10
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
30
3
INTRODUCTION
CONGRATULATIONS on your purchase of a SKY-HERO Lile 6, we hope that it will provide you with many years
of fun and entertainment.
SKY-HERO products are designed and developed in Belgium (Europe), but distributed and supported across the
globe through a network of dealers and outlets that can provide assistance and advice.
The SKY-HERO
reasonable support service.
OUR PHILOSOPHY
Foldable # take it everywhere
Hidden Electronic # neat
Oversized carbon parts # don’t fear massive payload
Multi-sized frames # choose yours
Co-axial design # heavy wind resistance
Smart Layout # easy nose visibility
Few parts # innite possibilities
Looks beautiful # be ready for Envy!
SAFETY ADVICE WARNING!
All SKY-HERO
SKY-HERO-
safety in mind and is provided to help you assemble
4
GENERAL INSTRUCTIONS AND GUIDELINES
FOR USE
•
•
to you, others or property.
•
•
anything which is outside of your control.
•
•
•
results.
•
•
•
•
•
electronics and wiring.
•
• your Flight Controller and any accessory equipment
such as transmitter, battery chargers etc.
5
PARTS CHECKLIST
N° DESCRIPTION PART NUMBER
1 BUTTON HEAD PLASTIC SCREW M3 X 10MM SKH07-111
2 MAIN FRAME LITTLE 6 UP SKH03-011-U
3 HALF FRAME SPACER SKH01-102
4 MOTOR (SKY HERO X2806 950KV*) SKH04-007 (*)
5 MOTOR FRAME BLACK SKH01-005-BK
6 WASHER M3 SKH07-111
7 BUTTON HEAD SCREW M3 X 6MM SKH07-111
8 ESC (40 AMP 6S SimonK Opto*) SKH04-003 (*)
9 INSERT ARM BLACK SKH01-004-BK
10 ARMS SET LITTLE 6 (2FR 2MID 2R) SKH03-065
11 HEX NUT NYLSTOP M3 SKH07-111
12 SOCKET HEAD SCREW M3 X 10MM SKH07-111
13 TUBE FRONT LITTLE6 SKH03-065
14 TUBE MIDDLE LITTLE6 SKH03-065
15 TUBE REAR LITTLE6 SKH03-065
16 BUTTON HEAD SCREW M4 X 40MM SKH07-111
17 KNURL BUTTON LONG M4 SKH07-111
18 MAIN FRAME LITTLE 6 DOWN SKH03-011-D
19 ZENMUSE PLATE LITTLE 6 SKH08-009
20 WASHER M4 SKH07-111
21 HEX NUT NYLSTOP M4 SKH07-111
22 STANDOFF LITTLE SKH07-111
23 LANDING SUPPORT LEFT SKH01-101
24 LANDING SUPPORT RIGHT SKH01-101
25 BUTTON HEAD SCREW M4 X 12MM SKH07-111
26 CAM PLATE LITTLE 6 SKH03-013
27 DAMPER SKH07-111
28 CLIPS SKH07-111
29 GROMET SKH07-111
30 CANOPY LITTLE 6 SKH05-055
31 PROP NUT SKH04-002
32 PROP SHAFT WASHER SKH04-002
33 11’’ CLOCKWISE PROPELLER SKH04-008-L6
34 11’’ COUNTERCLOCKWISE PROPELLER SKH04-008-L6
35 SOCKET HEAD SCREW M3 X 8MM SKH04-002
36 PROP SHAFT AXIS SKH04-002
37 BATTERY STRAP SKH08-003
Q
24
1
6
6
12
24
24
6
6
1
42
42
2
2
2
12
10
1
1
10
4
2
1
1
4
1
3
2
2
1
6
6
3
3
24
6
1
6
IDENTIFYING THE SCREWS, BOLTS & WASHERS
BUTTON HEAD SCREW M4 X 40MM
HEX NUT NYSLTOP M4
HEX NUT NYSLTOP M3
SOCKET HEAD SCREW M3 X 8MM
BUTTON HEAD PLASTIC SCREW M3 X 10MM
BUTTON HEAD SCREW M3 X 6MM
WASHER M3
BUTTON HEAD SCREW M4 X 12MM
WASHER M4
7
TOOLS REQUIRED FOR ASSEMBLY
ADDITIONAL EQUIPMENT THAT YOU WILL NEED
Capacity of 3000mAH / 65c or higher recommended)
PLANNING YOUR INSTALLATION
SKY-HERO
all of the parts and components that you will need. You should also think about what accessories you might want to add
well as things like which route the wiring will take. Some wires might need to be shortened whilst others might need to
check that there is space for everything.
website under NAZA-M You should make sure you have access
2 mm hex wrench
2.5 mm hex wrench
3 mm hex wrench
7 mm wrench
A reamer tool (oponal)
Double-sided adhesive tape
Blue threadlock (Locte)
12 mm Heat Shrink tubing
8
2
1
3
ASSEMBLING THE TOP FRAME
(3) to the upper frame (2)(1).
(7).
Use a small drop of Blue thread-lock on the screws.
Note:
9
INSTALLING THE MOTORS
Orientate the motor in the motor mount, so that the leads can pass through the hole to the tube.
motor, that it is not rubbing against the hole in the middle of the motor mount.
Mount the engines (4) on their supports (5) (7) and washers (6).
Note:SKY-HERO channel on YouTube and watch the video
4
5
6
7
10
CONNECTING THE ESCs TO THE MOTORS
your motor. It is best however, to connect 3 ESC cables for 3 motors one way and the other 3 ESC cables to their motors,
CHECKING THE DIRECTION OF ROTATION
FOR YOUR MOTORS
Please refer to Image on next page.
, and connect each
motor to each of your ESCs (8).
-
Connect your receiver to suitable power source (typically 6v, but check your receiver manual to be sure), connect your
the method to follow) If you are using a SKY-HERO
wires) that go between the ESC and the Motor.
Connect motor to ESC
8
4
11
OVERVIEW OF AIRCRAFT ARMS DIRECTION OF
ROTATION
the smaller space goes into the motor mount
a similar label to the ESC signal cable with the same number (between 1 - 6) will make things easier when you come to
connect the motors to your Flight Controller.
Further help can be found by watching the Video
«SKY-HERO HOW TO ASSEMBLE YOUR MOTOR MOUNTS»
ESC
13 14 15
CWCCW
12
9
12
11
5
8
10
ASSEMBLY OF THE COMPLETE ARM WITH
MOTOR & ESC
The carbon tube (Part No. 13/14/15) has 2 pairs of holes. One pair has a smaller gap between them;
this end of the tube should be xed in the motor mount.
On the inside of each motor mount (5) there are two small studs, these must be orientated to coincide
with the holes that are in the carbon arms.
Fix the motor mounts on their respective arms using 3 X 10 mm (12) Socket head screws and nuts
M3 (11). Slide the arm inserts (9) into each tube.
You should ensure that the ESC power leads exit the tube from the outer edge of the tube, across
the Insert (9), and into the center of the aircraft.
Do not overtighten the 4 screws that secure the motor mount to the carbon tube. A small space must
be visible between the two motor mounts halves
Make sure that these 3 nuts M3 (11) are orientated cor-
inserted into the motor mount hole. If the nuts are not
fully inserted, the screw will not connect and the two
motor mount halves will not be securely connected
13
AIRCRAFT MOTOR ROTATION AND
IDENTIFICATION
CW
CW
CW
CCW
CCW
CCW
14
MOUNTING THE ARMS ONTO THE FRAME
«Assembling the Top Frame»
«Aircra Motor rotaon and Idencaon»
Do not forget to leave enough loose cable to allow the arms to be folded back
FRONT ARMS:
(16) into hole A and tempo-
(17).
CENTRAL ARMS:
(16) into hole B and loosely secure with a M4 knurl
(17).
Rear arms :
(17).
17
16
Note:
•
• -
15
CABLES POSITIONING
9
16
If you are using the NAZA Flight Controller with GPS, the diagram below provides some guidance on where to locate the
standard components
18
LED position on the lower
framer
GPS
NAZA V2
LED
PMU
CoG
Center of gravity
Suitable location
GPS position
2
CoG LOCATION & NAZA FLIGHT CONTROLLER
INSTALLATION
17
(17),
(1) to secure the frame onto the Half Frame Spacers
(3).
Note:
(17)(22) to
secure the frame ( using M4 washers (21)
ATTACHING THE LOWER FRAME
18
1
17
22
21
18
ATTACHING THE CANOPY SUPPORTS
16
23
19
ATTACHING THE LANDING SKIDS TO THE
LOWER FRAME
18
26
25
24
17
you will need to install the landing skids.
20
27
28
27
28
ATTACHING A CAMERA TO THE FRAME USING
THE CAM PLATE
The Lile 6(27)Go Pro Hero type camera to
Note:Go Pro
plate is not included in the package
Table of contents
Other SKY-HERO Drone manuals
SKY-HERO
SKY-HERO Loki MK2 User manual
SKY-HERO
SKY-HERO Anakin Club Racer User manual
SKY-HERO
SKY-HERO ANAKIN NATURAL BORN RACER User manual
SKY-HERO
SKY-HERO Spy SKH00-301 User manual
SKY-HERO
SKY-HERO Anakin Installation guide
SKY-HERO
SKY-HERO Loki MK2 User manual
SKY-HERO
SKY-HERO Loki MK2 User manual
SKY-HERO
SKY-HERO Little Spyder User manual
