Stahl Tranberg TEF 2457 User manual

R. Stahl Tranberg AS
E[email protected] | stahl-tranberg.com
Main office: Strandsvingen 6 | N-4032 Stavanger | Norway | T+47 51 57 89 00 | F+47 51 57 89 50
Office Oslo: Luhrtoppen 2 | N-1470 Lørenskog |Norway | T+47 24 08 44 10
IMPORTANT
Read this instruction carefully before installing the
product
LIGHTING
TEF 2457 LUMINAIRE
WATERTIGHT
SAFE AREA
USER MANUAL
Subject to change without prior notice TUM1011 REV. B 17.07.2017

TEF 2457 WATERTIGHT LUMINAIRE USER MANUAL
INTRODUCTION
Thank you for purchasing this product!
For installation, maintenance and assurance of a long life
of this product, please follow this manual.
CONTENT IN BOX
The product is fully assembled, and ready for installation.
SAFETY PRECAUTIONS
Note that changes made to the product and/or installation
of components which do not conform to the approval,
may be a safety violation. The manufacturer will in no
circumstance be held responsible for such activity.
For your health and safety, always use safety gear suited
for the task. Be certain to follow codes, regulations and/or
specific procedures that are related to the installation.
TOOLS REQUIRED
Regular tools required for installation:
• 10 mm wrench - for assemble the luminaire.
• 3,5 mm flat screwdriver - for connecting the electricity
on B15d, E14, G-4
• PH1 and 5,5 mm flat screwdriver –for connecting
electricity on E27.
• 5,5 mm flat screwdriver –for tightening the globe and
earth screw.
• 21 mm wrench –for tightening the pressure nut on the
cable gland.
MAINTENANCE INSTRUCTIONS
The luminaire should be inspected according to Company
routines. The manufacturer suggests regular check for
water intrusion/condensation which should be removed
immediately. Check the drain plug / drain hole function.
When cleaning, use only mild detergents. Alcohol or
petroleum based products may damage lens, paint or
plastic components.
APPLICATIONS
• Deck lighting
• Signal lighting
• Emergency light
• Lifeboat light
• For use in safe area
APPROVALS
NA

TEF 2457 WATERTIGHT LUMINAIRE USER MANUAL
INSTALLATION INSTRUCTIONS
SPARE PARTS
Description Rart No.
Globe for incandescent lamp, clear 2000 039
Globe for incandescent lamp, green 2000 040
Globe for incandescent lamp, red 2000 038
Globe for incandescent lamp, blue 2000 042
Globe for incandescent lamp, yellow 2000 041
Globe for xelogenlamp with reflector G-4, clear 2000 026
Globe for xelogenlamp with reflector G-4, green 2000 027
Globe for xelogenlamp with reflector G-4, red 2000 025
Globe for xelogenlamp with reflector G-4, yellow 2000 028
Globe for xelogenlamp with reflector G-4, blue 2000 029
Glass gasket 5001 0022
Lamp holder, BA15d 5088 0003
Lamp holder, E27 5087 0011
Lampholder, B22 5088 0020
Lamp holder, E14 5087 0003
Lamp holder, G-4 5088 0018
Lamp holder, G-4, w/12V reg. 1635
Lamp holder, G-4, w/14V reg. 1636
Cable gland, M20 7045 042
Xelogenlamp, 12V, 10W, G-4 9400 039
Xelogenlamp, 12V, 20W, G-4 9400 040
Xelogenlamp, 24V, 10W, G-4 9400 041
Xelogenlamp, 24V, 20W, G-4 9400 042
Boatlight lamp, 12V, 25W, E27 9400 047
Boatlight lamp, 24V, 25W, E27 9400 046
Boatlight lamp, 12V, 25W, BA15d 9400 055
Boatlight lamp, 24V, 25W, BA15d 9400 056
Be sure to install the cable in a way wich prevents water to penetrate into the enclosure through the cable gland
The lamp may be installed in any direction, but it is
recommended that the cable glands face downwards.
Replace cable gland gasket as required to match the cable
diameter. Unused cable glands should always be replaced
with a blind plug.
When replacing globe, take care not to overtighten the
screws, while tightening them bit by bit.

R. Stahl Tranberg AS
E[email protected] | stahl-tranberg.com
Main office: Strandsvingen 6 | N-4032 Stavanger | Norway | T+47 51 57 89 00 | F+47 51 57 89 50
Office Oslo: Luhrtoppen 2 | N-1470 Lørenskog |Norway | T+47 24 08 44 10
TEF 2457 WATERTIGHT LUMINAIRE USER MANUAL
TECHNICAL DATA
Material: Cast brass, globe: polycarbonate lexan
Input voltage: 12V & 24V
Power comsumption: Max. 25 Watt, dependant on light source
IP-rating: IP56
Standard cable entries: 1 stk. M20 Cable gland
2 stk. M20 stopping plugs
Weight: 0,65 kg.