Subaru J1010SL000 User manual



ThankyouforpurchasingtheSubaruGenuineSportGrille.
ThismanualdescribestheproceduretoinstalltheSportGrilleontheFORESTER.
Besuretoreadthismanualbeforeinstallingthisproductandfollowtheinstructionsdescribedbelow.
GenuinePartNumber
ApplicableModel
Sport Grille
Installation Manual
Component Parts
△ 00
SportGrille
PartNameNo. Quantity
SportGrille 1
CameraCover 1
Screws#4×12mm 2
󱦯
󱦳
󱦱
󱦯
󱦱󱦳
J1010SL000
FORESTER 2025MY～


Makesuretoarrangevehiclepartsbypartwhenremovingthemsothatyoudonotlosethe
tappingscrews,nutsandbolts,andsoyoudonotmistakenthemwhenreinstallingthevehicle
components.Also,paydueattentionnottodamagethevehicleandtheremovedpartsduring
work.
⑵
⑴Parkthevehicleonalevelplace,applytheparkingbrake,andusewheelchocks.
Topreventdamagetothevehicleandvehiclepartswhenremovingvehiclepartsand
installingtheproduct,besuretoperformtheworkonaProtectiveSheet.
⑷
FollowtheServiceManualwhenhandlingthebattery.⑶
FollowtheServiceManualwhenperformingthework.
InstallationPrecautions
Clicks
NOTE
CAUTION
InstallationofParts
●Usethepropersizeoftools. ●Payattentiontothebacksideanddonotallow
anywireharnesstogetcaught.
AfterCompletionofInstallation
●Besuretoreassembleallthevehiclepartsthat
havebeenremoved.
…… Thisreferstosituationsinwhichinjurymayoccurorpropertymaybedamagedifthecautioninstructionsarenotfollowed.
Foryoursafety,importantinstructionsthatshouldbeobservedareshownwiththefollowingsymbolsinthisInstallationManual.
……Thisdenotesthingsthatyoushouldbemadeawareofsoyoucandotheworkquickly.
CAUTION
Tools Required
Philipsscrewdriver,Flatheadscrewdriver,Torquecheckscrewdriver,clipremovaltool,Needlenosepliers,
Protectiontape,Wastecloth,De-greasingagent


1. Applying Protective Tape
󰼨

󰼩

ProtectiveTape
ProtectiveTape
ProtectiveTape
Thefigureshowstheleftside.
TG-CT-A01
Post-installation Diagram
Installation Procedure
󱦯SportGrille


3. Removing the Front Bumper
󰼨

󰼩

2. Detaching the Camera Harness
<For vehicles with a camera>
󰼨

CameraHarness
Connector
TG-CT-A06
Claw
Cover
HeadlampWasherNozzle
ProtectiveTape
FlatheadScrewdriver
Thefigureshowstheleftside.
Cover
TG-CT-A02
󰼪

󰼫

FrontBumper
Thefigureshowstheleftside.
FenderMoulding
PlasticClipAx4
TG-CT-A03
CAUTION


(Adopt this practice
throughout the rest of the procedure)


󰼮
󰼬


󰼭

FrontBumper
Bolt
PlasticClipBx15
TG-CT-A04
󰼯

󰼰

FogLampConnector
Mudguard Pullback
Thefigureshowstheleftside.
TG-CT-A07



NOTE
Clipx3
FrontBumper
Thefigureshowstheleftside.
FenderMoulding
Clawx4
Claw
Cross-section
Push
TG-CT-A08


󰼨


(Adopt this practice throughout the rest
of the procedure)
󰼩



󰼪

4. Removing the Camera
<For vehicles with a camera>
󰼨
󰼩


Guide
CameraHarness
FrontGrille(vehiclepart)
Screwx2
CameraASSY
Clipx2
TG-CT-B01
5. Removing the Front Grille
󰼨
󰼩



Clawcross-section
ᵮᶓᶑᶆ
FrontGrille(vehiclepart)
FrontBumper(Backside)
Screwx2
Clawx8
TG-CT-B02



(Adopt this practice throughout the rest of
the procedure)
󰼱

Clawx9
(sameonRHside)
FrontBumper
BlanketorProtectiveSheet
TG-CT-A05
󰼨

󰼩


CAUTION
CAUTION
CAUTION
NOTE


6. Installing the Sport Grille
󰼨 󱦯

󰼩 󱐰󱦯

Clawcross-section
FrontBumper(Backside)
Screwx2
Clawx8
󱦯SportGrille
TG-CT-B03
7. Installing the Camera
<For vehicles with a camera>
󰼨󱦯

 
󰼩


Screwx2
󱦯SportGrille
Guide
CameraHarness
CameraASSY
Clipx2
TG-CT-B04
8. Installing the Camera Cover
<Only for vehicles without a camera>
󰼨󱦱󱦯
󱦳
 
Screwx2
󱦯SportGrille
󱦱CameraCover
TG-CT-B05

󱦳

󱦱󱦳






 
CAUTION
CAUTION
CAUTION


󰼨 



󰼩 


9. Reinstalling the Front Bumper
󰼨

CameraHarness
(onlyvehicleswithacamera)
Clawx9
(sameonRHside)
FrontBumper
BlanketorProtectiveSheet
TG-CT-C06
󰼫

Tightening torque: 7.5 Nm (0.8kgf-m, 5.5ft-lb)
󰼩

FogLampConnector
Mudguard Pullback
Thefigureshowstheleftside.
TG-CT-C07
FrontBumper
Bolt
PlasticClipBx15
TG-CT-C08





󰼪

CAUTION
CAUTION


󰼮

󰼯

FrontBumper
Thefigureshowstheleftside.
FenderMoulding
PlasticClipAx4
TG-CT-C09
󰼰


󰼱

Thefigureshowstheleftside.
Claw
Cover
HeadlampWasherNozzle
Cover
TG-CT-C10
󰼬


󰼭

Clipx3
FrontBumper
Thefigureshowstheleftside.
FenderMoulding
Clawx4
TG-CT-C12


CameraHarness
Connector
TG-CT-C11
10. Connecting the Camera Harness
<For vehicles with a camera>
󰼨
RevisionHistory
△ Description RevisionDate
△00 Firstversion November2023
󰼨
󰼩
󰼨
󰼩
󰼪

Post-installation Inspection
InspectionProcedure