Teac A-X35 User manual

pn
eae
NOTES
in
this
manual,
0
dB
is
referenced
to
1V.
Ay
Parts
marked
with
this
sign
are
safety
critical
components.
They
must
always
be
replaced
with
\dentical
components
-
refer
to
the
appropriate
parts
list
and
ensure
exact
replacements.
PC
boards
shown
are
viewed
from
{oil
side.

M-A DOD |
1 SPECIFICATIONS
Type OC Integrated Stereo Amplifier Signal-to-Noise Ratio
Rated Output Power (IHF A Network, short circuit)
(Both Channels, 8 ohms} PHONO MM 75dB8
40W + 40W (1kHz, 0.05% T.H.D.) TUNER, CDO/AUX, TAPE 1, 2, 94dB
35W + 35W (20H2 ~ 20kHz, 0.1% T.H.D.} Tone Control
Total Harmonic Distortion Bass +10d8, 100H2z
0.1% {20Hz ~ 20kHz, at 35W+35W Outout Power} Treble +12d8, 10kHz
Curput Bandwidth High Filter 10kHz, -6d8
IHF, -3dB, 25Hz ~ 80kHz Power Requirements
Frequency Response 100/14 20/220/240 V AC 50/60 Hz, 160W ‘General Export Model}
TUNER, CD/AUX, TAPE 1, 2, to SP out 25Hz 220V AC 50Hz, 160W (Europe Model)
80kHz +0, -3d8 240V AC 5OH2z, 160W {(U.K./AUS. Model)
PHONO to REC OUT, 20Hz ~ 20kH2 + 0.5d8 (RIAA) | Dimensions {W x H x D)
Input Sensitivity 435 x 80x 295mm (17'%" x 3%5" x 115A)
PHONO MM 2.8mV/47k ohms | Weight 5.3kq (11.66 Ibs) net
TUNER, CD/AUX, TAPE 1, 2, 150mV/47k ohms
Rated Output Voltage/Impedance * Improvements may result in specification or feature changes without
TAPE REC 1, 2, 150mV/47k ohms notice.
2 ADJUSTMENT LOCATION
14-1 DC BALANCE CHECK ©
1. Connect the DC voltmeter to SPEAKERS A terminal.
2,
Depress
POWER
switch
to
ON.
3. Confirm the OC voltmeter indication within 0 V +20mV.
-2 IDLING CURRENT CHECK
Connect the DC voltmeter between R615 to TP1 and R515 to TP2.
Confirm the DC voltmeter indication within BMV when POWER ts ON
after 10 seconds.
3. If the DC voltmeter indicates over 12mV adjust the TVR5 for LEFT
channel or adjust the TVR6 for RIGHT channel on the MAIN PCB.
4. After the above procedures, allow 10 minites for the amplifier to warm
up completely.
i
1.
e

A-X:
IDLING CURRENT CHECK POINT QO
a
TRANSFORMER
@
ns Tee 601
Ss 6 — 7 ee TVR 701
5 ’
AT Heuea |
: =fi=( =o min rin rites MAIN PCB
3 VOLTAGE CONVERSION
(FOR GENERAL EXPORT MODELS ONLY)
AC VOLTAGE SELECTION
This
unit
operates
on
110
volts
or
220
volts
AC.
110V
220V
Before connecting the power cord to your AC outlet, Slide the switch to Slide the switch to
make sure that the setting position of this switch LEFT position as RIGHT position as
matches your line voltage. If not, it must be set to drawing as below drawing as below
your voltage in accordance with the following direction.
AC SELECTOR
220V
“ —
(‘ii | ©

eee
4 BLOCK DIAGRAM
PHONO (CQ —>
CO/AUX YC
TUNER (ee
INPUT SW
OLUME
[
BALANCE
HANA
MY FILTER
t-—-Q_O-1
tA
TAPE PS
SPEAKERS
LOVONESS
POWER Sw
REC
o---sS
FUSE
° | 8+ a—
/ PHONO
.
AC
220v
CO/AUX
TUNER ( (3
; R CHANNEL
TAPE PB(C) :
REC (CO
m
~5 IC BLOCK DIAGRAM
* Equivalent Circuit (% Shown)
NJM2043
PIN FUNCTION
A OUTPUT
A — INPUT
A + INPUT
V~
B + INPUT
B — INPUT
B OUTPUT
V+
1.
2.
ce
4.
oe
6.
ve
8.

6 EXPLODED VIEW

A-X35
7 SCHEMATIC DIAGRAM
—
eS
—eeee
ad
oe
Catoceaeete
TREBLE BASS
DOOE ROO4 C005 R003 1K 005 1n4002
| | 1201
|
14y__1KS
2985
C611
1.9605
250716
R201C201
YRE2043
|
rgos
200P
Tai
47
Z
C601
R601CE02
.
060
\
32
(@
a
REI4
|
(o-]
[oe
]
:
|
R202]
©
56K
C202
-
|
100P S C204 205
100, .
103 333
C102
ra
C106 R106.
R108 = =R301
Fig
R (©
CD/VIDEO
| LO
1 D000—4
[
R
O
7
1N5402X4
TUNER
|
+¢
7
os
I
Odes
|
ob
TAPE
ROG
L©
Se
—o
ae
LL
i
Fong
.
O-O-++
10
O
O-©
:
|
C801
R801
:
soop
47K
+C)
CO
ene
OoA
Wd
O
R©
|
POWER
SW
[
REC
=O
OF
;
.
Ora
0
e
cp
cA
rat
not
©
©
e
|
Oe
ay
|
TAPE
TUNER
CD/VIDEO
PHONO
IDNI
Bees
ee
ed
ee
ee,
et
0
es
te
ee
ay
oa
FUNCTION
SPEAKERS
PHONES
SOHz
a) >_>
ty >
fe S
O =
a S
s >
Y) =
SVvVIT CHED
POWER
SUPPLY
FOR
AC120V
G6O0Hz
MODEL
POWER
SUPPLY
FOR
AC220V/11NV
Mane!
se
_ #
epee Bn
© Ooo Rg REI Pe ep Ege me teen game pas OP eR ata 8 PETS
ee ome FURS A Rr: ORerRORE Rea Fan wt. -

re ose ee le
8
EXPLODED
VIEW
PARTS
LIST
EXPLOOED VIEW
REF. NOQ.
ag.
7 40,
BO,
» 41,
42.
83.
44,
45.
46.
47.
48,
49.
51.
ad.
§3.
54.
59%
56.
57.
58.
53.
60.
61.
62.
63.
65.
66,
67.
PARTS NO.
PNLALO184 x 351
KNBRTO1438°°2
KN8RTO141B°°9
KNBRTO169B"°S
RUB4000800506
KNBKYO167B° °8
KNBRTO09 2B" °0
KNBKY01688°*!
GSKKB0194B°°S
GSKKBO1968° °S
FRMLEOOSS5BN ° 3
CHAC*0891X354
LEDOSOO20RS°7
CHAC*0897 x 355
NUTO7010020° 2
CLTO2802805°2
CLTOS005005 °6
LED050020GS°7
CHAC*0893 x 358
PCBS*OA517A°2
PWSES88213° "1
PCBS*OA517°°2
PHSSUF24AK142
EJKHL230603P3
PCBCA0A505* *2
PCBL*OAS13°*4
RVRIOOK25AT 26
PHSSUF24AK6 "1
PHSSUF41AK6°0
RVR250K25MC20
PCBT*0A510°°2
RVR250K258F 20
TRSSDO7 160° *0
TRSSBQ6860°*5S
RAPH*OO087°" "1
« FLCO4K7035R31
SPKPTO20808P5
RCKYKOOOS04P2
RCKYKCO0802P0
FTW03208005°7
SPW03200000 *0
SCECT3016YH* 1
CHAC*0892°356
864026E2°°* TS
864026B2°°*T?
864026A2°**T3
864026S2°°*T9
CHAC*0955X354
CHAC*0896X353
CHAC*0894X351
CLPB*0007°" 5
SCEOM4010WCE5
CHAC*0895X351
SCECM40068W’ 2
SCECM3006YC'9
SCECTO1098CP7
SCECTIOO6BC'6
FIP**0018°* "1
SCECT3006YC*?7
SCECM4008BW'6
FTW04010010°6
SCECM4008YS°7
SCECT30068C "6
SCECT3010YC*S
STNVC100180°!
ACKRTO021°°*2
SCECM30068C "8
ACKS*16519°°8
ACLRTOO21°°*2
DESCRIPTION
Front Panel L-184
Knob K8-1438K
Knob KB-1418K
Knob K8-1698K
Sponge Cushion 40 x 8 x Smm
Push Knob KB-1678
Push Knob K8-0928
Push Knob Ka- 1688
Power LED Cushion A-194
Washer for Push Knob A-196
Washer for Push Knob A-195
Front Chassis C-891
Power LED 2x5 Orange Red
Phone Jack Holder C-897
Washer for Phone Jack 120
Nut for Phone Jack M12x 1.75x0.5t
Washer 7.20% 12x0.5
Nut M7 x 0.75
Flet O0-O031A
Fiet 0-0032A
LED 2x5 Green
Right Chassis C-893.
P.C.8. S-ASITA
AC SW SOL-BIP TV3
PCA S-A517
SW SPUF24AK014
Phone, HTJ064-040
Main PCB CA-A505 (11)
PCB L-AS13 {kL}
VR RKDA208225-1O0KA x 2x 25
SW SPUF24AK006
SW SPUF41AK06
VR K162AC0+046-250KMN x 2x 25
PCB T-A510
VR K162B0E355-250KB x 2x 25
Transistor 280716
Transistor 2SB686
Heat Sink H-087
Electrolytic Capacitor
4700u 35V
Speaker terminal PT-208AS
RCA Jack KC21-0009
RCA Jack KC21-0008
Washer 3.20
Spring Washer 3.20
Hexagon Cross Screw Mix 16
Lett Chassis C-892
Transformer E186 x 40
Transtormer £186 x 40
Transformer EI86 x 40
Transformer E186 x 40
Transtormer Holder C-955
Bortom Chassis C-896
Rear Panel C-894
Bushing 8-7
AC Cord CEE x 2C
AC Cord SPT-2 AWG18 x 2C
AC Cord SPT-2 AWG18 x 2C
{Polarzed)
AC Cord 8S 6500
AC Cord SAA
Ground Screw CRWMS E-176
Upper Cover C-895
Sctew CRWMS 4x6
Screw CRMS 3x6
Plastic Screw 1/8x 9
Screw CRT§ 3x6
Foot Cushion 182 x 10mm
Screw CRTS 3x6
Screw CRWMS 4x8
Washer 4.22 x 100 x }
Screw CRSMS 4x8
Screw CRTS 3x6
Screw CRTS 3x6
Copper Post €-16)
Slide SW
Screw CRMS 3x6
AC Qutiet $-16519
AC Outlet 27-21
REMARKS
69.
70.
71.
EUR
EUR UK
USA
EX
EUR
EX
USA, CNO
EUR UK
AUS
EX
EX
CND
EX
ITDA*°0X35°38
nn
Owner's Manual
Styrofoam PF-054
inside carton
Outside carton (Two in one}

MAIN AMP PCB CA-A505 (1L)
'
S.
if
i
a
:
Hyigi
|
scecninabinpennnsinisant
nun
iteneneisirancapriemtoninesincineeed
&O2
Ipc nck oncmenenneaseroneinstienturaneritsettnt
Tiss
-WANGINE
—
CA-AS0SQL)
10
payeisen tags
i
af BPR ERR pho wagon SE
leone eth
Weasel ae se

MAIN AMP PC8 ASSY CA-A505
REF.
NO.
PARTS
NO.
DESCRIPTION
REF.
NO.
PARTS
NO.
DESCRIPTION
PCBCAOASOS'*2
MAIN
AMP
PCB
ASSY
C101,
201
ELCO4U7025R35
Elec.
-
4.7u
25V
PCBCAQASOS'*2
MAIN
AMP
PCB
C102,
C202
CRCO100050RK5
Ceramic
100?
SOV
C103,
C203
ELC
100U016R31
Elec.
100u
16V
ae
C104,
C204
PECOUO10SORJ8
Myiar
0.01%
C201,
1C401
ICCNJO2043006
0JRC204300
C105,
C205
PECUOI30SORJZ
Mylar
0.003u
C106,
C206
ELCOU220S0R57
Eiec.
0.22u
25V
KULR
Aer
C108,
C208
ELC100U016R31
Clee.
100u
18V
Q501,
Q601
TRSSA1038E°°3
2541038
C301,
C401
PEC47000SORJ6
Mylar
0.005
0502,
0602
TRSSA1038E°°3
254
1038
C301,
C401
ELC100U016R3!1
Elec.
100u
16V
Q503,
0603
TRSSD0438F*°0
2$0438F
C302,
C402
PECOUO10S0RJ8
Mylar
0.0lu
Q504,
0604
TRSSC18158L"1
25C
181584
C303,
C403
€LC04U7025R35
Elec.
4.7u
25V
0505,
0605
TRSSD0438F*
*0
250438F
C304,
C404
ELC100U016R3}
Elec.
™100u
16V
Q506,
0606
TRSSBOS6OF*
*
7
25B560F
C305,
C405
CRCO030050RK3
Ceramic
"
30P
SOV
0507,
0607
TRSSDO07160°*0
250716
C306,
C406
ELCO4U7025A35
Elec.
4,2u
25V
Q508,
Q608
TRSS806860°*S
258686
C307.
C407
PEC
1000050RU9
Mylar
0.001u
_DIODES-
C308,
C408
PEC20000S0RJ5
Mylar
0.002u
C308,
C408
PECEBOO0SORU4
Mylar
0.0068u
0001
-Do04
DIDINS4O1"*
"|
IN5402
C309,
C409
PECUOISOSORUO
Mylar
0.039u
0005
DIDIN4002°*
"2
IN6002
C310,
C410
PECOU1
SOSORKE
Mylar
0.154
0006,
0007
01001
4VOWS*
"0
Tay
0.oW
C501,
C60!
ELCO4U7025R35
Elec,
4Ju
25V
0701
DIDIN4O02""
"2
N4002
C502,
C602
ELCO4U7025R35
Elec.
4Ju
25V
-CARBON
RESISTORS
-
C503,
C603
CRCOO30SO0RKS
Ceramic
30P
500V
All
resistors
are
rated
+5%
tolerance
and
1/4W
C504,
C604
CRCO1000SORK5
Ceramic
100?
SOV
C505,
C605
£LC220U016R37
Elec.
220u
16V
R101,
R201
CBROOIKOW4TJ7
1K
ohm
me:
ees
a
-
ay
ne
Mee
CORDS
OROW
IN?
anh
One
C507,
C807
€LC047U035R31
Elec.
4Ju
a5V
R103,
R203
CBR1SOROW4TJI
150
ohm
cena
cane
scene
naa
ae
a
R106,
R206
sabadieichbaaeas
atom
C509,
C609
CRCO200S00RK5
Ceramic
200?
S00V
RIG7,
R207
Een
OOR
Sa
100K
ofr
C510,
C610
PECUO22050RK3
Mylar
0.022u
oe
ea
ni
eal
oe
C511,
C611
CRCO200SO0RKS
Canis
200°
500V
RIO
0
CBRISOROW
STI:
150/9hm
C610,
C710
PECUO47050RKO
Myiar
0.047K
R302,
R402
CBRO2K20W4TIS
2K2
ohm
a
cera
et
i
ee
se
Jase
annie
EahOI
OWA
Se
seanaail
C801,
C90!
CRCO1000S0RK5
-
Ceramic
100P
SOV
Lele
mORSACROW
SSE
seo
onm
ca02,
C902
CRCO1000SORKS
Caramie
100P
50V
R306,
R406
CBROIKBOW4TJ1
1K8
ohm
Bae
ae
ae
R307,
A407
CBRO47KOW4TJ6
47K
ohm
R308,
R408
CBROIOKOW4TI8
10K
ohm
|
~VARIABLE
RESISTORS
-
sealant
bac
Ac
ean
TVRS,
TVR6
TVROOIKO63HM1
=
Semiixed
1K
ohm
R310,
R410
CBROIOKOWSTJB
10K
ohm
Treble
Bass
RVR100K25AT26
RKDA20B225-100KA
x
2x
25
i
ieeaials
CBROZK20W4TJS
2K2
ohm
Ralance
RVR250K25MC20
K
182A0A046-250KMN
x
2x
25
A312,
RE12
CBRA70KOW4TJ6
470K
ohm
R501,
A601
CBROOIKOWSTJ?
1K
ohm
-MISCELLANEOUS
-
R502,
R602
CBRO33KOW4TJ2
33K
ohm
:
.
RCKYKO00904P2
4P
RCA
Jack
R503,
AGO3
CBROIKSOW4TJO
1K5
ohm
|
SAyvcpneaodpoS
i.
“emnghdsek
sagas
CBAO1BKOW4T
4
18K
ohm
SPKPTO20BO8P5
-«=—_‘Speakers
Terminal
RSOG,
AGOG
CBROI3KOW4TI2
33K
ohm
eweasnti
13s
nee
Mn
R507,
AGO?
CBRO2K20W4T/5
2K2
ohm
eqieneoas-"3
space
ee
COAOSKIOW4T
J
3K3
ohm
PHSSUF41AK6*0
Push
Switch
(SPUF41AKO6!
R503,
R603
CBROIK9OW4T
IE
3K
ohm
PHSSUF24AK6"
I
Push
Switch
(SPUF244K006)
R510,
R610
CBROO1KOW4TJ?
1K
ohm
RAPH*0087°**1
Heat
Sink
H-087
HTJ064-040
A511,
R611
CBRIOOROWSTJ4
100
ohm
RBO1,
ROO!
CBROAK
70W4T.J4
4K7
ohm
All resistors are rated + 5% tolerance and 1/3W
R512, R612 CBR220ROW 3T JO 220 ohm
R513,
R613
CBR220ROW
IT
JO
220
ohm
TONE
PCB
ASSY
T-A510
All resistors are rated +5% tolerance and 1/2W PARTS NO. DESCRIPTION
ROO
1,
R002
CBROSK70W2TJ2
4K?
ohm
scar
OAEIO"
=
Tone
PCB
ASSY
ROO3
CBROOIKOW2TJS
1K
ohm
Seay
iokstors
Fone
PCB
R004,
ROOS
CBROIKSOW2TJ9
1K5
ohm
RVR250K
25BF
20
Variable
Resistors
R616,
R716
CBROIOROW2TJ1
10
ohm
R701 CBROIK30W2TJ2 3K3 ohm
R702 CBRO2K70W2TJI 2K7 ohm
-METAL FILM RESISTORS-~
All tesistors are rated + 2% tolerance
R104, R204 PMRO7KSOW4TFS 7KS ohm V/4w
R105, R205 PMR 100KOW47 J7 TOOK chm 1/4W
POWER LED PC8 ASSY
PARTS NO.
GSKKBO1948° °5
DESCRIPTION
-CEMENT FILLED FIXED RESISTORS -
A-194
R514.
R614
CMROR3302WTJ9
7K5
ohm
2W
LEDOSOO20RS"?
LED
2x5
ORANGE
RED
R515,
RBIS
CMROR3302WTJ9
0.33
ohm
2W
-CAPACITORS-
C001,
C002
CRCOPO101KRZ1
Ceramic
0.01u
1000V
C003,
C004
ELCO4K7035R31
Elec.
4700u
35V
coos
£LC220U035R31
Elec.
220u
C006, C007 ELC470U025R38 Elec. 470u
17

X35
9.2
FUNCTION
LED
PCB
L-A513(L)
SWITCH
PCB
S-A517(A,L)
SS gee IR SHI e naar ananassae AN NRE
SS SS oe Pesos one
L-ASI3(L)
SWITCH
PCB
ASSY
S-A517A
SWITCH
PCB
ASSY
S-AS17(U
PARTS
NO,
DESCRIPTION
REF.
NO.
PARTS
NO.
DESCRIPTION
PCBS*OASI7A’2
Switch
PCB
ASSY
PCBS‘OASI7°"2
-—-«
Switch
PCB
ASSY
PCBS*OASI7A°2
Switch
PCB
|
PBS*OASI7°°2
Switch
PCB
PWSESB8213°*)
Switch,
Power
CRCOPO101KAZ1
Ceramic
0.005
“pETAC
TENDS
Ce
R517, R617 MTR330ROIWTI4 330 ohm 1W
~MISCELLANEOUS-
PUSSUF24AK142 Push Switch SPUF24AK014
FUNCTION
LED
PCB
ASSY
L-A513
EJKHL230603P3
tack
Phone
PARTS NO. DESCRIPTION
PCBL*0AS13°*°4 Function LED PCB ASSY
PCBL*OA513°°4 Function LED PCB
LEDOSO0920GS°? LED 2x5 GREEN
PRL13002405P5 SP x 130mm
GSKKBO196B* °9 A-196
1Z