TerraTrike Rambler 2020 Manual

www.TerraTrike.com | 800.945.9910
Revised 03/2020
Build Notes
For ModelYears 2020 and Later

www.TerraTrike.com | 800.945.9910
Inate tires before performing alignment. The Rambler alignment measurement is
approximately 30 ½” (center tread to center tread), though slight variance is possible.
Most importantly, make sure the alignment remains neutral with a rider seated in the
trike.
Alignment
30½
30½

www.TerraTrike.com | 800.945.9910
Hybrid Steering Stack Assembly*
1
2
3
4
5
8
9
10
Assemble the steering stack as shown. Grease the
steerer tube before inserting into head tube. Remove
any excess grease from steerer tube before installing
handlebar. Grease axle before installing wheel. Torque
axle to 23-25Nm.
*Right Hand assembly depicted. Some components
can be purchased individually as well as in pairs, see
parts list below.
1M6x30 Bolt TT000576
2Hybrid Top Cap TT000506
3 Trigger Handlebar - RH TT000649
Trigger Handlebar - LH TT000650
Trigger Handlebar - Pair TT000514
M5x20 Bolt - 2qty (not pictured)
TT000301
4Hybrid Headset Spacer TT000520
5Hyrbid Headset Cap TT000505
6Bushing (pre-installed)
TT000809
7 Hybrid Headset Cup (pre-installed) TT000602
8Hybrid Headset Bearing TT000600
9Rapid Axle Hubmount - RH TT000713
Rapid Axle Hubmount - LH TT000714
Rapid Axle Hubmount - Pair TT000516
10 Rapid Axle - RH TT000717
Rapid Axle - LH TT000718
Rapid Axle - Pair TT000563
11 Axle Spacer TT000568
Parts List
6
7

www.TerraTrike.com | 800.945.9910
Hybrid Steering Stack Assembly Continued*
11
Install Axle Spacer (11) between brake rotor and hub.

www.TerraTrike.com | 800.945.9910
Chain Tube Setup
Top:
Bottom:
Mount the chain tube assemblies as shown below. Ensure the chain
tubes do not rotate in the clamps after tightening the pinch bolts.

www.TerraTrike.com | 800.945.9910
Upper Assy. Chain Tube, 102cm LDPE TT000540 1
Chain Tube Clamp, Rov/Ram/Mav TT000152 1
Spacer, Chain Tube Clamp, 15mm TT000125 1
M5x30 Pan Head (phillips) SS TT000438 1
M5x18 Pan Head (phillips) SS N/A 1
Lower Assy. Chain Tube, 56cm LDPE TT000548
1
Chain Tube Clamp, Rov/Ram/Mav TT000152
1
Chain Tube Bracket Arm, M5, M5 TT000640
1
M5 Nyloc Nut SS TT000252 1
M5x12mm SHCS SS TT000303 1
M5x16mm SHCS SS TT000443 1
M5x18 Pan Head (phillips) SS N/A 1
Parts List

www.TerraTrike.com | 800.945.9910
Cable Routing RH
Brake Cable
Shift Cable
Chain Routing

www.TerraTrike.com | 800.945.9910
Cable Routing LH

800.945.9910 | www.TerraTrike.com
4460 40th St. SE | Grand Rapids, MI 49512 USA