Torklift A7770 User manual

!
1!
IMPORTANT OWNER-OPERATOR INSTALLATION INSTRUCTIONS
A7770, A7771
FORTRESS GAS LOCK
APPLICATION:
Dual Propane Tank Setups
REVISED version 3 BY: CW 10/13/14
TECH SUPPORT [phone]
AFTER INSTALL, PLEASE GIVE
THIS BOOKLET TO YOUR CUSTOMER!

!
2!
A7770, A7771 INVENTORY LIST
1- Propane Lock Bracket
1- Propane Lock Handle
1- Washer SS (A7770 - 1/2" SAE) (A7771 - 3/8" SAE)
1- Pin Lock
1- Theft Deterrent Decal
1- Rubber Lock Spacer
ASSEMBLY
Step 1-
Between the two propane tanks, remove the handle from the threaded rod.
Step 2-
Place the Propane Lock Bracket over the threaded rod with the feet pointing
down and facing towards either Propane Tank. It will fit over the Propane Tank Cross
Bar and Propane Tank Cover Bracket as seen in Photo 3.1 and 4.1.
Step 3-
Place the Washer SS over the threaded rod. Thread the Propane Lock Handle
onto the threaded rod and tighten until the propane bottles are secure. Occasionally the
threaded rod will not be tall enough to fully install the Propane Lock Handle. In most
cases, the threaded rod can be unscrewed from the bottom to allow for extra height.
Rotate the Propane Lock Handle so one of the locking holes lines up with the hole in
the Propane Lock Bracket see Photo 3.1

!
3!
Photo 3.1 - A7770
Step 4-
Place the Rubber Lock Spacer over the male end of the Pin Lock and then install
the Pin Lock from the bottom side of the Propane Lock Bracket. With the key
removed, push the female end of the Pin Lock onto the male end of the Pin Lock until
you hear a “snap.” Make sure to check that the Pin Lock is securely fastened by pulling
the female end of the Pin Lock away from the male end, see Photo 4.1.
Propane(Lock(Handle(
Washer(SS(
Propane(Lock(U4(Bracket(
Female(end(of(Pin(Lock(
Male(end(of(Pin(Lock(
Threaded(Rod(
Propane(Tank(
Cover(Bracket(
Rubber(Lock(Spacer(

!
4!
Photo 4.1- A7770
Step 5-
To remove the Pin Lock, insert the key and twist clockwise. Pull the two sides of
the Pin Lock apart and remove from Propane Lock Bracket and Propane Lock
Handle.
Step 6-
Apply the Theft Deterrent Decal onto the propane tank cover or the tank itself. (Photo
6.1)
Pin(Lock(
Propane(Tank(Cross(Bar(
Propane(Tank(
Cover(Bracket(

!
5!
Photo 6.1

!
6!
Torklift International Limited Lifetime
Warranty Information
!
1901 Fryar Ave Sumner, WA 98390
Torklift will require proof of purchase to register, with pictures of any defective product
before issuing a replacement. Torklift will not register any product without proof of
purchase, which can be faxed, scanned, emailed, or mailed to the information provided
below. Torklift warrants it’s hitches, custom hitch receivers, frame mounted tie downs,
turnbuckles, and accessories (excluding wire harnesses which carry a 90 day warranty)
from date of purchase against defects in material and workmanship under normal use and
service for the ownership life of the original consumer purchaser. ALL COMMERCIAL
APPLICATIONS ARE WARRANTED FOR A PERIOD OF 90 DAYS FROM THE
DATE OF INSTALLATION/SERVICE. Torklift will replace FREE OF CHARGE any
part, which proves defective in material or workmanship when presented to Torklift,
TRANSPORTATION CHARGES PREPAID by purchaser, at the address above. THIS
WARRANTY IS LIMITED TO DEFECTIVE PARTS REPLACEMENT ONLY.
LABOR CHARGES AND/OR DAMAGE INCURRED IN INSTALLATION OR
REPLACEMENT, AS WELL AS INCIDENTAL AND CONSEQUENTIAL
DAMAGES CONNECTED THEREWITH ARE EXCLUDED. This warranty does not
include the finish or paint on our products. Rusting, cracking or peeling of the finish is
also excluded. Some states do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or exclusion may not apply to you. Any
damage to Torklift products as a result of misuse, abuse, neglect, accident, improper
installation or any use violation of instructions furnished by Torklift or WHEN USED IN
ANY COMMERCIAL APPLICATION WILL VOID THE WARRANTY. This warranty
gives you specific legal rights, and you may also have rights, which vary from state to
state. With warranty service, you may be able to go to a small claims court, a state court
or a federal district court.

!
7!
!
!
1901 Fryar Avenue Phone [phone]
Sumner WA, 98390 Fax [phone]
or(visit(our(website:(www.TorkLift.com(
(
Dear Valued Customer,
Thank you for making TorkLift your choice for truck, camper packages and accessories
for your vehicle. By choosing TorkLift products, you have chosen a company that has
been serving the RV industry for nearly 40 years and whose name has become
synonymous with strength, quality and advanced design and installation.
Please take a few moments of your time to complete the Product Registration
Warranty Card on the next page. When registering your newly purchased TorkLift
products, you can be assured that your contact information is secure and that you and
your product are getting the attention and respect that you deserve.
Thank you again for choosing TorkLift quality products.
Register for your lifetime warranty and receive a free Torklift
International gift.
To Fax: Send copies of the questionnaire, warranty card and receipt to
253-854-8003
To E-mail: Send copies of the questionnaire, warranty card and receipt to
[email protected]
To Mail: Send to Torklift International 1901 Fryar Ave Sumner, WA 98390

!
8!
PLEASE FILL OUT THIS FORM COMPLETELY AND RETURN TO TORKLIFT WITHIN
30 DAYS OF PURCHASE ACCOMPANIED BY A COPY OF YOUR ORIGINAL RECEIPT
1. PART(S) PURCHASED
2. PURCHASER INFORMATION
3. TRUCK INFORMATION
YEAR: ______________ MAKE: _________________
4. CAMPER INFORMATION
YEAR: ___________ MAKE: _______________ MODEL: ________________
5. DEALER INFORMATION
PURCHASED FROM: ______________________________________________
CITY: _________________ STATE: _____ ZIP / POSTAL: ______________
INSTALLED BY: OWNER ABOVE DEALER ANOTHER DEALER
IF ANOTHER DEALER, WHO: _______________________________________
PART#: ___________________ PART#: _______________________
OFFICIAL WARRANTY REGISTRATION CARD
PART#: ___________________ PART#: _______________________
NAME: _____________________________________________________________
EMAIL: ______________________________
ADDRESS: __________________________________________________________
CITY: _________________ STATE: _____ ZIP / POSTAL CODE: ______________
PHONE: ( ) -_________
MODEL:_____________ BED LENGTH: ___________
ADDRESS:______________________________________________________
TODAY’S DATE: _________________________