Travis Industries 616 GSR User manual


616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 1 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
WARNINGS
•MakesurethegascontrolvalveisOFFandtheheateriscoolpriortoconductingservice.
•Failuretopositionthepartsinaccordancewiththesediagramsorfailuretouseonlypartsspecificallyapprovedwiththis
appliancemayresultinpropertydamageorpersonalinjury.
•Ifusingpropane(LP),converttheappliancebeforeinstallingthelogs(seetheownersmanualfordetails).
Compatibility
616GSR
Packing List
•8‐PieceTraditionalLogSet
(notshown)



FrontLogSupports,(4)10‐24Kepsnuts
RearAirDeflector,RearLog
Support

BagofRockWool,BagofEmbers
Burner Installation
NOTE:Theinsertshouldbeinplace,withthegaslineandventattachedandthefirebacksinstalled(seeowner’smanualfor
furtherdetails).
1. Removetherearburner.
 
Removethisscrew
(
1
/
4”n
utd
riv
e
r
)
.


616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 2 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
2. Removethe3screwsfromthebackoftherearburnerusinga¼”nutdriver.
 
3. Attachtherearairdeflectortotherearburnerwiththescrewsremovedinthepreviousstep.
 
4. Replacetherearburnerandsecurewiththeattachmentscrew.


Thetwotabsontherear
burnerrestontopofthe
frontburner.


616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 3 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
5. Installtherearlogshelf.

6. Attachthefrontlogsupportswiththe4includednuts.
NOTE:Theleftfrontlogsupportshouldbepositionedlikethephotobelow:






616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 4 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
Rock Wool Placement
7. Placetherockwoolasfollows:
a. Brushtherockwoolusingastiffbrushinaloose,gauze‐likelayer.

TIP:Holdtherockwoolinatightwadwithonehandwhilebrushingwiththeother.

Notehowtherockwoolisapproximately1/8”thickovertheburnerports.
TIP:Feelfreetoapplyagenerousamountofrockwooltogainadarkerflameandabrightercoalbed.





616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 5 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
Log and Ember Chunks Placement
Thelogsarefragile,especiallyafterbeingexposedtoheat.
•Theburnermustbecorrectlypositionedbeforeinstallingthelogs.Makesuretheburnerisfullyseated.
8. Placetherearlogasshownbelow.
NOTE:Theleftandrightmiddlelogsneedtobepushedbacktightagainsttherearburner.




Movethelogforwarduntilitrestsagainstthetabsontheburners.




616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 6 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
9. Placetheleftmiddlelogasshownbelow.

10. Placetherightmiddlelogasshownbelow.




616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 7 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
11. Placetheleftfrontlogasshown.


12. Placetherightfrontlogasshown.




616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 8 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
13. Placetheemberchunksasshownbelow.Notethathalfthebagofembersisleftover.


14. Re‐applytherockwoolovertheemberchunksalongthefrontburnerandbetweenthetwofrontlogsforanaturallook.
TIP:Applyingrockwoolinthecracksofthelogs(seebelow)helpstoaddsmallpointsofglow,butmaydampentheoverallglow
ofthelogs.
TIP:Naturalgas(NG)canusemorerockwoolthanpropane(LP).
NOTE:Initialapplicationofrockwoolmaycause“matting”overburnerports.Turningtheunitonandthenoffagainwillloosen
therockwool,resultinginabetterflame.
 



616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 9 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.
15. Placetheleftcrosslogasshown.
NOTE:Thethreecross‐logsmakeitdifficulttoapplymorerockwool.Addthemafteryouhavefinishedapplyingtherockwool
andemberchunks.


16. Placethemiddlecrosslogasshown.





616 GSR Traditional Log Set
Installation Instructions (SKU94500948)


Page 10 of 10 17601679.docx — 6/14/13 © Travis Industries, Inc.

17. Placetherightcrosslogasshown.


18. Theinsertshouldbetest‐burnedwiththeglassframeinplacepriortoleavingtheinstallation.Seetheowner’smanualfordetails
onfinalizingtheinstallation(adjustingtheairshutter,etc.).
19. Checktheexhaustrestrictorsettingbeforefinalizingtheinstallation.
Restrictor Settings
Traditional Logs
Natural Gas Short Vent
(25’ or less)#3 (stock)
Natural Gas Tall Vent
(25’ or more)#3 (stock)
Propane Short Vent
(25’ or less)#1
Propane Tall Vent
(25’ or more)#3 (stock)
