Vantron FPA-C34 User manual

FPA-C34, FPA-W34
1/ 17
FPA-C34, FPA-W34

User’sManual










FPA-C34, FPA-W34
2/ 17


ChengduVantronTechnology,Ltd.
www.vantrontech.com.cn
RevisionHistory:

No.VersionDescriptionDate
1V1.0Initial Version2015.01.17
2V1.1AddDIPSwitchexplain2015.01.25
3V1.2Addsomepicturestofunction2015.02.01
4V1.3 Changesomepicturestofunction 2015.02.04
5V1.4 StatementVantronisthemanufacturertothe
device,andSMCisthecustomerofthedevice
2016/7/19
6V1.5 Requireprofessionallyinstallantennasanduse
antennasspecifiedbythemanufacturer
2016/8/3
 





FPA-C34, FPA-W34
3/ 17
TableofContents
1.Foreword................................................................................................................................4
1.1CopyrightNotice........................................................................................................................4
1.2Notes..........................................................................................................................................4
1.3Statement...................................................................................................................................4
1.4Disclaimer...................................................................................................................................4
1.5LimitationofLiability/Non‐warranty..........................................................................................4
1.6SafetyInstructions......................................................................................................................5
1.7Precautions.................................................................................................................................5
1.8SafetyInstructionsforPowerCablesandAccessories...............................................................5
2.Overview................................................................................................................................7
2.1Introduction...............................................................................................................................7
3.M2MGateway‐FPA‐C34,FPA‐W34HardwareInstructions......................................................9
3.1ProductAppearance...................................................................................................................9
3.5InterfaceDescription...............................................................................................................10
3.5.1PowerInterface........................................................................................................10
3.5.2EthernetInterface....................................................................................................10
3.5.3RS232orRS485Connector......................................................................................11
3.5.3DIPSwitchforselect................................................................................................11
3.5.3DIPSwitchforboot..................................................................................................11
3.5.6LED...........................................................................................................................12
3.5.7MicroSIMCard........................................................................................................12
3.5.8DEBUG......................................................................................................................12
3.5.9Renewbutton..........................................................................................................12
3.5.12SD/MMCsocket.....................................................................................................13
4.Tips......................................................................................................................................14

FPA-C34, FPA-W34
4/ 17
1. Foreword
1.1CopyrightNotice
Whileallinformationcontainedhereinhavebeencarefullycheckedtoassureits
accuracyintechnicaldetailsandprinting,Vantronassumesnoresponsibilityresulting
fromanyerrororfeaturesofthismanual,orfromimproperusesofthismanualor
thesoftware.Pleasecontactourtechnicaldepartmentforrelevantoperation
solutionsifthereisanyproblemthatcannotbesolvedaccordingtothismanual.
Vantronreservesallrightsofthismanual,includingtherighttochangethecontent,
form,productfeatures,andspecificationscontainedhereinatanytimewithoutprior
notice.Thelatestversionofthismanualisatwww.vantrontech.com.cn.Please
contactVantronforfurtherinformation:
VantronTechnology（Vantron）
E‐mail:[email protected]
Thetrademarksandregisteredtrademarksinthismanualarepropertiesoftheir
respectiveowners.Nopartofthismanualmaybecopied,reproduced,translatedor
sold.Nochangesorotherpurposesarepermittedwithoutthepriorwrittenconsent
ofVantron.
Vantronreservestherightofallpublicly‐releasedcopiesofthismanual.
1.2Notes
Applicablenotesarelistedinthefollowingtable:

SignNoticeTypeDescription

NoticeImportantinformationandregulations

CautionCautionforlatentdamagetosystemorharmtopersonnel
1.3Statement
ItisrecommendedtoreadandcomplywiththismanualbeforeoperatingFPA‐C34,
FPA‐W34whichprovidesimportantguidanceandhelpsdecreasingthedangerof
injury,electricshock,fire,oranydamagetothedevice.
1.4Disclaimer
Vantronassumesnolegalliabilityofaccidentsresultingfromfailureofconforming
tothesafetyinstructions.
1.5LimitationofLiability/Non‐warranty

FPA-C34, FPA-W34
5/ 17
FordirectorindirectdamagetothisdeviceorotherdevicesofVantroncausedby
failureofconformingtothismanualorthesafetyinstructionsondevicelabel,
Vantronassumesneitherwarrantynorlegalliabilityevenifthedeviceisstillunder
warranty.
TheFPA‐C34,FPA‐W34shouldbeinstalled,debuggedandmaintainedby
professionalpeople.
Theoutsideantennasarenotpermittedtobeinstalledortobechangedbynon‐
professionalpeople.Torunthedevicenormally,onlyspecifyantennasareapproved
tobeassembledtogetherbyprofessionalpeople.
Unitshallbeusedwithindoor‐useantennaonly.Noantennaforthisunitcanbe
installedoutdoor.
1.6SafetyInstructions
 Keepandcomplywithalloperationinstructions,warnings,andinformation.
 Payattentiontowarningsonthisdevice.
 Readthefollowingprecautionssoastodecreasethedangerofinjury,electric
shock,fire,oranydamagetothedevice.
1.7Precautions
 Payattentiontotheproductlabels/safetyinstructionsprintedonsilkscreens.
 Donottryrepairingthisproductunlessdeclaredinthismanual.
 Keepawayfromheatsource,suchasheater,heatdissipater,orenginecasing.
 Donotinsertotheritemsintotheslot(ifany)ofthisdevice.
•Keeptheventilationslotventilatedforcooling.
•Systemfaultmayariseifotheritemsareinsertedintothisdevice.
 Installation:ensurecorrectinstallationaccordingtoinstructionsfromthe
manufacturerwithrecommendedinstallationtools.
 Ensureventilationandsmoothnessaccordingtorelevantventilationstandard.

1.8SafetyInstructionsforPowerCablesandAccessories
Properpowersourceonly
Startonlywithpowersourcethatsatisfiesvoltagelabelandthevoltagenecessary
accordingtothismanual.PleasecontacttechnicalsupportpersonnelofVantronfor
anyuncertaintyabouttherequirementsofnecessarypowersource.
Usetestedpowersource
Thisproductstillcontainsabuttonlithiumbatteryasareal‐timeclockafterits
externalpowersourceisremovedandthereforeshouldnotbeshort‐circuitedduring
transportationorplacedunderhightemperature.

FPA-C34, FPA-W34
6/ 17
Placecablesproperly:
Donotplacecablesatanyplacewithextrusiondanger.

CleaningInstructions
 Pleasepoweroffbeforecleaningthedevice.
 Donotusespraydetergent.
 Cleanwithadampcloth.
 Donottrycleaningexposedelectroniccomponentsunlesswithadustcollector.
 Supportforspecialfault:Poweroffandcontacttechnicalsupportpersonnelof
Vantronincaseofthefollowingfaults:
 Thedeviceisdamaged.
 Thetemperatureisexcessivelyhigh.
 Faultisstillnotsolvedaftertheoperationaccordingtothemanual.


FPA-C34, FPA-W34
7/ 17
2. Overview
2.1Introduction
ThankyouforchoosingVantron.Itisourcommitmenttoprovideourvalued
customerswiththeembeddeddevicesequippedwiththestate‐of‐the‐art
technologyandthebestproductservices.
Vantron’sM2MproductsarebasedonthemostadvancedARMandIntelAtom
processorsandhavelow‐powerconsumptionandhighintegration.Theproductsare
designedforapplicationsofM2Minindustrials,medicals,financial,retail,vehicle,
andtransportationsetc.

2.2Howtosetupandusethedevice
Tousethedevice,pleaseinstalltheunitstably,andassembleitsantenna(s)for
WLAN(BlueTooth),CELLandpossibleGPS,ifthedeviceisconfiguredforCELLfunction,maybeyou
needtoactivatetheSIMcardagainstpropercarrier,andthenpleaseinsertcorrect12‐24VDC
cabletothepowerjackofthedevice,thedevicewillbepoweredupandthePWRLEDlighting
indicatesthesystembootsup.ThedevicehaveastandardRJ45Ethernetportwhichsupporting
10M/100MFull/HalfDuplex.

ThedeviceintegratesaWebPageSubsystemtoprovideawebpageforusertocontrolthe
system. ThedefaultIPaddressis“192.168.0.1”,thedefaultusernameandpasswordare
“root/admin”.YoucansetupsuchasWAN,Network,CELL,Wirelessviawebpage.Follow
guidelinesofapplicationsoftwareforfurthercommenttothedeviceusageplease.




















FPA-C34, FPA-W34
8/ 17







FPA-C34, FPA-W34
9/ 17
3. M2MGateway‐FPA‐C34,FPA‐W34HardwareInstructions
3.1ProductAppearance



FrontSideView


LightSideView

FPA-C34, FPA-W34
10/ 17
3.5InterfaceDescription
3.5.1PowerInterface


Powerconnectoroutlook

PinDescription
1Powerinputrange12‐24V
2Ground
3Shellground
3.5.2EthernetInterface
StandardRJ45interface,supporting10M/100MFull/HalfDuplex,thisisa
standardRJ45Ethernetport
PinDescriptionRemarks
1ETH_TX+O
2ETH_TX‐ O
3ETH_RX+I
4ETH_RX‐ I
5ETH_CT
6ETH_CT
7NC
8DGNDP
9LEDG+IO
10LEDG‐ IO
11LEDG+
12LEDG‐ 
PIN1