Victory Sanitizers Plus VP200ESK Firmware update

VP200ESK •Safety Instructions •1
Important Safety Instructions
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •2
IMPORTANT: The Electrostatic Sprayer has been designed and engineered to be very safe
during normal operation. As with all cordless products certain safety precautions should be
taken.
Please read the following WARNINGS before operating the machine.
Understand these safety precautions before operating machine. Failure to properly follow these
Important Safety Instructions
WARNING:
including the following:
• Read all the instructions before using the appliance.
•
children.
• Do not contact moving parts.
• Only use attachments recommended or sold by the manufacturer.
•
place or store appliance where it can fall or be pulled into a tub or sink.
• Use only the charger supplied by the manufacturer to recharge.
WARNING: It is the operator’s responsibility to read and understand the cautions and
warnings in this manual before attempting to operate this machine.
Items Included:
1 Professional Electrostatic Sprayer
1 Tank
1 16.8 Volt Battery (3400 mAh)
1 16.8 Volt Charger
1 Tank Cap
Product Components:
Tank
Tank Release
Tank Locking Collar
16.8 Volt Battery
Unit ON/OFF
Lock OFF Switch
Electrostatic Charge ON/OFF
Headlight
Grounding Strap
Optional Accessories Sold Separately:
VP20B Professional 16.8 Volt Battery
VP10 Professional 16.8 Volt Charger
VP30 VP200 Replacement Tank
B
B
E
E
F
F
CC
G
G
D
D
H
H
J
J
I
I
A
A
Tank Cap
Professional Electrostatic Sprayer
16.8 V Battery 16.8 V Charger Nozzle Wrench
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •3
WARNING: This product contains chemicals known to the State of California to cause
cancer and birth defects or other reproductive harm.
WARNING
WARNING: Read and understand all instructions. Failure to follow all instructions listed
WARNING: This machine contains an electrostatic device that may interfere with sensitive
DO NOT operate
this machine or stand within 10 feet if you use such medical devices. Contact your
physician prior to operation if you are unsure if this machine will interfere with your
medical device.
WARNING:
Never attempt to personally service the machine or access its internal components.
General Safety Rules for All Battery-Operated Sprayers
Save These Instructions
• Keep your work area clean and well lit.
•
dust or fumes.
•
can cause you to lose control.
CAUTION
TO AVOID ELECTRICAL SHOCK
DO NOT TOUCH OR INSERT
ANYTHING INTO THE NOZZLE
OF THE SPRAYER
RE AD AND UNDERSTAND
OWNERS MANUAL AND
ALL OTHER SAFE T Y
INS TRU C TION S BEF ORE
OPERATING THIS MACHINE
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •4
Electrical Safety
• CAUTION:
• A cordless sprayer with integral batteries or a separate battery pack must be recharged only
•
Personal Safety
•
or medication.
• A moment of inattention while operating cordless sprayer may result in serious personal
injury.
• Avoid accidental starting. Be sure switch is in the locked or OFF position before inserting
battery pack.
•
the switch ON invites accidents.
• Do not overreach. Keep proper footing and balance at all times. Proper footing and balance
•
Formulations
• Most water based chemicals are suited for machine. Questions? Call 952-843-5100
Do Not Use This Cordless Sprayer To Apply Flammable Liquids.
•
• Store formulation in its original labeled container.
• Ensure that formulation is applied only in strict compliance with the formulation label as
•
Tool Use And Care
• Do not use a machine that is broken or damaged in any way.
• Do not alter the machine by adding or removing parts.
• Do not restrict the motor air inlet area.
•
• Do not allow the machine to operate unattended.
• Do not stand in water or hold over water while operating machine.
• Do not use outdoors when it’s raining.
•
cannot be controlled with the switch is dangerous and must be repaired.
• Disconnect battery pack from cordless sprayer or place the switch in the locked or OFF
Such preventative safety measures reduce the risk of starting the cordless sprayer accidentally.
• Store idle cordless sprayer out of reach of children and other untrained persons. Cordless
sprayers are dangerous in the hands of untrained users.
•
•
components run water through the sprayer for 3 minutes.
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •5
Important Safety Instructions for Battery Packs
battery
pack is not fully charged out of the carton. Before using the battery pack and
safety instructions below. Then follow charging procedures outlined.
CAUTION:
Do not attempt to disassemble the battery or remove any component projecting from the
battery terminals. The battery and charger have no user serviceable parts. Fire or injury may
to prevent shorting.
DANGER:
electrocution may result.
WARNING:
CAUTION: Battery pack must be securely attached to the cordless sprayer. If battery pack is
Do not incinerate the battery pack even if it is severely damaged or is completely worn out.
Charge the battery packs only with a Victory Innovations charger.
DO NOT
Do not store or use the tool and battery pack in locations where the temperature may reach
Damaged battery packs should be recycled.
UNLESS
make sure that the battery terminals are protected and well insulated from materials that could
contact them and cause a short circuit.
Important Safety Instructions for Battery Chargers
SAVE THESE INSTRUCTIONS: This manual contains important safety instructions for battery
DANGER:
conductive objects.
WARNING:
CAUTION:
rechargeable batteries. Other types of batteries may burst causing personal injury and damage.
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •6
CAUTION:
buildup of metallic particles should be kept away from charger cavities. Always unplug the
charger from the power supply when there is no battery pack in the cavity. Unplug charger
before attempting to clean.
DO NOT attempt to charge the battery pack with any chargers other than the one noted in this
These chargers are not intended for any uses other than charging Victory Innovations rechargeable
charger to rain or snow.
Pull by plug rather than cord when disconnecting charger. This will reduce risk of damage
to electric plug and cord.
subjected to damage or stress.
Recommended Minimum Wire Size for Extension Cords:
Total Length of Cord
Do not place any object on top of charger or place the charger on a soft surface that might block
any heat source. The charger is ventilated through slots in the top and the bottom of the housing.
Do not operate charger with damaged cord or plug — have them replaced immediately.
in any way.
Disconnect the charger from the outlet before attempting any cleaning. This will reduce the risk
of electric shock. Removing the battery pack will not reduce this risk.
NEVER attempt to connect two (2) chargers together.
The charger is designed to operate on standard household electrical power (120 or 240 Volts)
with proper country plug.
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •7
Operation Instructions
1.
inserting the Victory 16.8 volt battery into the charger and plugging the charger into a wall
socket.
2.
and pulling the tank release ring . The tank can now be removed. Note: you must hold
3.
4. Insert the tank into the sprayer and rotate the tank locking collar until you hear the click
of the tank release ring snap into place.
5. Insert the charged battery into the battery socket and lock in place.
6. Pull the trigger and spray on your desired surface.
the handle in contact with the grounding strap
B
B
B
E
F
C
C
C
G
D
H
J
I
A
A
Tank Cap
Professional Electrostatic Sprayer
16.8 V Battery 16.8 V Charger Nozzle Wrench
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •8
Nozzle Instructions
To Adjust the Nozzle:
• Remove the battery from the unit.
•
•
•
the medium particle and rotate clockwise again until it clicks again to get the smallest particle.
• Remove the wrench when complete.
To Remove the Nozzle
• Remove the battery from the unit.
•
•
• When the tabs and slots are lined up the wrench will be completely inserted into the front end.
•
(¼ rotation).
• Remove the wrench when complete.
To Insert Nozzle
• Remove the battery from the unit.
•
•
•
is in position.
• Remove the wrench when complete.
Cleaning Electrostatic Sprayers
cleaning the sprayer.
It is recommended that user should purchase a second tank to wash out cordless electrostatic
sprayers to prevent residual solution build up. Disconnect the storage tank from the sprayer
and use the black threaded cap that is included. Disconnect storage tank from sprayer use the
locking threaded cap to secure tank and solution when not in use.
Review chemical MSDS sheet how best to secure and store your chemical solution when not in use.
Cleaning Nozzle
remove blockage.
Example below:
recommendation is that a full tank of water is sprayed through the unit after every few days of
use to rinse any residual chemical build-up to reduce the chance of blockage.
Nozzle #1 (Dirty)
Nozzle #2 (Clean)
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •9
How to Use
Charge Battery
The lights on the right are fully
illuminated when the battery
is empty. The lights on the left
are fully illuminated when the
battery is charged. Charge
time is two (2) hours.
Adjust Nozzle
particles.
an opening resembling a line.
Remove Tank
1. Rotate collar to unlocked
position.
2. Pull locking ring to remove.
3.
tank.
Spray
The optimum sprayer distance
is 24 inches (61 cm).
Connect Tank
1. Align tank grooves into slide
onto the tank.
2. Listen for a click.
3. Rotate collar to locked
position.
Clean Up
water through the sprayer to
rinse the components of any
chemical build-up.
Largest
1 1
2 2
3 3
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/

VP200ESK •Safety Instructions •10
One Year Limited Warranty
workmanship for one year from the date of purchase. This warranty does not cover part failure
due to normal wear or tool abuse. For further detail of warranty coverage and warranty repair
to damage caused where repairs have been made or attempted by others. This warranty gives
FREE WARNING LABEL REPLACEMENT:
Sanitizers Plus • 3590 N.W. 54th Street Suite 9 Ft. Lauderdale, FL 33309
• https://www.sanitizersplus.com/