Volvo 31285376 User manual

Instruction No Version Part. No.
31285377 1.2 31285376, 31339014
Navigation system, portable, Installation kit TMC
Instruction No Version Part. No.
31285377 1.2 31285376, 31339014
Navigation system, portable, Installation kit TMC
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 1 / 35

Equipment
A0000162 IMG-246925
IMG-298683
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 2 / 35

IMG-213320
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 3 / 35

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
IMG-312464
Note!
On cars being installed with the portable Navigation system
and TMC kit, the short cable harness in the Navigation system
kit (see image) must not be used. It must be replaced with
cable harness A in the TMC kit.
2
IMG-246024
Applies to all models
Turn the ignition key to position 0.
Disconnect the battery negative lead.
Note!
Wait at least three minutes before unplugging the connectors
or removing other electrical equipment.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 4 / 35

3
IMG-299783
Remove the ventilation outlet by carefully inserting special tool
9995919 between the ribs and carefully pulling up the four
catches on the lower edge. Carefully pry using a weatherstrip
tool.
Note!
Pay particular care to the dashboard and the outlet ribs. These
can easily be damaged as the outlet is mounted very firmly.
4
IMG-299784
Unplug the connector for the warning flashers and move the unit
aside.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 5 / 35

5
IMG-279343
Open the glovebox.
Carefully pry off the panel inside the centre console. Use a
plastic weatherstrip tool. The panel is secured by two clips on
each of the short sides.
Pull the panel away downwards.
6
IMG-263505
Remove the rubber mat and storage compartment.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 6 / 35

7
J8504893
Detach the surround around the display and the media player by
pressing in the catch at the edge of the media player cover. Use
a small screwdriver. Carefully pry off the surround at the corner.
Use a plastic weatherstrip tool.
Note!
Do not damage the panel and dashboard.
Repeat the operation on the other side.
Hint
If the other side does not detach, press the detached side into
position again and repeat the procedure, beginning from the
other side.
Fold the surround backwards. Remove by pulling upwards.
8
J8504534
Press out the display module from the reverse of the center
console. Use both hands and press straight back.
Disconnect the two connectors. Put the display to one side.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 7 / 35

9
IMG-263585
Carefully pry loose and remove the hand brake lever's panel.
10
IMG-270743
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 8 / 35

11
IMG-263588
Applies to cars with manual gearbox
Remove the gear selector lever boot from the center console.
First pry it off at the front edge using a weatherstrip tool and then
unhook it at the rear edge.
12
IMG-279049
Loosen the gearshift knob from the shift by pressing down the
knob and turning it slight more than a 1/4 turn anticlockwise and
pull it up.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 9 / 35

13
IMG-263584
Applies to all models
Remove the two screws holding the centre console at the rear
edge.
14
IMG-263944
Applies to the C70
Remove the rear seat cushion by first pressing the outer edges
of the cushion backwards and then by pulling them upwards so
that the outer hooks release.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Navigation system, portable, Installation kit TMC- 31285377 - V1.2
Page 10 / 35