WaterChef Countertop C7000 User manual
This System does not require
the services of a plumber.
Premium Water Filtration
C7000
INSTALLATION, USE & CARE GUIDE
COUNTERTOP
Filtration System
QUESTIONS?
1.800.879.8909
(int’l +1.775.359.9500)
MON - FRI 8 AM - 5 PM PST
Read & Save These Instructions.
Important
System Tested and Certified by NSF International against NSF/ANSI Standard 42
for the reduction of Chloramine, Chlorine Taste and Odor, and nominal Particulate
Class I and NSF/ANSI Standard 53 for the reduction of Cysts, Lead, VOC and MTBE.
bpafree
ASSEMBLED
USA
ASSEMBLED
USA
www.waterchef.com 1
Introduction ............................................................ 1
Important Use Guidelines ................................................. 1
................................................... 2
Replacement Parts Directory .............................................. 2
Setup and Installation .................................................... 3
Replacing the Filter Cartridge .............................................. 5
Troubleshooting ......................................................... 7
Warranty............................................................... 8
Product Registration ..................................................... 9
Lid and Housing Assembly
3 Piece Faucet Adapter Kit
(includes 3 washers)
Battery Shuttle
(includes Battery)
Included Literature:
- Installation, Use & Care Guide
- Performance Data Sheet
- Product Registration Card
WaterChef®CR70
Filter Cartridge
(ships pre-installed in
housing assembly)
INTRODUCTION
Diverter Assembly
Congratulations on the purchase of your new WaterChef®Premium Filtration System!
You have taken an important step toward improving the quality of your drinking and cooking
cabin or RV.
workmanship, and will serve you reliably for many years to come when operated and maintained
according to the directions contained in this guide. You have made a wise investment in
providing quality water for you and your loved ones. Now please take a few minutes to learn
1. Read this manual completely before attempting to install or use this product.
2. Replacement Filter Cartridges may be purchased from a WaterChef reseller. For the
location of the reseller nearest you, or for additional purchase information, please contact
WaterChef Customer Care at 1.800.879.8909 (int’l +1.775.359.9500).
3. The actual capacity of your Cartridge may vary from the rated capacity. This may be due
to the volume of contaminants or sediment actually present in your water supply.
-Annually
-
-When you notice a taste or odor recurrence
-When the rated capacity of the Filter Cartridge has been reached
-When the Intelligent Monitor™
4. Do not use water that is microbiologically unsafe or of unknown quality without adequate
disinfection before or after the System.
6. For use on cold potable water supplies only.
7. For this System to continue to perform as tested and represented, be sure to use only
®CR70 Filter Cartridges.
8. Do not allow System to sit for extended lengths of time without being used (10 days or
more). If System must be left unused for more than 10 days, drain all water from the
for 15 min. prior to use. (The ushed water can be used to water plants.)
9. Installation of this product must comply with all state and local laws and regulations.
Refer to your local agencies for details.
10. The contaminants or other substances removed or reduced by this System may not be
in all users’ water.
TABLE OF CONTENTS
WHAT’S IN THE BOX [MODEL: C7000]
HAVE QUESTIONS OR NEED ASSISTANCE?
IMPORTANT USE GUIDELINES
WaterChef Customer Care is here to help if you ever have questions or need
assistance with your WaterChef Filtration System.
1.800.879.8909
customercare@waterchef.com
www.waterchef.com
3
www.waterchef.comwww.waterchef.com
2
1. Open the shipping carton, remove all System parts
and place them on your kitchen counter.
2. Compare them with the parts shown in this guide to be
certain all items were included (see inside front cover).
3. Unthread and remove the aerator from the end of your
kitchen faucet if it has one. (g. A)
4. Thread the Diverter Valve directly onto your kitchen
faucet. Do not over-tighten. (g. B)
5. If the threads to the Diverter Valve do not directly
attach to your kitchen faucet, use one of the three
Adapters provided. (g. C)
6. Most kitchen faucets with external threads will directly
attach to the Diverter Valve. In some instances the
Diverter Valve may be smaller than your kitchen faucet.
In this case use the adapter with internal threads and
thread it directly to your kitchen faucet. Next, thread
the Diverter Valve to the Adapter. (g. D)
7. If your kitchen faucet has internal threads, thread
one of the two Adapters with external threads directly
to your kitchen faucet. Next, thread the Diverter Valve
to the Adapter. (g. E)
8. If your kitchen faucet does not have threads, measure
the inside diameter of the kitchen faucet and call
WaterChef Customer Care at 1.800.879.8909
to request an Expandable Adapter.
provided, send your threaded aerator to:
WaterChef Customer Care
3760 Barron Way
Reno, NV 89511
Include a note requesting an Adapter that ts your threads.
(continued on next page)
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Countertop
Particle Retention Size . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Sub-Micron
Intelligent Monitor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rated Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1,000 gallons (US)
Rated Service Flow. . . . . . . . . . . . . . . . . . . . . . . . . . . 0.65 gal/min @ 60 psi
Maximum Working Pressure . . . . . . . . . . . . . . . . . . . . . . . 100 psig (689.5 kPa)
Minimum Working Pressure . . . . . . . . . . . . . . . . . . . . . . . 30 psig (206.8 kPa)
Maximum Operating Temperature . . . . . . . . . . . . . . . . . . . . . . . .
Minimum Operating Temperature . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement Filter Cartridge (includes Battery) . . . . . . . . . . . . . . . . . . . . . .CR70
. . . . . . . . . . . . . . . . . . . . . . . . . . 63018-NV-001
Protected under U.S. Patent #: D408,494
Refer to Performance Data Sheet for actual contaminant and substance reduction capabilities.
PRODUCT SPECIFICATIONS SETUP & INSTALLATION
note
This System is not recommended for installation on pull-out faucets.
2
4
6
ITEM PART # DESCRIPTION
1215-55-05 Lid Assembly (White)
1215-41-01 Lid Assembly (Black)
24-104-0052-02 Battery Shuttle (White) (includes Battery)
24-104-0052-01 Battery Shuttle (Black) (includes Battery)
1215-10-37 Housing Assembly (White)
1215-20-40 Housing Assembly (Black)
4CR70 Filter Cartridge (includes Battery)
0581-03-02 3/8” Diverter Valve Assembly (White)
0581-03-15 3/8” Diverter Valve Assembly (Black)
69-904-0023 Faucet Adapter Kit (3 pieces)
A
B
C
D
E
REPLACEMENT PARTS DIRECTORY
System Tested and Certified by NSF International against NSF/ANSI Standard 42 for the reduction of Chloramine, Chlorine
Taste and Odor, and nominal Particulate Class I and NSF/ANSI Standard 53 for the reduction of Cysts, Lead, VOC and MTBE.
www.waterchef.comwww.waterchef.com
I
The most important part of maintaining your WaterChef Filtration System is replacing the
Filter Cartridge (and Battery) on a regular service interval. To insure your System continues to
perform as stated in the Performance Data Sheet, the Filter Cartridge should be replaced
- Annually
- When you notice a taste or odor recurrence
- When the rated capacity of the Filter Cartridge has been reached
- When the Intelligent Monitor™
54
REPLACING THE FILTER CARTRIDGESETUP & INSTALLATION
10. Determine which side of the sink
you want your System:
To position System to the LEFT side
Unthread Lid Assembly
from Filter Housing, then orient the Lid
Assembly to Filter Housing as shown.
(g. F, Step 1) Once positioned, thread
Lid Assembly clockwise onto the Filter
Housing until tightened. (g. F, Step 2)
To position System to the RIGHT side
Unthread Lid Assembly
from Filter Housing, then orient the Lid
Assembly to Filter Housing as shown.
(g. G, Step 1) Once positioned, thread
Lid Assembly clockwise onto the Filter
Housing until tightened. (g. G, Step 2)
into the Filter Base. (g. H)
12. Insert Battery Shuttle (with included Battery) into Lid
Assembly.
(g. I) The Intelligent Monitor™
and
the rated capacity counter to zero gallons. Do NOT
remove Battery Shuttle until it is time to replace
the Filter Cartridge. Removing Battery Shuttle
13. With System placed on the counter and positioned
water faucet “ON” and pull Diverter Pin. (g. J) Water
™will
performance. Check to see that all hose, lid and
housing connections are tight and do not leak.
14.
over from the manufacturing process, expel trapped
air and condition the Filter Cartridge for normal use.
(This water may be used to water plants.)
1. Remove the Lid Assembly by turning counterclockwise
until it separates from the Filter Housing. As you
remove the Lid Assembly, the Filter Cartridge will
remain attached to the Lid Assembly. (g. K)
2. Hold the Lid Assembly and rotate the Filter Cartridge
counterclockwise to remove. Discard the used Cartridge
with your regular refuse. (g. L)
3. Wash the inside of Filter Housing and Lid Assembly
with warm water, a mild dish washing detergent and
a clean cloth.
4. Remove the plastic sanitary wrap from your new Filter
Cartridge. Thread the new Cartridge clockwise onto
the threaded post on the Lid Assembly until you
feel resistance. Make an additional quarter turn.
Do NOT over-tighten. (g. M)
(continued on next page)
spout
facing
into sink
spout
facing
into sink
STEP 1
STEP 1
STEP 2
STEP 2
LEFT Placement
RIGHT Placement
line up
FRONT
of Lid
Assembly
with hose
outlet
line up
BACK
of Lid
Assembly
with hose
outlet
Rubber gloves should be worn to avoid direct contact with filtered
contaminants.
recommendatIon
Do NOT use abrasive pads or other abrasive materials to clean
Filtration System.
cautIon
Be sure to use only genuine WaterChef®CR70 Filter Cartridges with this System. Only WaterChef Filter Cartridges
have been tested and certified by NSF International to insure the performance represented in the Performance
Data Sheet.
Important
F
G
H
J
K
L
M
Repeat flushing procedure each time a new Cartridge is installed.
Important
Congratulations! Your new WaterChef®Filtration System is ready!
www.waterchef.com www.waterchef.com
spout
facing
into sink
spout
facing
into sink
STEP 1
STEP 1
STEP 2
STEP 2
LEFT Placement
RIGHT Placement
line up
FRONT
of Lid
Assembly
with hose
outlet
line up
BACK
of Lid
Assembly
with hose
outlet
76
5. Determine which side of the sink
you want your System:
To position System to the LEFT side
Orient the Lid Assembly to
Filter Housing as shown. (g. N, Step 1)
Once positioned, thread Lid Assembly
clockwise onto the Filter Housing until
tightened.
(g. N, Step 2)
To position System to the RIGHT side
Orient the Lid Assembly to
Filter Housing as shown. (g. O, Step 1)
Once positioned, thread Lid Assembly
clockwise onto the Filter Housing until
tightened.
(g. O, Step 2)
6. Remove the Battery Shuttle from Lid
Assembly and replace your existing Battery with the
re-insert Battery Shuttle into Lid Assembly. (g. P)
The Intelligent Monitor™
and
counter to zero gallons. Do NOT remove Battery
Shuttle until it is time to replace the Filter Cartridge
again. Removing Battery Shuttle prematurely may
kitchen sink. Turn the cold water faucet “ON” and
pull the Diverter Pin. (g. Q)
System, the Intelligent Monitor™
8.
over from the manufacturing process, expel trapped
air and condition the Cartridge for normal use.
(This water may be used to water plants.)
N
O
REPLACING THE FILTER CARTRIDGE
P
CONDITION
REASON
There is a presence of calcium carbonate in
your main water supply. This condition will
or frozen and then melts.
SOLUTION
This condition is normal – no action is
required. However, you may choose to
strain the white sediment.
CONDITION
Ice cubes appear cloudy in the center.
REASON
Minerals such as calcium and magnesium
that are present in your water supply
collect in the center of ice cubes when
the water is frozen.
SOLUTION
No action is required. Your System is
trace minerals in your water.
CONDITION
™
REASON
Your Filter Cartridge is reaching the end
of its rated capacity and will need to be
replaced soon.
SOLUTION
®
CR70 Filter Cartridge. For the location of
the reseller nearest you, call WaterChef
Customer Care at (int’l
CR70 Cartridge and Battery (included).
CONDITION
REASON #1
There could be a lack of lubricant on the
shaft of the Diverter Valve.
SOLUTION #1
Remove the Diverter Valve from the kitchen
faucet. Press petroleum jelly into opening
on the Diverter Valve. Work the Diverter Pin
in and out until a smooth motion is restored.
REASON #2
Hard water (water with high content of
dissolved minerals) has caused a buildup
in the Diverter Valve.
SOLUTION #2
Soak Diverter Valve in vinegar for several
hours to remove buildup. Then rinse
Diverter Valve with warm water. Press
petroleum jelly into opening on the Diverter
Valve and work the Diverter Pin in and out
until a smooth action is restored. Replace
rubber washer and reconnect the Diverter
Valve to the kitchen faucet.
CONDITION
the System.
REASON
supply may cause premature plugging of
Filter Cartridge. This condition may occur
SOLUTION
Filter Cartridge must be replaced due to
poor water quality conditions in your area.
NOTE: Battery MUST be replaced at time
of Cartridge replacement. (CR70 Filter
Cartridge includes a new Battery.)
TROUBLESHOOTING
Q
Repeat flushing procedure each time a new Cartridge is installed.
Important
www.waterchef.com www.waterchef.com 98
WATERCHEF®PRODUCT REGISTRATION
NOTES
®!Don’t forget to take a moment to register your new System.
Doing so will allow us to better serve you in the event that technical or warranty assistance is
ever required.
Simply visit www.waterchef.com to register your system online, or if you prefer, you may complete
and return this registration form to: WaterChef Customer Care · 3760 Barron Way · Reno, NV 89511
( )
C7000
WaterChef Updates, Special Promotions & Exclusive Discounts!
Please send me Courtesy Email Notications
We value your privacy and will not sell or share your information with anyone. You may unsubscribe from updates and cartridge
reminder notications at any time.
LIFETIME LIMITED WARRANTY
WaterChef®warrants that for the lifetime of the original purchaser and from the date of
purchase, this product will be free from defects in materials and workmanship.
WaterChef, at its option, will repair or replace this product or any component of the product
found to be defective during this warranty period. Replacement will be made with a new or
remanufactured product or component. If the product is no longer available, replacement
may be made with a similar product of equal or greater value. This is your exclusive warranty.
This warranty is valid for the original retail purchaser from the date of original retail purchase
and is not transferable. Keep the original sales receipt. Proof of purchase is required to obtain
warranty service. WaterChef dealers do not have the right to alter, modify or change the
terms and conditions of this warranty in any way.
This warranty does not cover normal wear of components or damage resulting from any of
the following: negligent use or misuse of the product, use contrary to the Installation, Use
and Care Guide, disassembly, repair or alteration by anyone other than WaterChef or an
WaterChef shall not be liable for any incidental or consequential damages caused by the
duration to the duration of the above warranty. Some states, provinces or jurisdictions do
not allow the exclusion or limitation of the incidental or consequential damages or limitations
on how long an implied warranty lasts, so the above limitations or exclusion may not apply
vary from state to state or province to province.
HOW TO OBTAIN WARRANTY SERVICE
Call (int’l +1.775.359.9500) or email customercare@waterchef.com. If it is
determined that it is necessary to return the product, a Return Authorization Number will be
issued. Pack
the product in the original carton, or equivalent, using newspaper or other packing materials
to protect the product from damage in transit. Before sealing the carton, be sure to include
a copy of the original sales receipt along with a note describing the nature of the defect or
problem. Be certain to include your return shipping address and Return Authorization Number
on the outside of the carton.
Ship the product postage paid to: WaterChef Customer Care
3760 Barron Way
Reno, NV 89511
Upon receiving the product, we will repair or replace the product and return it to the return
address on the shipping carton, postage pre-paid. (U.S. customers only)
Premium Water Filtration
WaterChef®|3760 Barron Way · Reno, NV 89511 |tel 800.879.8909 |int’l +1.775.359.9500 |www.waterchef.com
Manufactured by Water Safety Corporation
R 13.07 1-404-0094
Other manuals for Countertop C7000
2
Table of contents
Other WaterChef Water Filtration System manuals
Popular Water Filtration System manuals by other brands
Brita
Brita MAXTRA Aluna Instructions for use
GRUNDFOS ALLDOS
GRUNDFOS ALLDOS Oxiperm Pro OCD-162 Installation and operating instructions
Riello
Riello BAG3 MIX BASIC Instructions for the Installaer and for Technical Assistance
UJETA
UJETA CARE operating instructions
AQUAPHOR
AQUAPHOR APRO WH 1000 LPH manual
Wasserhaus
Wasserhaus QuaRO Series Installation and user manual