Westerbeke 8.5 BTG User manual

SERIES -8 .5 BTG
8.5 kw Gasollne Marine Generator Set
n~ ~m, REMOVABlE
RAW WATER
INLEJCONN .
1 1.0. HOSE
PlAST1C
BELT GUARD
'*9-- ilfft t-
1-- -----20 . 31 ----- ~
TECHNICALDATA
DESIGN: Brushless, four pole, revolving field, self regulating,
pre-lubricated single bearing design. (Optional full power
take-off through rear of generator available .)
VOLTAGE REGULATION: Standard ±5 % no load to full
load. (With optional solid state voltage regulation ±2 % no
load to full load.)
FRE QUENCY REGULATION: 3 Hertz (5%)no load to full
load.
INSULATION: Class F as defmed by NEMA MGI-1.65.
TEMPERATURE RISE: Within NEMA MGI-22.40 defmi-
tion when operating at full load.
COOLING: Centrifugal blower, direct connected.
RADIO I NTERFERENCE LEVEL: Exc eeds requirements
for most marine radio-telephone equipment and standard
AM
televisions.
ARMATURE: Balanced laminated steel, double.cJipped and
baked.
mCTRICAl ClWlACTERISTICS ) RATINGS
DERATINGS ENGINE
Mode'
Vo lts
mOl
Hem Phlle
.r,:~:l,
WlreFacl"KW
RPM SII.
8. 5-61 ."
120/2'
r ~
60 1 4 1.0 8.5
%fo reach 100f
1800 Remol
6. 8- 514
220 50 1 , 1.0
7.0 (S'CI
'boV!
1500 Remot
8S"F (30'C)
Re co nn ec tab le10 120 volts 0 60 Hz or 110 volts 0 50 Hz0 twice the ampera ge.
ENGINE
En gine type ...................... 4 cylinder, 4 cycle
Displacement .......................... 65.4 C.I.O.
Compression ratio . .... . . . .. .. .............. ,9.2:1
Fue l .................................... Gasoline
Block .................................. Cast iron
Valve system ......... Operated byoverhead cam shaft-
c hain driven
Main bearings .. . ........................... Five
Carbureto r . . . . ...... Down draft type with U.S.C.G.
approved flame arrestor
Governor ....... Hoof, fIybaII type, 5% speed regulation
Ignition system ........ Horizontal electronic distibutor
driven by overhead cam . Reduces height and
eliminates service points.
Ignition system R.F. I. suppressed
Weight .................. . .......... . ..... 513lbs
Starting motor . .............. 12 volt negative ground
Battery c harging alternator ................ 51 amps
C ENTERS
FOR "., BOLT S
ORWl
SC REWS
STANDARD EQUIPMENT
DRIP TRA Y
• Brushl ess Generator . Overspeed Shutdown . High
Water Temperature Shutdown . Low Oil Pressure Shut-
down • Lightweight Mounting Rails . Vibration Isolator
Mounts 0 High Exhaust Temperature Shutdown 0 Flexible
Fuel Supply Line 0 Lifting Eyes 0 Belt Guard 0 Fresh
Water Cooled Exhaust Manifold 0 Raw Water
Pump 0 51
Amp Alternator (Igniti on Protected) 0 Hoof Speed Gover-
nor 0 Down Draft Carburetor 0 Flame Arrestor (USCG Ap-
proved) 0 RFI Reduction (Igniti on Shielding) 0 Water In-
jected Exhaust Elbow 0 Fresh Water Coolant Recovery
Tank . Lube Oil Drain Hose . Operator's Manual . Unit
Mounted Control Panel includes On-Start and Stop Switches,
Engine Hour-Meter and Remote Terminal Connecti
OPTIONAL EQUIPMENT
• Remote Control Panel . 15 'Connector for Remote Panel
o Ship/Shore Transfer Switch 0 Electronic Voltage Regu-
lator • Hydro Hush Exhaust Silencer . Remote Engine In·
struments • Parts Catalog • Instruction Manual
HYDRO-HUSH
SILENCER
---
---_ ....
Call your Westerbeke representative
orcontact the Westerbeke Corporation
' '''"l:j WESTERBEKE
WESTERBEKE CO RPORATION
8/87 AVONINDUSTRIAL PARK. A VO N, MA 02322 . TE L [phone]
6M
~;"U.sA