Advantech PCM-3380 Installation and operation manual

PCM-3380 Startup Manual 1
PCM-3380 Intel
®
Pentium
®
M/Celeron
®
M/PCI-104 CPU module Startup Manual
PCM-3380 Intel
®
Pentium
®
M/Celeron
®
M PCI-
104 CPU module Startup Manual
Before you begin installing your card, please make
sure that the following materials have been shipped:
If any of these items are missing or damaged, contact
your distributor or sales representative immediately.
Note 1: For detailed contents of the PCM-3380,
please refer to the enclosed CD-ROM (in PDF
format).
Note 2: Acrobat Reader is required to view any PDF
file. Acrobat Reader can be downloaded at:
www.adobe.com/Prodindex/acrobat/read-
step.html (Acrobat is a trademark of Adobe)
Standard Motherboard Functions
• CPU: Embedded Intel Pentium-M Processor 1.1GHz, Cele-
ron-M 600 MHz, Pentium-M 1.6GHz (option)
• Second level cache: 1MB on Pentium-M processor,
512KB on Celeron-M 600MHz
• BIOS: AWARD 512 KB Flash memory
• System Chipset: Intel 855GME ICH4 Chipset 400MHz FSB
• Enhanced IDE interface: Supports up to two EIDE devices.
BIOS auto-detect, PIO Mode 3 or Mode 4 transfer, Ultra
DMA33 mode supported
• Serial ports: 2 serial ports with power (option by cable)
COM1,2: RS-232
• Parallel port: One parallel port, supports SPP/EPP/ECP
mode
• DRAM: 200 pin SO-DIMM sockets, support 128 MB to 1GB,
accept 128/256/512/1000MB, DDR200/266/333 DRAM
• Keyboard/mouse connector: 6-pin wafer box connector for
keyboard and PS/2 mouse
• SSD: Supports CompactFlash Card Type I / Type II (option for
Micro Drive)
• Power management: Supports Advanced Power Manage-
ment /ACPI, Intel Speedstep
• Watchdog timer: 255-level-interval Watchdog timer, setup by
software, selection, generates system reset
• Audio: AC' 97 2.0 compliant. Supports Mic in, line in,
line out
• USB: 6 x USB 2.0, UHCI specification compliant
• FAN connector: Support for + 5 V FAN
• PCI-104 expansion: 120-pin PCI PC/104-Plus module
connector
VGA/LCD Interface
• Chipset: Intel 855GME
• Supports CRT Display, 2CH 18-bit LVDS LCD display
• Supports Dual Display Combination: CRT+ 36bit/48bit LVDS,
18bit LVDS+ 18bit LVDS
• Optimized Shared Memory Architecture, support 64MB frame
buffer using system memory
Ethernet Interface
• Chipset: Intel 82562EMT
• Ethernet interface: RJ-45 cable, PCI Ethernet controller,
IEEE 802.3u protocol compatiblePCI 10/100 Mbps Ethernet.
Solid State Disk
• Supports CompactFlash Card Type I / Type II (option for
Micro Drive)
Packing List Specifications
• 1 PCM-3380 SBC
• 1 Start-up manual
• 1 Utility CD
• 1 BATTERY 3V/210 mAf cable
CR2032WK with Wire ASS'Y
p/n: 1750129010
• 1 Y -cable external cable p/n: 1703060053
• 1 IDE cable p/n: 1701440350
• 1 Wire ATX power p/n: 1703200380
• 1 Ethernet RJ-45 Conn.conversion
cable
p/n: 1701100202
• 1 KB/MOUSE Y-cable p/n: 1700060202
• 1 COM port cable p/n: 1701200220
• 1 USB Cable Adaptor p/n: 1700000897
• 1 VGA cable p/n: 1700000898
• 1 Audio cable p/n:1700000918
• 1 LPT cable p/n:1700000916
For more information on this and other Advantech
products, please visit our website at:
http://www.advantech.com
http://www.advantech.com/epc
For technical support and service, please visit our
support website at:
http://service.advantech.com.tw/eservice/
This manual is for the PCM-3380
Part No. 2006338001
Printed in Taiwan
2nd. Edition
February 2005

2 PCM-3380 Startup Manual
Mechanical and Environmental
• Board size: 116mm X 110mm complain with PCI-104 1.0
• Weight: .277 kg (with heatsink)
• Operating temperature: 0° to 60° C (32 to 140° F)
• Storage temperature: -40° to 85° C (-40 to 185° F)
• Operating humidity: 0% to 95% relative humidity, noncon-
densing
• Power consumption: 5V +- 5%, 12V+-5%
- Celeron M 600 MHz+ DDR 512MB: Max. 2.16A@
5V;Typical 1.80A@ 5V
- Pentium M 1.1 GHz + DDR 512MB: Max. 3.68A@ 5V;
Typical 1.74A@ 5V
- Pentium M 1.6 GHz + DDR 512MB: Max. 7.37A@ 5V;
Typical 3.72A@ 5V
• Power supply voltage: -Average 500mA@12V; + 5 V ± 5 %,
+12V ± 5 %
The table below lists the functions of each of the
board connectors:
Locating connectors (component side)
Locating connectors (solder side)
Connectors
Table 1-1:
Connectors
Label Function
CN1 LCD Inverter connector
CN2 Battery connector
CN4 KB/MS connector
CN5 IDE 44pin connector
CN6 Power/Reset Header/Buzzer
CN7 PCI 104 connector
CN8 Power connector
CN9 LAN connector
CN10 FAN connector(5V Only)
CN11 Audio Line-out connector
CN12 LVDS connector
CN13 ATX AUX connector
CN14 CRT connector
CN15 Audio Line-in/Mic connector
CN16 CF connector
CN17 COM Port connector
CN18 USB connector
CN19 LPT
Locating connectors
CN8
CN2
CN15
CN1
CN4
CN14
CN10
CN13
CN11
CN5
CN12
CN9
CN7
CN17
CN19
CN18
CN6
CN8
CN15
CN11
CN14
CN12
CN13
CN7
CN6
CN1
CN2
CN4
CN5
CN9
CN19
CN10
CN17
CN18
DIMM-1
CN-16
SOM-3380 REV.A1
MADE IN TAIWAN
19A6338000
79.38 95.88
90.17
79.38 95.88
73.66
90.17

PCM-3380 Startup Manual 3
Dimensions
CN6
CN8
CN15
CN4
CN14
CN10
CN13
CN11
CN5
CN12
CN3
CN9
CN2 CN1
CN7
0.00
0.00
23.18
13.97
7.37
14.73
10.16
15.56
13.63
15.40
2.54
11.94
85.72
76.20
85.72
82.87
80.33
87.95
80.64
68.58
85.71
74.93
74.94
7.94
92.07
84.24
25.61
8.07
0.00
80.01
65.72
62.23
70.48
58.74
19A6338000
MADE IN TAIWAN
SOM-3380 REV.A1
DIMM-1
CN-16
Ø6.35
0.00
0.00
0.00
80.01
85.72
2.54
76.20
85.72
59.78
66.43
61.47
41.91
53.97
30.80
59.59
37.81