Alliance Laundry Systems BA025E User manual

Programming
Tumble Dryer
Dual Digital Control
Refer to Page 7 for Model Numbers
Original Instructions
Keep These Instructions for Future Reference.
CAUTION: Read the instructions before using the machine.
(If this machine changes ownership, this manual must accompany machine.)
www.alliancelaundry.com Part No. 70579901ENR9
October 2022

Installation must conform with local codes or, in the absence of
local codes, with:
In the U.S.A., installation must conform to the latest edition of
the American National Standard Z223.1/ NFPA 54 “National
Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric
Code.”
In Canada, installation must comply with Standards CAN/CSA-
B149.1 or Natural Gas and Propane Installation Code and CSA
C22.1, latest edition, Canadian Electric Code, Part I.
In Australia and New Zealand, installation must comply with the
Gas Installations Standard AS/NZS 5601 Part 1: General Installa-
tions.
WARNING
FOR YOUR SAFETY, the information in this manual
must be followed to minimize the risk of fire or ex-
plosion or to prevent property damage, personal in-
jury or death.
W033
WARNING
• Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
• WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Clear the room, building or area of all occu-
pants.
• Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s in-
structions.
• If you cannot reach your gas supplier, call the
fire department.
• Installation and service must be performed by a
qualified installer, service agency or the gas sup-
plier.
W052
IMPORTANT: Information must be obtained from a lo-
cal gas supplier on instructions to be followed if the
user smells gas. These instructions must be posted in
a prominent location. Step-by-step instructions of the
above safety information must be posted in a promi-
nent location near the tumble dryer for customer use.
IMPORTANT: The installer must fully test the tumble
dryer after installation and demonstrate to the owner
how to operate the machine.
WARNING
To reduce the risk of electric shock, fire, explosion,
serious injury or death:
• Disconnect electric power to the tumble dryer be-
fore servicing.
• Close gas shut-off valve to gas tumble dryer be-
fore servicing.
• Close steam valve to steam tumble dryer before
servicing.
• Never start the tumble dryer with any guards/
panels removed.
• Whenever ground wires are removed during serv-
icing, these ground wires must be reconnected to
ensure that the tumble dryer is properly ground-
ed.
W002R1
WARNING
• Installation of unit must be performed by a quali-
fied installer.
• Install tumble dryer according to manufacturer’s
instructions and local codes.
• DO NOT install a tumble dryer with flexible plastic
venting materials. If flexible metal (foil type) duct
is installed, it must be of a specific type identified
by the appliance manufacturer as suitable for use
with tumble dryer. Refer to section on connecting
exhaust system. Flexible venting materials are
known to collapse, be easily crushed, and trap
lint. These conditions will obstruct tumble dryer
airflow and increase the risk of fire.
W752R1
The following information applies to the state of Massachusetts,
USA.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
3 Part No. 70579901ENR9

• This appliance can only be installed by a Massachusetts li-
censed plumber or gas fitter.
• This appliance must be installed with a 36 inch [91 cm] long
flexible gas connector.
• A “T-Handle” type gas shut-off valve must be installed in the
gas supply line to this appliance.
• This appliance must not be installed in a bedroom or bath-
room.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
4 Part No. 70579901ENR9

Table of Contents
Introduction........................................................................................... 7
Model Identification........................................................................................7
Preliminary Information.......................................................................20
About the Control......................................................................................... 20
Glossary of Terms.........................................................................................20
Power Fail Recovery..................................................................................... 20
Control Identification........................................................................... 21
Select Cycle Keypads....................................................................................21
Display Identification............................................................................24
Light Emitting Diodes (LEDs)....................................................................... 24
CYCLE LED............................................................................................ 24
REVERSING LED (reversing models only).................................................24
Four 7-Segment Digits.................................................................................. 24
Special Features....................................................................................25
Collecting Audit Information......................................................................... 25
Testing the Machine Using Diagnostic Functions............................................. 25
Rapid Advance Feature................................................................................. 25
Machine Operation...............................................................................26
Power Up.....................................................................................................26
System Check Mode..................................................................................... 26
Start Mode................................................................................................... 26
Run Mode.................................................................................................... 26
End of Cycle Mode....................................................................................... 26
Changing Cycles...........................................................................................26
OPL Power Save...........................................................................................26
Power Failure Display Mode..........................................................................26
Error Display Mode...................................................................................... 26
Extended Tumble Mode.................................................................................26
Opening the Service Door..................................................................... 28
Stacked Tumble Dryer...................................................................................28
Stand Alone Tumble Dryer............................................................................ 28
© Copyright 2022, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed
written consent of the publisher.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
5 Part No. 70579901ENR9

Entering the Manual Mode................................................................... 30
How to Enter the Manual Mode......................................................................30
How to Exit Manual Mode.............................................................................30
Rapid Advance Feature.........................................................................31
Manual Rapid Advance Menu........................................................................ 31
Collecting Audit Information................................................................ 32
Manual Read Audit Mode Menu.................................................................... 32
Machine Diagnostic Functions.............................................................. 33
Manual Diagnostic Mode Menu..................................................................... 33
Diagnostic (Testing) Mode – Quick Reference.................................................33
Diagnostic Test Descriptions..........................................................................34
Front-End Control Software Version Number d 01 .......................................34
Input/Output Board Software Version Number d 02 ..................................... 34
Drive Board Software Version Number d 03 ............................................... 34
Fan Board Software Version Number d 04 (Tumble Dryer Designs 3 and 5,
Stacked Washer-Extractor/Tumble Dryer Designs 1 and 2)........................ 34
Ignition Control Software Version Number d 05 (gas models only)................ 34
Service Door Switch Input Test d 08 ...........................................................35
Dryer on Temperature Test d 14 ................................................................. 35
Door Switch Input Test d 15 ...................................................................... 35
Lint Door Switch Input Test d 16 ............................................................... 35
Temperature Sensor Display Test d 19 ........................................................ 35
12.5VDC Voltage Test d 20 ....................................................................... 35
24VDC Voltage Test d 21 ..........................................................................35
AC Mains Voltage Test d 28 ...................................................................... 35
Machine Configuration #1 Display Test d 29 ...............................................36
Machine Configuration #2 Display Test d 30 ...............................................36
Machine Configuration #3 Display Test d 31 ...............................................36
Machine Configuration #4 Display Test d 32 ...............................................36
Machine Configuration #5 Display Test d 33 ...............................................46
ICM Alarm Status d 34 (gas models only)................................................... 46
ICM Reset Test d 35 (gas models only)....................................................... 46
Heat Interlock Test d 36 ............................................................................ 47
Air Flow Switch Test d 37 ......................................................................... 47
Fan Motor Test d 38 ..................................................................................47
Damper Motor Test d 39 (steam models only).............................................. 47
Drive Motor Test d 40 ...............................................................................47
Factory Test Cycle................................................................................ 48
Factory Test Quick Reference Chart................................................................48
Error Codes .........................................................................................50
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
6 Part No. 70579901ENR9

Introduction
Model Identification
Information in this manual is applicable to these models. Refer
to the machine serial plate for the model number.
25 Series (11 Kg)
BA025E BU025F HG025E HU025F NJ025E PK025N SJ025R UG025S
BA025F BU025L HG025F HU025L NJ025L PR025E SJ025S UH025E
BA025L BU025N HG025L HU025N NJ025N PR025S SK025E UH025F
BA025N BU025R HG025N HU025R NJ025S PT025E SK025F UH025L
BA025R BU025S HG025R HU025S NK025E PT025L SK025L UH025N
BA025S GA025E HG025S KT025E NK025L PT025N SK025N UH025R
BG025D GA025L HH025E KT025L NK025N PT025S SK025R UH025S
BG025E GA025N HH025F KT025N NR025E PU025E SL025E UJ025D
BG025F GA025S HH025L KT025S NR025S PU025L SL025L UJ025E
BG025L GG025E HH025N MG025D NT025E PU025N SR025E UJ025F
BG025N GG025L HH025R MG025E NT025L PU025S SR025S UJ025L
BG025R GG025N HH025S MG025F NT025N SA025E ST025E UJ025N
BG025S GG025S HJ025D MG025L NT025S SA025F ST025F UJ025R
BH025E GH025E HJ025E MG025N NU025E SA025L ST025L UJ025S
BH025F GH025L HJ025F MG025R NU025L SA025N ST025N UK025E
BH025L GH025N HJ025L MG025S NU025N SA025R ST025R UK025F
BH025N GH025S HJ025N MJ025D NU025S SA025S ST025S UK025L
BH025R GJ025E HJ025R MJ025E PA025E SG025D SU025E UK025N
BH025S GJ025L HJ025S MJ025F PA025L SG025E SU025F UK025R
BJ025D GJ025N HK025E MJ025L PA025N SG025F SU025L UL025E
BJ025E GJ025S HK025F MJ025N PA025S SG025L SU025N UL025L
BJ025F GK025E HK025L MJ025R PG025E SG025N SU025R UR025E
BJ025L GK025L HK025N MJ025S PG025L SG025R SU025S UR025S
BJ025N GK025N HK025R NA025E PG025N SG025S UA025E UT025E
BJ025R GU025E HL025E NA025L PG025S SH025E UA025F UT025F
BJ025S GU025L HL025L NA025N PH025E SH025F UA025L UT025L
BK025E GU025N HR025E NA025S PH025L SH025L UA025N UT025N
BK025F GU025S HR025S NG025E PH025N SH025N UA025R UT025R
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
7 Part No. 70579901ENR9

25 Series (11 Kg)
BK025L HA025E HT025E NG025L PH025S SH025R UA025S UT025S
BK025N HA025F HT025F NG025N PJ025E SH025S UG025D UU025E
BK025R HA025L HT025L NG025S PJ025L SJ025D UG025E UU025F
BL025E HA025N HT025N NH025E PJ025N SJ025E UG025F UU025L
BL025L HA025R HT025R NH025L PJ025S SJ025F UG025L UU025N
BR025E HA025S HT025S NH025N PK025E SJ025L UG025N UU025R
BR025S HG025D HU025E NH025S PK025L SJ025N UG025R UU025S
BU025E
30 Series (13 Kg)
BA030E BT030F HA030N HT030R NH030S PR030E SJ030R UG030S
BA030F BT030L HA030R HT030S NJ030E PR030S SJ030S UH030E
BA030L BT030N HA030S HU030E NJ030L PT030E SK030E UH030F
BA030N BT030R HG030D HU030F NJ030N PT030L SK030F UH030L
BA030R BT030S HG030E HU030L NJ030S PT030N SK030L UH030N
BA030S BU030E HG030F HU030N NK030E PT030S SK030N UH030R
BG030D BU030F HG030L HU030R NK030L PU030E SK030R UH030S
BG030E BU030L HG030N HU030S NK030N PU030F SL030E UJ030D
BG030F BU030N HG030R KT030E NR030E PU030L SL030L UJ030E
BG030L BU030R HG030S KT030L NR030S PU030N SR030E UJ030F
BG030N BU030S HH030E KT030N NT030E PU030R SR030S UJ030L
BG030R GA030E HH030F KT030S NT030L PU030S ST030D UJ030N
BG030S GA030L HH030L MG030D NT030N SA030E ST030E UJ030R
BH030E GA030N HH030N MG030E NT030S SA030F ST030F UJ030S
BH030F GA030S HH030R MG030F NU030E SA030L ST030L UK030E
BH030L GG030E HH030S MG030L NU030L SA030N ST030N UK030F
BH030N GG030L HJ030D MG030N NU030N SA030R ST030R UK030L
BH030R GG030N HJ030E MG030R NU030S SA030S ST030S UK030N
BH030S GG030S HJ030F MG030S PA030E SG030D SU030E UK030R
BJ030D GH030E HJ030L MJ030D PA030L SG030E SU030F UL030E
BJ030E GH030L HJ030N MJ030E PA030N SG030F SU030L UL030L
BJ030F GH030N HJ030R MJ030F PA030S SG030L SU030N UR030E
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
8 Part No. 70579901ENR9

30 Series (13 Kg)
BJ030L GH030S HJ030S MJ030L PG030E SG030N SU030R UR030S
BJ030N GJ030E HK030E MJ030N PG030L SG030R SU030S UT030D
BJ030R GJ030L HK030F MJ030R PG030N SG030S UA030E UT030E
BJ030S GJ030N HK030L MJ030S PG030S SH030E UA030F UT030F
BK030E GJ030S HK030N NA030E PH030E SH030F UA030L UT030L
BK030F GK030E HK030R NA030L PH030L SH030L UA030N UT030N
BK030L GK030L HL030E NA030N PH030N SH030N UA030R UT030R
BK030N GK030N HL030L NA030S PH030S SH030R UA030S UT030S
BK030R GU030E HR030E NG030E PJ030E SH030S UG030D UU030E
BL030E GU030L HR030S NG030L PJ030L SJ030D UG030E UU030F
BL030L GU030N HT030D NG030N PJ030N SJ030E UG030F UU030L
BR030E GU030S HT030E NG030S PJ030S SJ030F UG030L UU030N
BR030S HA030E HT030F NH030E PK030E SJ030L UG030N UU030R
BT030D HA030F HT030L NH030L PK030L SJ030N UG030R UU030S
BT030E HA030L HT030N NH030N PK030N
T30 Series (13/13 Kg)
BAT30E BTT30F HAT30N HTT30R NHT30S PRT30E SJT30R UGT30S
BAT30F BTT30L HAT30R HTT30S NJT30E PRT30S SJT30S UHT30E
BAT30L BTT30N HAT30S HUT30E NJT30L PTT30E SKT30E UHT30F
BAT30N BTT30R HGT30D HUT30F NJT30N PTT30L SKT30F UHT30L
BAT30R BTT30S HGT30E HUT30L NJT30S PTT30N SKT30L UHT30N
BAT30S BUT30E HGT30F HUT30N NKT30E PTT30S SKT30N UHT30R
BGT30D BUT30F HGT30L HUT30R NKT30L PUT30E SKT30R UHT30S
BGT30E BUT30L HGT30N HUT30S NKT30N PUT30F SLT30E UJT30D
BGT30F BUT30N HGT30R KTT30E NRT30E PUT30L SLT30L UJT30E
BGT30L BUT30R HGT30S KTT30L NRT30S PUT30N SRT30E UJT30F
BGT30N BUT30S HHT30E KTT30N NTT30E PUT30R SRT30S UJT30L
BGT30R GAT30E HHT30F KTT30S NTT30L PUT30S STT30D UJT30N
BGT30S GAT30L HHT30L MGT30D NTT30N SAT30E STT30E UJT30R
BHT30E GAT30N HHT30N MGT30E NTT30S SAT30F STT30F UJT30S
BHT30F GAT30S HHT30R MGT30F NUT30E SAT30L STT30L UKT30E
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
9 Part No. 70579901ENR9

T30 Series (13/13 Kg)
BHT30L GGT30E HHT30S MGT30L NUT30L SAT30N STT30N UKT30F
BHT30N GGT30L HJT30D MGT30N NUT30N SAT30R STT30R UKT30L
BHT30R GGT30N HJT30E MGT30R NUT30S SAT30S STT30S UKT30N
BHT30S GGT30S HJT30F MGT30S PAT30E SGT30D SUT30E UKT30R
BJT30D GHT30E HJT30L MJT30D PAT30L SGT30E SUT30F ULT30E
BJT30E GHT30L HJT30N MJT30E PAT30N SGT30F SUT30L ULT30L
BJT30F GHT30N HJT30R MJT30F PAT30S SGT30L SUT30N URT30E
BJT30L GHT30S HJT30S MJT30L PGT30E SGT30N SUT30R URT30S
BJT30N GJT30E HKT30E MJT30N PGT30L SGT30R SUT30S UTT30D
BJT30R GJT30L HKT30F MJT30R PGT30N SGT30S UAT30E UTT30E
BJT30S GJT30N HKT30L MJT30S PGT30S SHT30E UAT30F UTT30F
BKT30E GJT30S HKT30N NAT30E PHT30E SHT30F UAT30L UTT30L
BKT30F GKT30E HKT30R NAT30L PHT30L SHT30L UAT30N UTT30N
BKT30L GKT30L HLT30E NAT30N PHT30N SHT30N UAT30R UTT30R
BKT30N GKT30N HLT30L NAT30S PHT30S SHT30R UAT30S UTT30S
BKT30R GUT30E HRT30E NGT30E PJT30E SHT30S UGT30D UUT30E
BLT30E GUT30L HRT30S NGT30L PJT30L SJT30D UGT30E UUT30F
BLT30L GUT30N HTT30D NGT30N PJT30N SJT30E UGT30F UUT30L
BRT30E GUT30S HTT30E NGT30S PJT30S SJT30F UGT30L UUT30N
BRT30S HAT30E HTT30F NHT30E PKT30E SJT30L UGT30N UUT30R
BTT30D HAT30F HTT30L NHT30L PKT30L SJT30N UGT30R UUT30S
BTT30E HAT30L HTT30N NHT30N PKT30N
35 Series (16 Kg)
BA035E BT035M HA035N HT035S NH035N PK035E SJ035L UG035N
BA035F BT035N HA035R HU035E NH035S PK035L SJ035M UG035R
BA035L BT035R HA035S HU035F NJ035E PK035N SJ035N UG035S
BA035M BT035S HG035D HU035L NJ035L PR035E SJ035R UH035E
BA035N BU035E HG035E HU035M NJ035M PR035S SJ035S UH035F
BA035R BU035F HG035F HU035N NJ035N PT035E SK035E UH035L
BA035S BU035L HG035L HU035R NJ035S PT035L SK035F UH035M
BG035D BU035M HG035M HU035S NK035E PT035M SK035L UH035N
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
10 Part No. 70579901ENR9