Antunes HEBT-5V User manual

HEBT-5V BUN TOASTER
1
P/N 1011112 Rev W 05/22
McDonald’s
BUN TOASTER
HEBT-5V
MFG. NO. 9210840, 841, 842, 843, 844, 845, 846, 847, 848, & 849
Place this manual in the Toaster section
of your Equipment Manual.
Manufactured exclusively for
McDONALD’S®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: [phone]
TOLL FREE: [phone]
FAX: [phone]
www.antunes.com
This manual is for the exclusive use of licensees and employees of McDonald’s Systems, Inc..
© McDonald’s Corporation All Rights Reserved
Owner Information................................................................. 2
General ................................................................................. 2
Service/Technical Assistance ................................................ 2
Warranty Information............................................................. 2
Specications ........................................................................ 3
Electrical Specications & Plug Conguration ...................... 3
Pass Through Time............................................................... 3
Dimensions ........................................................................... 3
Important Safety Information ............................................... 4
Installation.............................................................................. 5
Unpacking ............................................................................. 5
Location................................................................................. 5
Operation................................................................................ 6
Language Selection .............................................................. 6
Operating Instructions........................................................... 6
Club Platen OFF units (Mfg. # 9210844 & 9200847)............ 7
Programming ......................................................................... 8
Control Panel LEDs............................................................... 8
Settings ................................................................................. 8
Adjusting Toast Quality.......................................................... 8
Factory Reset........................................................................ 8
Maintenance........................................................................... 9
Belt Inspection Information.................................................... 9
Troubleshooting ...................................................................11
Replacement Parts .............................................................. 15
Wiring diagram .................................................................... 22
Scan with mobile device or enter URL
for product and service information.
HEBT-5V
http://tiny.cc/ajaHEBT5V
LIMITED WARRANTY
Antunes provides the following limited warranty to the original purchaser of all McDonald’s Equipment.
All components are warranted against defects in the material and workmanship for a period of two (2) years. If any part becomes inoperable during the period of this
warranty, Antunes will pay labor costs to an Authorized Service Agent to replace the part plus travel expenses.
Antunes reserves the right to make changes in design or add improvements on any products. The right is always reserved to modify Equipment because of factors
beyond our control and government regulation. Changes to Equipment do not constitute a warranty charge.
This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur-
pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall or any of its Divisions be liable for special conse-
quential or incidental damages for the breach or delay in the performance of this warranty.
WARRANTY EXCLUSIONS
• The cost of installation.
• Equipment that has been damaged due to shipment. Purchaser should make
damage claim directly upon carrier.
• Alteration, misuse, abuse.
• Improper storage or handling.
• Improper maintenance.
• Failure to follow proper installation instructions, including electrical connec-
tion.
• Improper or unauthorized repairs.
• Scheduled Maintenance procedures as outlined in your MRC Card.
• Consumables such as Grill Covers (Release Sheets), gaskets, Conveyor Belt
Wraps, O-rings, removal of links, and light bulbs.
• Freight, foreign, excise, municipal, or other sales or use taxes.
• Consequential damages such as loss of profit, loss of time, the cost of repair-
ing or replacing other property which is damaged, or any other incidental
damage of any kind.
Angular Bun Feeder
shown not used
on all units.
Table of Contents

HEBT-5V BUN TOASTER
2P/N 1011112 Rev W 05/22
McDonald’s
Fill in the information below and have it handy when calling
Antunes Technical Service for assistance. The serial number
is on the specication plate located on the rear of the unit.
Purchased From:
Date of Purchase:
Model No.:
Serial No.:
Mfg. No.:
Network ID Number:
Use only genuine Antunes replacement parts in this unit. Use
of replacement parts other than those supplied by the manu-
facturer will void the warranty.
IMPORTANT! Keep these instructions for future reference. If the unit
changes ownership, be sure this manual accompanies the equipment.
General
This manual provides the safety, installation, and
operating procedures for this unit. Please read this manual
prior to installing and operating the unit.
This unit is manufactured from the finest materials avail-
able and assembled to our strict quality standards. This
unit has been tested at the factory to ensure depend-
able trouble-free operation.
Service/Technical Assistance
If you experience any problems with the installation or opera-
tion of your unit, contact Antunes Technical Service at +1-877-
392-7854 (toll free).
Warranty Information
Please read the full text of the Limited Warranty in this manual.
If the unit arrives damaged, contact the carrier immediately
and le a damage claim with them. Save all packing materials
when ling a claim. Freight damage claims are the responsi-
bility of the purchaser and are not covered under warranty.
The warranty does NOT extend to:
yDamages caused in shipment or damage
as result of improper use.
yInstallation of electrical service.
yNormal maintenance as outlined in this manual.
yMalfunction resulting from improper maintenance.
yDamage caused by abuse or careless handling.
yDamage from moisture into electrical components.
yDamage from tampering with, removal of, or
changing any preset control or safety device.
Owner Information

HEBT-5V BUN TOASTER
3
P/N 1011112 Rev W 05/22
McDonald’s
Dimensions
Model &
Mfg. No Volt Watts Hz. Plug Description
Plug
Conguration
9210840
(International) 230 4600 50/60 IEC-309 Pin & Sleeve, 32 Amp., 230 Volt
9210841
(Australia) 220-240 4430-5250 50/60 Marechal 32 Amp., 220-250 Volt
9210842
(New Zealand) 220-240 4430-5250 50/60 Marechal 32 Amp., 220-250 Volt
9210843
(Taiwan) 230 4430-5250 50/60 L6-30P Twist-Lock 32 Amp., 220-250 Volt
9210844
(Europe -Club O󰀨) 220-240 4430-5250 50/60 IEC-309 Pin & Sleeve, 32 Amp., 230 Volt
9210845
(Japan) 208 4600 50/60
L6-30P 30 Amp.,
250 Volt,
Straight Twist Lock
9210846
(Domestic) 208 4800 50/60 Pin & Sleeve Plug 30 Amp., 250 VAC
R
9210847
(Europe - Club O󰀨) 230 3600 50/60 IEC-309 Pin & Sleeve 16 Amp., 220-250 Volt
9210848
(Europe - Club On) 230 3600 50/60 IEC-309 Pin & Sleeve 16 Amp., 220-250 Volt
9210849
(Korea) 230 4430-5250 50/60 IEC-309 Pin & Sleeve, 32 Amp., 230 Volt
Pass Through Time
For all HEBT-5V units the pass through time is
22 seconds (+/- 2 seconds).
35.37”
(898.4 mm)
32.61”
(828 mm)
24.62”
(625 mm)
15.55”
(394.9 mm)
Angular Bun Feeder
shown not used
on all units.
Specications
CAUTION
All electrical connections must be in accordance with
local electrical codes and any other applicable codes.
Electrical Specications & Plug Conguration

HEBT-5V BUN TOASTER
4P/N 1011112 Rev W 05/22
McDonald’s
In addition to the warnings and cautions in this manual, use
the following guidelines for safe operation of the unit.
yRead all instructions before using equipment.
yFor your safety, the equipment is furnished with
a properly grounded cord connector. Do NOT
attempt to defeat the grounded connector.
yInstall or locate the equipment only for its intended
use as described in this manual. Do NOT use
corrosive chemicals in and/or on this equipment.
yDo NOT operate this equipment if it has a
damaged cord or plug, if it is not working properly,
or if it has been damaged or dropped.
yThis equipment should be serviced by qualied
personnel only. Contact the nearest Authorized
Service Agency for adjustment or repair.
yDo NOT block or cover any openings on the unit.
yDo NOT immerse cord or plug in water.
yKeep cord away from heated surfaces.
yDo NOT allow cord to hang over
edge of table or counter.
yDo NOT clean this appliance with a water jet.
The following warnings and cautions appear throughout this
manual and should be carefully observed.
yTurn the unit o󰀨, wait for the cool-down
procedure to complete its cycle, and
disconnect the power cord before performing
any service or maintenance on the unit.
NOTE: Turning o󰀨 the power switch does NOT turn o󰀨 all
power to the unit. When the unit is plugged in and
turned o󰀨, an LED light ashes to indicate that the
power cord is plugged in.
yThe equipment should be grounded according
to local electrical codes to prevent the possibility
of electrical shock. It requires a grounded
receptacle with separate electrical lines, protected
by fuses or circuit breaker of the proper rating.
yBread may burn. Therefore toasters must not be used
near or below curtains or other combustible walls
and materials. Failure to maintain safe operating
distances may cause discoloration or combustion.
Important Safety Information WARNING
To avoid possible personal injury and/or damage to
the unit, all inspections, tests, and repair of electrical
equipment should be performed by QUALIFIED
SERVICE PERSONNEL. The unit MUST be completely
shut down and unplugged before any internal
servicing, except when electrical tests are required.
Use extreme care during electrical circuit tests. Live
circuits will be exposed.
CAUTION
All electrical connections must be in accordance with
local electrical codes and any other applicable codes.
CAUTION
Bread may burn. Therefore toasters must not be used
near or below curtains or other combustible walls and
materials. Failure to maintain safe operating distances
may cause discoloration or combustion.
CAUTION
NEVER unplug the power cord while the unit is
running! Use the proper shutdown procedure before
unplugging the power cord.
WARNING
ELECTRICAL SHOCK HAZARD.
FAILURE TO FOLLOW THE INSTRUCTIONS IN
THIS MANUAL COULD RESULT IN
SERIOUS INJURY OR DEATH.
yElectrical ground is required on this appliance.
yDo NOT modify the power supply cord plug.
If it does not t the outlet, have a proper
outlet installed by a qualied electrician.
yDo NOT use an extension cord with this appliance.
yThe toaster should be grounded according to
local electrical codes to prevent the possibility
of electrical shock. It requires a grounded
receptacle with separate electrical lines, protected
by fuses or circuit breaker of the proper rating.
yCheck with a qualied electrician if you are
unsure if the appliance is properly grounded.

HEBT-5V BUN TOASTER
5
P/N 1011112 Rev W 05/22
McDonald’s
Location
When placing the toaster into service, pay attention to the
following guidelines:
yMake sure power is off and the
toaster is at room temperature.
yDo NOT block or cover any openings on the unit.
yDo NOT immerse cord or plug in water.
yKeep cord away from heated surfaces.
yDo NOT allow cord to hang over
edge of table or counter.
1. Place the toaster in the required position
designated by McDonald’s.
2. Attach the Bun Feeder, Angular Bun Feeder (if
present), Bun Buffer Frame, and Crown\Heel
Separator accessories (Figure 1).
NOTE: Be sure to attach the Bun Feeder so the tabs are
seated properly. Failure to attach the Bun Feeder
properly could cause serious damage to the
toaster.
3. Plug the power cord into an appropriate power
outlet. Refer to the specification plate for the proper
voltage.
NOTE: See “Angular Bun Feeder (Some Models” in the
Operations section of this manual for information
on using the supplementary Angular Bun Feeder
(some models).
Unpacking
1. Open the large box. It contains:
yHEBT-5V toaster
yAccessories box
2. Remove the accessories box from the large box.
3. With the help of another person, carefully remove the
HEBT-5V from the large box.
4. Remove all protective coverings from the unit.
5. Open the Accessories Box. It contains:
yOwner’s Manual
yAngular Bun Feeder (some models)
yBun Bu󰀨er Frame
yClub/Heel Separator
6. Wipe the entire exterior of the toaster and the
accessories mentioned above with a clean towel sprayed
with a McDonald’s approved sanitizer. Allow to air dry.
NOTE: Handle accessories with care. If an accessory
becomes bent or damaged, it may not attach
to the unit correctly, which may a󰀨ect normal
operation.
NOTE: If any parts are missing or damaged, contact
Antunes Customer Service IMMEDIATELY at +1-
877-392-7856 (toll free).
Figure 1. HEBT-5V Components
(Belts not Shown)
Bun Feeder
Angular
Bun Feeder
Some Models)
Bun Buffer
Frame
Club/Heel
Separator
Rear
Conveyor
Cover
Control
Panel
Front
Conveyor
Cover
Compression
Knob
Installation