Aquasana AQ-7000 User manual

aq7000install_20120302
Installation Instructions
Inline Refrigerator & Fountain Filtration System
AQ-7000
Don’t Forget
• Notethedateandreplaceyourltercartridgesevery6months.
• Yoursatisfactionisguaranteed.Thisltercomeswitha6-monthwarranty,and
ifforanyreasonyouarenotsatisedwithyourpurchase,simplycallusat866-
662-6885forafullrefunduponreturn.
ThankyouforchoosingAquasana!
Aquasana, Inc. •www.aquasana.com
6310MidwayRoad•HaltomCity,Texas76117
888.516.9752

1.Turnowatersupplytorefrigerator
2.Locateaneasilyaccessiblesectionofrefrigeratorwatersupplytubingorsupplylineto
refrigeratorfromunder-sink.
3. Ifinstallingonthebackofarefrigerator;cutandremovea
11.5”sectionofrefrigeratorwatersupplytubing.
•Useatubecutterforcoppertubingandautilityknifeforplastic
tubing.Makesureendsaresquare.
4.Referringto“UsingPush-InFittings”sectionbelow,insertrefrigeratorwatersupplytubinginto
inletpush-inttingonlter.
5. Turnontheincomingwatersupplyandushthelterintoa
bucket.Runwaterfor2-3minutes.Theinitialsurgeofwatermaybe
discoloredduetocarbonnes.
6. Shutowatersupplyagain.Referringto“UsingPush-InFittings”
section,insertwatersupplytubefromrefrigeratorintooutlettting.
7. Useplasticstraptosecureltertobackofrefrigeratororundersink.
8. Turnonwatersupplytorefrigeratorandcheckforleaks.
Filter Replacement
1. Turnowatersupplytorefrigerator.
2. Referringtosection“UsingPush-InFitting”,releasetubingfrombothendsoflter.
3. Referringto“UsingPush-InFittings”section,insertrefrigeratorwatersupplytubingintoinlet
push-inttingonlter.
4.Turnontheincomingwatersupplyandushthelterintoabucket.Runwaterfor2-3minutes
toushoutair.
5. Shutowatersupplyagain.Referringto“UsingPush-InFittings”section,insertwatersupply
tubefromrefrigeratorintooutlettting.
6.Turnonwatersupplytorefrigeratorandcheckforleaks.
Troubleshooting
IfwaterleaksatPush-inConnections:Pushtubinginasfarasitwillgo.Ifleakingcontinues,shut
owaterattheoriginalvalveandremovewaterlinebypushinginontheconnectorcollarwhile
pullingthetubingaway.See,“Using Push-In Fittings”section.Inspecttubingforcracksand
scratches.Iftubingiscrackedorscratched,simplycutthatportionawayandreinsertnewendof
tubingintotting.Makesuretubingiscutstraight.Ifnot,re-cut.
Do not use with water that is microbiologically unsafe or of unknown
quality without adequate disinfection before or after the system.
COLLET
BACKSTOP
Using Push-In Fittings
To Release Tubing
Push in grey collet to release tubing.
With collet held, pull tubing straight out.
To Attach Tubing
Push tubing in as far as it will go. Tubing must
be inserted past o-ring and hit backstop. Pull
tube to ensure it is secured.
Filter Installation
Parts and Material Included
 •FilterCartridge
 •Adjustableplasticstrap
 •Installationinstructions
Tools & Parts Needed
 •TubeCutterorUtilityKnife
 •Bucketforushinglter
Install in a location that is
not susceptible to freezing
temperatures.
Install away from direct sunlight
as prolonged exposure to light
can weaken plastic components.
A water supply line must be run
to the refrigerator or fountain
prior to installation of this filter.
Correct
Incorrect
FLOW