ARJO HUNTLEIGH MAXI LITE User manual

MAXI LITE
Instruction for Use
001.23104.EN rev. 6 • March 2014

Design Policy and Copyright
® and ™ are trademarks belonging to the ArjoHuntleigh group of companies.
© ArjoHuntleigh 2013.
As our policy is one of continuous improvement, we reserve the right to modify designs without
prior notice. The content of this publication may not be copied either whole or in part without the
consent of ArjoHuntleigh.
Table of Contents

001.23104.EN rev. 6
Table of Contents iii
Table of Contents
Foreword ......................................................................................................................................1
Please Read this Manual Thoroughly!..................................................................................................... 1
Service and Support ................................................................................................................................ 1
Manufacturer Information......................................................................................................................... 1
Denitions Used in this Manual ............................................................................................................... 1
Safety Instructions ......................................................................................................................2
Intended Use ........................................................................................................................................... 2
Operational Life ....................................................................................................................................... 2
Important Safety Instructions................................................................................................................... 2
Policy on Number of Staff Members Required for Patient Transfer......................................................... 3
Safe Working Load (SWL)....................................................................................................................... 3
Battery and Battery Charger Safety Practices......................................................................................... 4
Shock Prevention..................................................................................................................................... 4
Fire and Explosion Prevention................................................................................................................. 4
Human and Environmental Safety Practices ........................................................................................... 4
Homecare Environment Considerations................................................................................................................ 4
Symbols Used..............................................................................................................................5
General Symbols ..................................................................................................................................... 5
Charger Related ...................................................................................................................................... 5
Product Description ....................................................................................................................6
Preparation / Transport ................................................................................................................7
Initial Setting ............................................................................................................................................ 7
Transporting the Lift................................................................................................................................. 7
Unfolding the Lift...................................................................................................................................... 7
Folding the Lift ......................................................................................................................................... 7
How to use the MAXI LITE ..........................................................................................................9
Adjusting Legs Spreading........................................................................................................................ 9
Brakes...................................................................................................................................................... 9
Emergency Stop ...................................................................................................................................... 9
Boom Control........................................................................................................................................... 9
To Raise the Patient .............................................................................................................................................. 9
To Lower the Patient.............................................................................................................................................. 9
Moving the MAXI LITE ........................................................................................................................... 10
Emergency Lowering............................................................................................................................. 10
Automatic Cut-out.................................................................................................................................. 10
During lifting ........................................................................................................................................................ 10
During lowering ................................................................................................................................................... 10
Hour Meter............................................................................................................................................. 10
Battery Charge Indicator.........................................................................................................................11
Battery Charging ........................................................................................................................12
Inserting / Removing the Battery Pack.................................................................................................... 12
Clip Slings Application .............................................................................................................13
Clip Sling Compatibility.......................................................................................................................... 13
Sling Selection....................................................................................................................................... 14
Spreader Bar Compatibility.................................................................................................................... 14
Attachment points.................................................................................................................................. 14
Attaching / Detaching the DPS Spreader Bar ......................................................................................... 15
Attaching the Sling to the DPS .............................................................................................................. 15
Detaching the Sling from the DPS......................................................................................................... 15
Operating the DPS................................................................................................................................. 15
Transferring Patients Using Clip Slings ................................................................................................. 15
Lifting Patient from a Seated Position ................................................................................................................. 16
Lowering Patient to a Seated Position ................................................................................................................ 16
Lifting Patient from a Bed .................................................................................................................................... 17
Lowering Patient to a Bed ................................................................................................................................... 18

001.23104.EN rev. 6
Table of Contentsiv
Lifting Patient from the Floor ............................................................................................................................... 18
Lowering Patient to the Floor .............................................................................................................................. 19
Loop Slings Application ...........................................................................................................20
Compatible Loop Slings......................................................................................................................... 20
Sling Selection....................................................................................................................................... 21
Spreader Bar Compatibility.................................................................................................................... 21
Attaching the Sling to the Spreader Bar ................................................................................................ 21
Positioning the Patient ........................................................................................................................................ 21
Attachment Methods ........................................................................................................................................... 22
Transferring Patients Using Loop Slings ............................................................................................... 22
Lifting Patient from a Seated Position ................................................................................................................. 22
Lowering Patient to a Seated Position ................................................................................................................ 23
Lifting Patient from a Bed .................................................................................................................................... 24
Lowering Patient to a Bed ................................................................................................................................... 25
Lifting Patient from the Floor ............................................................................................................................... 26
Lowering Patient to the Floor .............................................................................................................................. 27
Care and Maintenance ..............................................................................................................28
Lift Cleaning and Care........................................................................................................................... 28
Preventive Maintenance Schedule...........................................................................................29
Troubleshooting ........................................................................................................................30
Labels on the Lift.......................................................................................................................31
Technical Specications...........................................................................................................32
Dimensions..............................................................................................................................................................
Electromagnetic Compatibility.....................................................................................................
Electromagnetic Compliance.....................................................................................................................
Electromagnetic Emissions........................................................................................................................
Electromagnetic Immunity .........................................................................................................................

001.23104.EN rev. 6
Foreword 1
Please Read this Manual Thoroughly!
The information in this manual is crucial to the
proper use and maintenance of the MAXI LITE
oor lift. It will help protect your product as well
as ensure that it performs to your satisfaction.
Lifting and transferring a person always
presents a potential risk. This manual contains
safety related information that must be read
and understood to help prevent injuries.
ArjoHuntleigh strongly advises and warns that
to avoid injuries that can be attributed to the
use of inadequate parts, only parts designated
by ArjoHuntleigh should be used on product
and other appliances supplied by ArjoHuntleigh.
Unauthorized modications on any
ArjoHuntleigh product may affect its safety.
ArjoHuntleigh will not be held responsible for
any accidents, incidents or lack of performance
that occur as a result of any unauthorized
modication to its products.
Service and Support
A service routine has to be done on your
MAXI LITE oor lift by ArjoHuntleigh trained
service personnel. This will ensure it remains
safe and functional.
Please contact your local ArjoHuntleigh vendor
for any of the following:
• If you require further information.
• Want to report an unexpected event,
change in the performance or a
malfunction.
• Need any help in setting up, using or
maintaining your MAXI LITE.
• Need replacement parts.
Your ArjoHuntleigh vendor can offer support
and service programs to maximize the long-
term safety, reliability and value of the product.
Manufacturer Information
This product was manufactured by:
ArjoHuntleigh AB
Hans Michelsensgatan 10
211 20 Malmö
SWEDEN
Denitions Used in this Manual
WARNING:
Means: Failure to understand and follow this
instruction may result in injury to yourself and
others.
CAUTION:
Means: Failure to follow this instruction may
cause damage to the product(s).
NOTE:
Means: Important information regarding correct
use of the product.
Foreword

001.23104.EN rev. 6
Safety Instructions2
The MAXI LITE oor lift must always be handled
by a trained caregiver, as per instructions
herein, who shall attend to the patient during lift
operation.
Intended Use
The MAXI LITE oor lift has been designed to
assist caregivers in homecare environments,
hospitals, nursing homes or other assisted
living centres. It is intended for lifting patients
with reduced mobility for the following purposes:
• Transferring to or from adjacent
location, such as chair, wheelchair, bed,
bath, toilet, oor or stretcher.
• Assisting patient with tasks such as,
toileting.
• Transferring to or from an automobile
located on a level and hard surface
such as a driveway, street, sidewalk or
garage.
WARNING: This product is not intended to
be operated by the patient.
Patient could get stuck in many
circumstances.
WARNING: The MAXI LITE oor lift must be
solely used for the purposes stated above.
Do not use the lift for any other purpose, it
could compromise product’s reliability
and / or patient’s safety.
Operational Life
The MAXI LITE oor lift has been designed and
tested to achieve up to 10 000 cycles with a
load of 160 kg / 350 lb.
It is subject to maintenance as specied in the
“Care and Maintenance” section in this manual.
The following table shows number of years in
relation to cycles per day. One cycle is dened
as transferring a 160 kg / 350 lb patient including
a raising action, a lateral displacement and a
descending action.
Cycles per Day Years
(10,000 transfers)
4 7
6 4.5
8 3.5
WARNING: Using a oor lift or an accessory
beyond its life span may result in an incident
causing serious injuries.
The life span is the safe operating time period
before a complete overhaul is required.
Following are factors that have an impact on
the lift’s life span:
• aging of the unit;
• transfers per day;
• weight of the patient;
• maintenance frequency.
The expected life for other consumable items,
such as batteries, fuses, slings, straps and
cords is dependent upon the care and usage of
the product. Consumable must be maintained
in accordance with published Instructions for
Use and “Preventive Maintenance Schedule”.
Important Safety Instructions
• Before using the MAXI LITE, a clinical
assessment of the patient’s suitability for
transfer must be carried out by a
qualied health professional considering
that, among other things, the transfer
may induce substantial pressure on the
patient’s body.
• Keep this manual at proximity from the
lift and refer to it as required. Make sure
that all users are regularly trained in the
use of the MAXI LITE oor lift as per the
information found therein.
• All controls and safety features are used
only as per the rules specied in this
manual. Never attempt to force a control
or button on the lift.
•
WARNING: Do not put ngers, hands or feet
where space is limited (see “Fig. 1”). This
could pinch, cut, or seriously harm body parts.
• Avoid any impact during transfer.
Safety Instructions

001.23104.EN rev. 6
Safety Instructions 3
Fig. 1
1) Around the boom pivot.
2) Around the spreader bar attachment.
3) Between the castors and the base assembly.
4) Between the base assembly and the oor.
5) Between the actuator and mast.
6) Between the mast and the base.
7) Around the legs pivot.
8) Around the leg opening mechanism.
1
2
3
4
5
7
8
6
WARNING: ArjoHuntleigh warns of possible
strangulation risks related to the hand control
cable.
WARNING: Some plastic parts hiding screw
heads on the lift may represent a choking
hazard for young children. Make sure to
replace them if they become loose or
damaged.
CAUTION: Do not drop either the lift or the
battery pack, as it may cause internal
damage that is not easily seen. If the lift is
suspected to be damaged, contact your local
ArjoHuntleigh vendor for servicing.
CAUTION: Using the MAXI LITE in humid,
salty, or chlorinated conditions may cause
premature wear of the lift.
In such cases, weArjoHuntleigh recommend
to perform a proactive maintenance program
with more frequent inspections.
Policy on Number of Staff Members
Required for Patient Transfer
ArjoHuntleigh’s oor lifts are designed for safe
usage with one caregiver. There are
circumstances that may dictate the need for a
two-person transfer. It is the responsibility of
the caregiver to determine if a one or two person
transfer is more appropriate, based on the
following:
• resident’s condition (combativeness;
obesity, contracture etc.);
• the task;
• resident’s weight;
• environment;
• capability;
• skill level of the caregiver.
Do not hesitate to contact your medical
professional for guidance.
Safe Working Load (SWL)
The MAXI LITE oor lift has been made for a
maximum lifting capacity of 160 kg (350 lb).
Do not attempt to lift more than the lowest
weight limit indicated on the following:
• the “maximum load” label on the lift;
• on the spreader bar;
• on the accessories;
• on the sling.

001.23104.EN rev. 6
Safety Instructions4
Battery and Battery Charger Safety
Practices
WARNING: Following the instructions is
important for the safe use of the battery and
to keep the user (resident/caregiver) from
harm.
Make sure the battery belongs to the device by
comparing the battery label with the “Technical
Specications” section on page 27. If battery
type cannot be conrmed, call your vendor for
assistance.
CAUTION: Do not expose the battery
connectors or the battery charger to water.
Humid air or water can cause premature
wear to the battery or the charger.
• Only use the charger that has been
supplied with the equipment.
• Do not charge the batteries in an
unventilated area.
• The charger must not be covered or
exposed to dust.
• Do not crush, puncture, open, dismantle
or otherwise mechanically interfere with
the batteries.
• Do not store the battery at a
temperature higher than 40 ºC (104 ºF).
• Stop using the battery if any damage or
deformation is noted.
Shock Prevention
• Electrically live equipment can result in
serious injuries. If the lift or charger has
any exposed or damaged wires, contact
your local ArjoHuntleigh vendor
immediately.
• Do not attempt to expose, service or
repair the lift, battery or charger. If any
unit is malfunctioning, contact your local
ArjoHuntleigh vendor.
Fire and Explosion Prevention
• Do not place or store the battery under
direct sunlight or near a heat source.
• Do not expose the batteries or battery
charger to ames.
• Do not use the charger in the presence
of ammable anaesthetic gases.
• Do not short circuit the battery terminals.
Human and Environmental Safety
Practices
• Should the battery casing crack,
allowing its contents to come into
contact with skin or clothing, rinse
immediately with water. If the contents
comes in contact with the eyes, rinse
immediately with plenty of water and
seek medical attention.
• Inhalation of the contents can cause
respiratory irritation. Seek out fresh air
and medical attention.
• For recycling and disposal of the
batteries, the rules according to the
WEEE directive (Waste of Electronic
and Electrical Equipment) as well as
local laws and regulations must be
followed. When returning batteries,
insulate their terminals with adhesive
tape. Otherwise, the residual electricity
in used batteries may cause re or
explosion.
In case of doubt about the way to proceed,
please contact your local authorities to
determine the proper method of disposal.
Homecare Environment Considerations
WARNING: The MAXI LITE is not intended
to be operated by children. Serious injuries
could occur.
NOTE: Cleaning actions should be done
rigorously when the MAXI LITE is exposed to
an animal.
Pet hair trapped around mobile parts can
affect lift’s performance.

001.23104.EN rev. 6
Symbols Used 5
Symbols Used
General Symbols
This symbol points out the
manufacturer’s name and
address. May also point
out manufacturing date.
This symbol means that
the product complies
with the medical device
directive 93 / 42 / EEC.
ISO 15223 3.15
This symbol points out
the manufacturer’s
catalogue number.
ISO 15223 3.16
This symbol points out the
manufacturer’s serial number.
“Separate collection” for all
batteries and accumulators
as per the WEEE Directive.
This symbol means that
the item can be recycled.
1641
This symbol means that
you must refer to the
Instructions for Use (IFU).
This symbol points out a
Type BF applied part.
This symbols points out
a risk of pinching.
SWL SWL is the maximum load the
device is rated for safe usage.
This symbol points out the
emergency stop device.
This symbol points out
the reset switch.
Correct.
Incorrect.
Charger Related
Class II electrical equipment.
This term refers to electrical
equipment in which
protection against electric
shock does not rely on
basic insulation only.
When applicable, symbol reference can be
found in EN 60601-1 and WEEE Directive.
Acronyms
DPS Dynamic Positioning System

001.23104.EN rev. 6
Product Description6
Product Description
Fig. 2
1
1
2
3
4
4
6
5
27
26
25
22
24
19
20
21
17
18
87
12
16
14
13
11
10
9
23
15
Legend
1) Down Button
2) Reset Button
3) Emergency Stop Button
4) Up Button
5) Hand Control
6) Boom
7) Actuator
8) Handle
9) Battery Release Button
10) 2-Point Spreader Bar
11) Safety Latch
12) Flat DPS Spreader Bar
13) Charger Status LED
14) Wall-Mounted Charger
15) Charger Power Cord
16) Right Leg
17) Left Leg
18) Emergency Lowering Handle
19) Mast
20) Mast Locking Screw
21) Leg Opening / Closing Pedal
22) Battery Pack
23) Castor Break
24) Control Box
25) Hand Control Connector
26) Battery Status Display
27) Hour Meter

001.23104.EN rev. 6
Preparation / Transport 7
Initial Setting
The MAXI LITE oor lift does not require any
initial setting except for the battery pack which
must be charged for at least 8 hours prior rst
usage.
Transporting the Lift
WARNING: To prevent back injuries, never
attempt to lift, transport, fold or unfold the lift
without being assisted.
The MAXILITE oor lift can be folded to t
inside the trunk of most domestic vehicle for
transport.
See “Unfolding the Lift” and “Folding the Lift”
sections for details.
Unfolding the Lift
1) Lock both rear casters.
Fig. 3
2) Remove the mast locking screw.
Fig. 4
3) Unfold the lift until it is straightened out.
NOTE: Make sure the mast pivot remains on
top of the groove when unfolding the mast.
Otherwise the pivot might slide down the
groove and block, see “Fig. 5”.
Fig. 5
4) Insert the locking screw back to block the
mast, and then tighten the knobs.
Fig. 6
Folding the Lift
1) Lock both rear castors of the lift.
2) Remove the DPS (if equipped), see
“Attaching / Detaching the DPS Spreader
Bar” on page 12.
3) Lower the boom to its lowest position.
4) Remove the battery pack.
5) Remove the shoulder knob and the turning
knob from the mast.
Fig. 7
6) Pull the mast up and lean it forward to bring
the pivot bolt in the upper section of the
groove.
7) Fold the lift until the boom touches the oor.
8) Insert the shoulder knob back in the proper
place to lock the mast.
Fig. 8
Preparation / Transport

001.23104.EN rev. 6
How to use the MAXI LITE8
Adjusting Legs Spreading
The base of the lift can be set with the legs
opened or closed. Adjustments are made by
changing the position of the pedal. Pressing
down the left side of the pedal will close the
legs. Pressing down the right side of the pedal
will open the legs. There is no locking device to
allow a mid-run adjustment. The legs must be
either fully opened or closed.
Fig. 9
OPEN
CLOSE
Brakes
Foot operated brakes are tted on both rear
castors.
To apply brakes, step on the back portion of
pad.
To release brakes, push the top portion of the
pad forward.
Fig. 10
UnlockedLocked
Emergency Stop
The operator can shut off the power at any time
by pressing the red emergency button on the
control panel or by pressing the red button on
the battery while pulling it backward to remove
it.
Reset the emergency stop function by pressing
on the green power button or by replacing the
battery.
First-time users should practice the emergency
stop manoeuvre before operating the lift with a
patient in it.
Fig. 11
Emergency
Stop
Button
Battery
release
button Pull
Boom Control
The electrical actuator can be operated in both
directions. It allows the operator to raise or
lower the patient without any physical effort.
The boom raising / lowering action is controlled
by the “Up” / “Down” buttons located on the
control box and on the hand control.
If two buttons are pressed simultaneously, the
rst function button pressed overrides the other
function until it is released.
Fig. 12
UP
DOWN
To Raise the Patient
WARNING: Always make sure that the
spreader bar is above the patient before
lifting.
Failure to follow this instruction may cause
the patient to swing resulting in injury.
The “UP” buttons are used to raise the boom.
The boom keeps rising as long as the button is
pressed or until it reaches its upper travel limit.
To Lower the Patient
The “Down” buttons are used to lower the boom.
The boom keeps lowering as long as the button
is pressed or until it reaches its lower travel
limit.
How to use the MAXI LITE

001.23104.EN rev. 6
How to use the MAXI LITE 9
Moving the MAXI LITE
Always use the handles to manoeuvre the lift.
Close the legs and move the lift in the direction
of travel as shown in the gure below.
If necessary, initiate the movement by pushing
on the back of the base with your foot. Do not
push on the legs.
WARNING: Never attempt to manoeuvre
the lift by pulling on the mast, boom, actuator
or patient. Doing so could cause incidents
resulting in injuries.
Fig. 13
Never attempt to push or pull a loaded lift over
a oor obstruction which the castors are unable
to ride over easily, including steps, door
thresholds or moving sidewalk.
Do not push the lift at a speed which exceeds a
slow walking pace (3 km/hour or 0.8 meter/
second).
Emergency Lowering
This feature allows the boom to be lowered in
the event of a main control failure.
In the event of a hand control or control box
failure, locate the red handle above the actuator.
Gradually pull the handle up and hold it until the
actuator is lowered to the desired level. The
force exerted on the handle and the patient
weight affects the speed of descent.
Fig. 14
WARNING: Before operating the “emergency
lowering”, always ensure that a suitable
support is underneath, ready to receive, the
patient.
The handle is spring loaded and will return to
normal position and stop the lowering process
when released. Note that a load must be applied
to the boom for the device to function.
CAUTION: This function should only be used
in the event of control failure, and not as a
regular lowering function for the equipment.
Automatic Cut-out
During lifting
This feature will stop the lifting motion in the
event where the MAXI LITE is trying to raise a
patient heavier than the SWL.
During lowering
This feature disables the down motion when
the boom is being lowered onto the patient or
any other obstruction.
Sleep Mode
The control box includes an automatic switch-
off control that disables part of the circuitry, after
2 minutes of inactivity, to prevent battery from
draining.
Power is re-established when a control button
is pressed.
Hour Meter
HRS
Fig. 15
The hour meter is
an LCD display
which shows the
total duration of
powered operation
(in hours).
This is primarily
intended as an aid
for scheduling maintenances.

001.23104.EN rev. 6
How to use the MAXI LITE10
Battery Charge Indicator
HRS
Normal
operating
Low
battery
Critical
Fig. 16
The battery charge
indicator is a bar
graph display,
located on the
battery pack holder,
which shows the
charge condition of
the battery.
The lift is equipped
with an audible warning device, which will
beep when the battery level reaches the critical
range.
CAUTION: When the indicator reaches the
critical range, recharge the battery
immediately to prevent reducing its lifespan.
When a fully charged battery is inserted into the
lift, the display will return to the green fully
charged position, regardless of the level the
indicator had reached previously. However, if a
partially charged battery is inserted, the
previous indicator level will be maintained, even
though the recently inserted battery may be in a
better state of charge than indicated. To achieve
a true indication of battery condition, a fully
charged battery must be inserted into the lift.
Battery Information
For safe handling and to extend the battery
lifetime, please follow and remember these
instructions.
The MAXI LITE uses a 24 volts sealed lead-
acid battery pack that can deliver up to 100 lifts
per charge.
Battery life is variable (2-3 years) and is
inuenced by: frequency of use, frequency of
charging, temperature of operation / storage
and storage time.
To prolong the battery pack life, recharge it
before the indicator reaches the Low Battery
range.
To ensure that the MAXI LITE is always ready
for use, it is recommended that a fully charged
battery pack always be available. Do this by
having additional battery packs, and keeping
one battery pack charging while the other is in
use.
Remove the battery pack from the lift when
storing for an extended period of time. Stored
batteries should be recharged at least every
two weeks to maximize their life span.
Battery Charging
The battery should be recharged as soon as
the discharge indicator displays amber.
Refer to Battery Charger IFU for charging
details.
Note that the battery pack may remain
connected to the charger when fully charged.
Inserting / Removing the Battery Pack
The same method applies for inserting / removing
the battery pack into / from the lift or the charger.
Inserting the Battery Pack
1) Align the bottom of the battery pack with the
bottom of the battery support.
2) Insert the battery pack until it rests into the
support base.
3) Push the top of the battery until it latches to
the support.
Fig. 17
1 2 3
Removing the Battery Pack
1) Push the release button.
2) Pull the battery back.
3) Lift the battery to pull it out of the battery
rack.

001.23104.EN rev. 6
Clip Slings Application 11
Clip Sling Compatibility
This section only applies for model supplied with the at DPS spreader bar.
Following is a list of typical ArjoHuntleigh clip slings that are compatible with the MAXI LITE
oor lift.
MAA2090-XX
Four-Point Amputee
MAA4031-XX
Four-Point Hygienic
MAA4000-XX
Four-Pointed Padded
MAA-2000-XX
Four Point Nonpadded
MAA4060-XX
Four-Pointed Mesh
NOTE: Other sling models are available. Contact your ArjoHuntleigh vendor for more information
about clip slings and how to use them.
Clip Slings Application

001.23104.EN rev. 6
Clip Slings Application12
Sling Selection
The spreader bar that is attached to the lift
determines what slings can be used to transfer
a patient.
Slings are colour coded for size by having a
different colour edge binding or attachment
strap colouring:
• Teal - Extra Extra Small - XXS
• Brown - Extra Small - XS
• Red - Small - S
• Yellow - Medium - M
• Green - Large - L
• Purple - Large Large - LL
• Blue - Extra Large - XL
• Terracotta - Extra Extra Large - XXL
Note that some sling models are not available
in all sizes.
A wide variety of slings are available for each
application. Please contact your local
ArjoHuntleigh vendor for more information.
Flites® (single patient multi- use slings) are also
available for most sling models. If ArjoHuntleigh
Flites slings are to be used with the MAXI LITE
oor lift, refer to the separate ArjoHuntleigh
Flites slings Instruction for Use.
Spreader Bar Compatibility
The MAXI LITE oor lift is only compatible with
the spreader bar that is delivered with the lift.
Fig. 18
MAXI LITE oor lift
model that is
designed for use with
clip slings is delivered
with a manual Flat
DPS spreader bar.
WARNING: Using the at DPS with amputee
sling may cause injuries if not used correctly.
Attachment points
Fig. 19
Shoulders
Legs
Attaching / Detaching the DPS Spreader Bar
Attaching the DPS
Fig. 20
1) Align the DPS tube onto the lift’s attachment.
2) Insert the pin through the attachment.
3) Turn the locking spring to secure the
attachment.
WARNING: Make sure that the locking
spring is correctly engaged. Failure to
do so could result in patient fall.
Detaching the DPS
Fig. 21
1) Release the lock spring taking care not to
pull the pin out of the tube.
WARNING: Pulling the pin without
holding the DPS would drop the DPS
which could cause injuries.
2) Hold the DPS from the bottom and pull the
pin out.
3) Pull the DPS out of the lift’s attachment.

001.23104.EN rev. 6
Clip Slings Application 13
Attaching the Sling to the DPS
Fig. 22
1
2
Insert the clip attachment over the lug on the DPS.
Secure the clip in place by pulling the sling down so
that the lug is in the top portion of the clip hole.
WARNING: Make sure all clips are correctly
engaged. Failure to do so could result in patient
fall.
Method 1 - Straight Attachment
Fig. 23
Apply the leg clips of
the sling onto the lugs
so that they become
positioned vertically.
For most patients, the straight attachment of the leg
clips is recommended.
Method 2 - Crossed Legs Attachment
Fig. 24
Cross the legs pieces
of the sling when
attaching to the lugs.
If the patient is prone to kicking off the leg clip, the
crossed attachment of the leg clips shall be applied,
which will prohibit the clip from being kicked off.
Detaching the Sling from the DPS
1
2
Fig. 25
Pull the sling up to release the lock.
Remove the clip attachment from the lug on the
DPS.
Operating the DPS
Fig. 26
Note: To ensure maximum patient comfort, do
not allow them to hold onto the spreader bar.
The DPS spreader bar is adjusted by rising or
lowering the tilt handle until the patient is in the
desired position.

001.23104.EN rev. 6
Clip Slings Application14
Transferring Patients Using Clip
Slings
Before using the MAXI LITE ensure that:
• A clinical assessment of the patient’s
suitability for transfer is carried out by a
qualied health professional considering
that, among other things, the transfer
may induce substantial pressure on the
patient’s body.
• Special consideration is taken when
transferring a patient who is connected
to electrodes, catheters, or other
medical devices.
• Always carry out the items marked as
“Before every use” in the “Preventive
Maintenance Schedule” before using
the lift.
WARNING: Always hold the spreader bar
when near a patient. The spreader bar could
hit the patient resulting in injury.
WARNING: To avoid injury or discomfort, do
not lower the spreader bar onto the patient.
WARNING: Before raising the patient,
always make sure the sling is not caught on
any obstructions (for instance, the wheelchair
brakes or armrests). Sling catching in such
obstructions could result in patient fall.
WARNING: Always conrm that the sling
clips remain attached as the weight of the
patient is gradually taken up. A wrongly
clipped attachment could detach resulting in
patient fall.
Lifting Patient from a Seated Position
1) Place the sling around the patient so that
the base of the sling sits slightly below the
tail bone.
A MaxiSlide® or MaxiTube® positioning aid
can be used to assist with placement of the
sling.
Fig. 27
2) Ensure that the head support area of the
sling is behind the head covering it.
3) Pull each leg strap under the thigh so that it
emerges on the inside of the thigh.
Fig. 28
4) Approach the patient with the lift, ensure
that:
• The spreader bar is in sitting position.
• The wide part of the spreader bar is at
or just below shoulder level.
• The spreader bar is close enough to be
able to connect the shoulder strap clips
of the sling to the frame.
5) Connect the shoulder strap clips, then tilt
the frame and attach the leg sections. If
necessary, lower the spreader bar a little
further, being careful not to lower it onto the
patient.
Fig. 29
6) Raise the patient using the hand control,
positioning him comfortably to a semi-
reclined position for the transfer. The patient
should not be lifted above the caregiver’s
eye level.
7) Turn the patient to face the caregiver, and
keep at a normal chair height.
8) Proceed with the transfer.
Lowering Patient to a Seated Position
1) Once the patient has arrived at destination,
reposition the patient according to the
destination position.
2) Lower the patient down onto the new
location by making small adjustments
during the descent.
3) When the patient’s body weight is fully
supported, detach the connections clips.
4) Move the lift away from the patient.
5) Remove the sling from under the patient.

001.23104.EN rev. 6
Clip Slings Application 15
Lifting Patient from a Bed
Before you start, make sure the bed is in correct
working height.
WARNING: Make sure that the bed safety
side is installed to prevent the patient from
falling.
1) Roll the patient onto their side.
2) Fold the sling in half and place on the bed
land marking it, along the back of the patient
so that the base of his spine is aligned with
the base of the sling, making sure the sling
extends to the top of the patient’s head.
Fig. 30
3) Roll the patient back onto the sling and then
slightly further in the opposite direction, so
that the folded part of the sling can be
unfolded.
Fig. 31
4) If possible, slightly raise the head of the
bed.
5) Approach the patient with the lift, and ensure
that:
• the spreader bar is in reclined position;
• the spreader bar is close enough to be
able to connect the shoulder strap clips
of the sling to the frame.
6) Using the hand control, lower the spreader
bar taking care not to lower the frame onto
the patient.
7) Connect the sling shoulder and leg strap
clips to the spreader bar.
Fig. 32
8) Raise the patient using the hand control,
positioning him comfortably to a semi-
reclined position for the transfer. The patient
should not be lifted above the caregiver’s
eye-level.
9) Turn the patient to face the caregiver, and
keep at a normal chair height.
10) Proceed with the transfer.
Lowering Patient to a Bed
1) Once the patient has arrived at destination
reposition the patient according to the
destination position.
2) Lower the patient down onto the new
location by making small adjustments
during the descent so that the patient is
always in the best comfortable position.
3) When the patient’s body weight is fully
supported, detach the connections clips.
4) Move the lift away from the patient.
5) Remove the sling from under the patient.

001.23104.EN rev. 6
Clip Slings Application16
Lifting Patient from the Floor
The technique described here can be used for
transferring patients lying on the oor.
Patients being lifted from the oor due to a slip
or fall should only be lifted after examination by
qualied medical personnel. The patient can be
lifted from a completely reclined position on the
oor, but for his comfort, put a pillow under his
head rst.
1) Roll the patient onto their side.
2) Fold the sling in half and place on the oor
land marking it, along the back of the patient
so that the base of his spine is aligned with
the base of the sling, making sure the sling
extends to the top of the patient’s head.
Fig. 33
3) Roll the patient back onto the sling and then
slightly further in the opposite direction, so
that the folded part of the sling can be
unfolded.
Fig. 34
4) Depending on circumstances, space or
position of patient, approach the patient
with the open part of the chassis.
5) Adjustment of the spreader bar height may
have to be made before connection is
possible.
6) Attach the shoulder strap clips rst, then,
with the open part of the sling, support
frame pointing downwards towards the
shoulders, connect the leg strap clips.
Fig. 35
7) When all the clips are securely attached,
raise the patient from the oor in a semi-
recumbent position.
8) Once raised from the oor, ensure the
patient’s legs are clear of the chassis before
continuing to lift.
9) Turn the patient to face the caregiver, and
keep at a normal chair height.
10) Proceed with the transfer.
Lowering Patient to the Floor
1) Lower the patient down onto the new
location by making small adjustments
during the descent so that the patient is
always in the best comfortable position.
2) When the patient’s body weight is fully
supported, detach the connections clips.
3) Move the lift away from the patient.
4) Remove the sling from under the patient.
.
Loop Slings Application