Blodgett BLG-30E User manual

BLODGETT OVEN CO ▪44 lakeside Ave ▪Burlington, VT 05446
Tel. [phone] ▪Fax [phone] ▪www.blodgett.com
1 2007-06-26
PARTS LIST
ELECTRIC TILTING SKILLETS
MODELS: BLG-30E
BLG-40E

PARTS LIST, ELECTRIC TILTING SKILLETS, MODELS BLG-30E, BLG-40E
ITEM PART NO. DESCRIPTION BLG-
30
BLG-40
1 42572 Cover Assembly 1
42573 Cover Assembly 1
2 42909 Pour Lip Strainer 1 1
3 43312 Base Bracket 2 2
4 40452 Bronze Bearing 2 2
5 43311 Pan Tilt Bracket 2 2
6 43504 Lock Washer 4 4
7 43443 Socket Head Screw 4 4
8 42541 Component Mounting Panel 1 1
9 41004 High-Limit Thermostat 1 1
** 10 40892 Contactor, 208, 220, 240V 1 1
40943 Contactor, 220/380, 240/415, 480, 600V 1 1
11 40840 Ground Lug 1 1
12 40734 Terminal Block Section 4 4
40733 End Section 1 1
** 13 41859 Fuse, 1 Amp., 250V (208, 220, 240V) 2 2
41765 Fuse, 1/2A, 600V (380, 415, 480, 600V) 2 2
** 14 41844 Fuse Holder, (208, 220, 240V) 2 2
41769 Fuse Holder, (380 415, 480, 600V) 2 2
15 42574 Control Panel 1
42575 Control Panel 1
16 42560 Control Panel Decal 1
42561 Control Panel Decal 1
17 40820 Temperature Pilot - Red 1 1
18 41005 Operating Thermostat 1 1

PARTS LIST, ELECTRIC TILTING SKILLETS, MODELS BLG-30E, BLG-40E
** 19 40848 Dial (F) 1 1
40849 Dial (C) 1 1
* 40994 Bezel 1 1
20 43447 Set Screw, 1/4 - 20 x ½ 1 1
21 43212 Tilt Decal 1 1
22 43505 Screw, 10 - 32 x 3 1 1
23 42536 Tilt Handle Assembly 1 1
24 42535 Input Shaft 1 1
25 41131 Adjustable Foot 2 2
26 41474 Flanged Adjustable Foot 2 2
27 40127 Retaining Ring 1 1
28 42539 Special Flat Washer, 1/2" 1 1
29 43450 Oilite Bearing 2 2
30 42533 Upper Tilt Arm 1 1
31 42598 Liquid Tight Connector/Strain Relief 1 1
* 42599 Liquid Tight Locknut 1 1
32 42596 Tilt Switch 1 1
33 42534 Lower Tilt Arm 1 1
34 42597 Retaining Ring 2 2
35 42802 Key, 8 mm x 10 mm x 5.5" 1 1
36 41808 Hex Nut, 3/8 - 16 4 4
37 43506 Screw, 3/8 - 16 x 1-¼” 4 4
38 42587 Gear Box 1 1
39 42537 Output Shaft 1
39 42538 Output Shaft 1
40 43452 Key, 8 mm x 10 mm x 1" 1 1
41 41837 Set Screw, 3/8 - 16 x 1/2" 1 1
42 43453 Screw, 3/8 - 16 x 1-1/2" 1 1
43 43454 Right Hand Access Panel 1 1
44 43455 Screw 10 - 32 x 1 4 4

PARTS LIST, ELECTRIC TILTING SKILLETS, MODELS BLG-30E, BLG-40E
45 43456 Set Screw, 8 - 31 x 5/16" 1 1
46 43457 Yoke Pin 1 1
47 43458 Screw, 5/16 - 18 x 1 4 4
48 43460 Rear Panel 1
43461 Rear Panel 1
49 43424 Screw, 10 - 32 x ½" 4 4
50 41543 Lock Pin 2 2
51 41546 End Lock Plate 2 2
52 43106 Stationary Disc 2 2
53 41100 Core 2 2
54 41526 Spring 2 2
55 43107 Rotary Disc 2 2
56 41520 End Stop Plate 2 2
57 43463 Screw, 1/4 - 20 x 3/4" 8 8
58 43464 Hinge Support Assembly 2 2
59 43507 Right Hand Insulation Shield 1
43508 Right Hand Insulation Shield 1
60 43509 Left Hand Insulation Shield 1
43510 Left Hand Insulation Shield 1
61 43511 Screw, 1/4 - 20/ x 1" 8 8
62 43512 Flat Washer, 1/4" 8 8
63 43513 Hex Nut, 5/16-18 29 29
64 43514 Flat Washer, 5/16 29 29
65 43178 Element Clamp 9
40185 Element Clamp 9
** 66 41945 Element Assembly, 208V, 4 kW 3
41951 Element Assembly, 220/380V, 4 kW 3
41949 Element Assembly, 240/415V, 4 kW 3
41950 Element Assembly, 480 (287V), 4 kW 3
41952 Element Assembly, 600 (347V), 4 kW 3

PARTS LIST, ELECTRIC TILTING SKILLETS, MODELS BLG-30E, BLG-40E
42271 Element Assembly, 208V, 5 kW 3
42273 Element Assembly, 220/380V, 5 kW 3
42280 Element Assembly, 240/415V, 5 kW 3
42274 Element Assembly, 480 (277V), 5 kW 3
42279 Element Assembly, 600 (347V), 5 kW 3
42272 Element Assembly, 208V, 6 kW 3
42276 Element Assembly, 220/380V, 6 kW 3
42275 Element Assembly, 240/415V), 6 kW 3
42277 Element Assembly, 480 (247V), 6 kW 3
42278 Element Assembly, 600 (347V), 6 kW) 3
67 40428 Thermostat Bulb Closure 1 1
68 43467 Socked Head Screw, ½ - 13 x 1 2 2
69 43468 Lock Washer, ½" 2 2
* ** 70 40974 Transformer, 380/415V - 240V, 100 VA 1 1
40980 Transformer, 480 - 240V, 100 VA 1 1
* ** 70 40985 Transformer, 600 - 240V, 100 VA 1 1
ALTERNATE PARTS
Page Item Crown Blodgett
3 16 7276-1 42566

PARTS LIST, ELECTRIC TILTING SKILLETS, MODELS BLG-30E, BLG-40E
Page Item Crown Blodgett
7276-2 42567
4 19 4736-1 43029
21 5608-1 42838