Canon Satera LBP5610 User manual

Laser Beam Printer
User's Guide
User's Guide

1
Contents
Tu r ning the Printer ON/OFF (For 5910/5910F) . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Tu r ning the Printer ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Tu r ning the Printer OFF . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
When Not Using a Hard Disk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
When Using a Hard Disk (Only When a Hard Disk is Installed) . . . . . . . . . . . . . . . . . . . .6
Tu r ning the Printer ON/OFF (For LBP5610) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Tu r ning the Printer ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Tu r ning the Printer OFF . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Online and Offline (Only for LBP5910/5910F) . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Placing the Printer Online . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Placing the Printer Offline . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Paper Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Usable Paper. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Paper Size for LBP5910/5910F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Paper Type for LBP5910/5910F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Paper Size for LBP5610 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Paper Type for LBP5610 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Printable Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Unusable Paper. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Paper Capacity of Paper Source. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Paper Capacity of the Output Tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Loading Paper in the Paper Cassette . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
When Loading Paper in Cassette 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
When Loading Standard Size Paper in Cassette 2, 3, or 4 . . . . . . . . . . . . . . . . . . . . . 36
When Loading Custom Size Paper (Non-Standard Size Paper) in Cassette 2, 3, or 4 . . . . 45
Loading Paper in the Multi-purpose Tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
When Loading Paper (Other than Postcards and Envelopes). . . . . . . . . . . . . . . . . . . . 55
When Loading Postcards (Only for LBP5910/5910F) . . . . . . . . . . . . . . . . . . . . . . . . . . 60
When Loading Envelopes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Paper Loading Orientation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Paper Jams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Precautions on Clearing Paper Jams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Paper Jam Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Procedure for Clearing Paper Jams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

2
Staple Jams (Only for LBP5910F) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Precautions on Clearing Staple Jams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Procedure for Clearing Staple Jams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Replacing the Toner Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
When a Message Appears. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Precautions on Replacing the Toner Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Replacing the Toner Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Resetting the Counter of Toner Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
In Case of LBP5910/5910F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
In Case of LBP5610 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
Replacing the Drum Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
When a Message Appears. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Precautions on Replacing the Drum Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Replacing the Drum Cartridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Removing the Drum Cartridge to Be Replaced . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Installing a New Drum Cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Replacing the Waste Toner Container . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
When a Message Appears. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Precautions on Replacing the Waste Toner Container. . . . . . . . . . . . . . . . . . . . . . . . 139
Replacing the Waste Toner Container . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Replacing the Staple Cartridge (Only for LBP5910F) . . . . . . . . . . . . . . . . . . . 146
When a Message Appears. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Precautions on Replacing the Staple Cartridge. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Replacing the Staple Cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
Canceling a Job (Only for LBP5910/5910F) . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
Deleting/Pausing/Resuming a Job (Only for LBP5610) . . . . . . . . . . . . . . . . . . 155
Confirming the Printer Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
In Case of LBP5910/5910F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
In Case of LBP5610. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Service Call Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
In Case of LBP5910/5910F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
In Case of LBP5610. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Message List (Only for LBP5910/5910F) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166

3
Turning the Printer ON/OFF (For 5910/5910F)
The power switch to turn the printer ON or OFF is located on the right side of the
printer. Be sure to observe the following instructions in order to prevent unexpected
problems.
Turning the Printer ON
In order to use this printer, you should press " " of the power switch to turn the
printer ON. After running a self-diagnostic test on the printer unit and optional
accessories, the printer will be ready to print.
IMPORTANT
• Do not turn the power ON immediately after turning it OFF. If you want to turn the printer
ON again after turning it OFF, wait at least 10 seconds after turning the printer OFF
before turning it ON again.
• Be sure to set the paper cassette in the printer before you turn the power ON for the first
time after you install the printer.
NOTE
When turning the printer ON for the first time after installing the hard disk, or when being
malfunction in the hard disk, it takes approx. 60 seconds to be ready to print because of
formatting after turning the printer ON.
1
Press " " of the power switch on the printer.

4
The indicators of the control panel and the display come on, and the printer
initiates a self-diagnostic test on the printer unit and optional accessories.
If no abnormality is found during the self-diagnostic test, the オンライン indicator
and the 印刷可 indicator, and the selected paper source display indicator comes
on, <00 インサツ カノウ > , <00 LIPS>, or <00 ESC/P> comes on the display
and the printer can be ready to print.
The following information is displayed on the display.
Turning the Printer OFF
Turn the printer OFF using the following procedure. The operation to turn the printer
OFF is different in whether using the hard disk or not.
IMPORTANT
•
When using the hard disk, be sure to turn the printer OFF as the procedure for the
protection of the hard disk. (See p. 6)
•
If the printer is used on a network, make sure that it is not printing data from another
computer before turning the printer OFF.
•
If turning the printer OFF with the
ジョブ
indicator being on, remaining print data will be
deleted. Turn the printer OFF after necessary print data completing to be output or being
output by selecting <
ハイシュツ
> with pressing [
リセット
] offline.
•
Do not turn the printer OFF when the printer is in any of the following status:
- During printing.
-While the printer is running a self-diagnostic test immediately after turning the power
ON
-When the messages informing you that the NVRAM is being initialized or being written
is displayed.
-While <
02 キドウチュウ
> or <
02 キャリブレーションチュウ
> is displayed.
•
When you are using a hard disk, make sure that HDD indicator is not on. If turn the
printer OFF while the HDD indicator is on (while data is being read from the hard disk or
being written to the hard disk), the hard disk may be damaged and disabled.
オンライン
給紙選択
印刷可 ジョブ
ジョブ
リセット
ユーティリティ セットアップ
メッセージ
ジョブキャンセル
HDD
OK
電源
主電源
オンライン
indicator
Paper source
display indicator
印刷可
indicator
00  ｲﾝｻﾂ  ｶﾉｳ  A4
Ready to print and no
processing print data
Paper size in the paper
source that is selected
currently

5
When Not Using a Hard Disk
When you are not using a hard disk, turn the printer OFF using the following
procedure.
1
Make sure that ジジ
ジジョョ ョョブブ ブブ
indicator is off.
2
Press " " of the power switch on the printer.
オンライン
給紙選択
印刷可 ジョブ
ジョブ
リセット
ユーティリティ セットアップ
メッセージ
ジョブキャンセル
HDD
OK
電源
主電源
Off

6
When Using a Hard Disk (Only When a Hard Disk is Installed)
When using the optional hard disk, turn the printer OFF using the following
procedure.
IMPORTANT
•
If you perform a shutdown when any job of which you stopped the operation or of
secured print is in the hard disk, the message <
ジョブガ ノコッテイマス
> or <
ジッコウ デ
キマセンデシタ
> is displayed.
If you want to execute a shutdown, perform a soft reset to delete the job, and then
perform a shutdown again.
If you do not want to execute a shutdown, press [
オンライン
].
•
Once you perform a shutdown, you cannot cancel the operation in midstream. When you
want to turn the printer ON again, turn the printer OFF once following the instruction of
the message, and then turn the printer ON.
NOTE
You can also perform <
シャットダウン
> in the
リセット
menu by pressing [
リセット
] on the
control panel.
1
Make sure that the ジジ
ジジョョ ョョブブ ブブ
indicator and HDD indicator are off.
2
Hold down the control panel power switch (sub power supply)
on the control panel until <00
0022 22 シシ シシャャ ャャッッ ッットト トトダダ ダダウウ ウウンン ンンチチ チチュュ ュュウウ ウウ > is
displayed, then release the switch.
Hold down the switch (approximately 4 seconds) until <
02 シャットダウンチュウ
>
is displayed. If the switch is released in less than 4 seconds, and <
スリープモード
>
is set to a setting value other than <
ツカワナイ
>, the printer enters Power Save
Mode.
オンライン
給紙選択
印刷可 ジョブ
ジョブ
リセット
ユーティリティ セットアップ
メッセージ
ジョブキャンセル
HDD
OK
電源
主電源
Off
電源
02  ｼｬｯﾄﾀﾞｳﾝﾁｭｳ


7
3
Confirm the message.
When the printer is ready to be turned OFF after the process for it is performed,
the message < デンゲンヲ オキリクダサイ > appears.
4
When the message <デデ
デデンン ンンゲゲ ゲゲンン ンンヲヲ ヲヲ オオ オオキキ キキリリ リリクク ククダダ ダダササ ササイイ イイ
> appears, press
""of the power switch on the printer.
ﾃﾞﾝｹﾞﾝｦ  ｵｷﾘｸﾀﾞｻｲ


8
Turning the Printer ON/OFF (For LBP5610)
The power switch to turn the printer ON or OFF is located on the right side of the
printer. Be sure to observe the following instructions in order to prevent unexpected
problems.
Turning the Printer ON
In order to use this printer, you should press " " of the power switch to turn the
printer ON. After running a self-diagnostic test on the printer unit and optional
accessories, the printer will be ready to print.
IMPORTANT
•
Do not turn the power ON immediately after turning it OFF. If you want to turn the printer
ON again after turning it OFF, wait at least 10 seconds after turning the printer OFF
before turning it ON again.
•
Be sure to set the paper cassette in the printer before you turn the power ON for the first
time after you install the printer.
1
Press " " of the power switch on the printer.

9
The indicators come on, and the printer initiates a self-diagnostic test on the
printer unit and optional accessories.
If no abnormality is found during the self-diagnostic test, the 印刷可 indicator (blue)
comes on, and the printer is ready to print.
Turning the Printer OFF
Turn the printer OFF using the following procedure.
IMPORTANT
•
If the printer is used on a network, make sure that it is not printing data from another
computer before turning the printer OFF.
•
If you turn the printer OFF, all the print data remaining in the printer memory will be
deleted. So, wait for the necessary print data to be printed before turning the printer OFF.
•
Do not turn the printer OFF when the printer is in any of the following status:
- During printing
-While the printer is running a self-diagnostic test immediately after turning the power
ON
1
Press " " of the power switch on the printer.
印刷可トナー トナ
On