Carefree TRAVEL'R User manual

O WNER ' S M ANUAL
T RAVEL ' R
12V M OTORIZED A WNING
WITH
D IRECT R ESPONSE
TM
RV
Before operating the awning, carefully review the Owner's Manual.
The manual contains important safety information, detailed operating
instructions, common maintenance procedures and other useful
information.
The Adjustable Pitch Travel'r with Direct Response is only offered through select OEMs.
T ABLE OF C ONTENTS
Introduction ........................................................................................................... 2 
Operation ............................................................................................................... 4 
Power Switch.......................................................................................4 
Patio Switch.........................................................................................4 
Motion Switch......................................................................................4 
Testing the Direct Response System ............................................................ 5 
Using the Key FOB Remote Control.............................................................. 5 
Key FOB Batteries...............................................................................5 
Programming the Remote Receiver ..............................................................6 
Operational Notes: ..............................................................................6 
LED’s.............................................................................................................7 
Adjusting the Pitch......................................................................................... 8 
Emergency Operation ................................................................................... 9 
Common Operational Questions.................................................................10 
Awning Care ........................................................................................................ 11 
Fabric Care..................................................................................................11 
Arm Care.....................................................................................................11 
Carefree Major Product Limited Warranty......................................................... 12 

Carefree of Colorado
2
INTRODUCTION
Thank you for your recent purchase of the Travel’r awning. We appreciate
having the opportunity to do business with you. Our customers are our top
priority, and we strive for 100% satisfaction. If you have any questions or
concerns about this order, please do not hesitate to contact us.
Check with your dealer to discover the products that can make your life more Carefree.
P RODUCT D ESCRIPTION
The Travel'r series of awnings provides motorized awning comfort with Carefree's
standards for looks, strength and dependability.
Features include:
The unique "scissor" style arms do not require vertical ground supports.
The adjustable pitch arms provide easy to use 6-position pitch adjustment.
The roller tube and arms are made from light weight, no-rust aluminum;
The 100% billow-proof, worm-gear drive motor eliminates the need for travel locks.
The Carefree Direct Response System
The Auto-Retract System is an exciting enhancement to basic awning operation. When
activated, the system will retract the awning automatically in windy conditions.
Sensitivity is set at the control panel.
The system uses a sensor in the motor head to detect awning motion caused by windy
conditions. The system operates by gauging the vertical motion of the awning’s leading
edge. When persistent motion exceeds the factory preset threshold value for 2
seconds or longer, the system will automatically retract the awning. The controls allow
the user to choose between 3 factory preset sensitivity values (threshold values).
Gust detection is incorporated into the Direct Response software. When the motion
value is suddenly and sharply increased above a safe maximum value, then the 2
second persistence measure is overridden and the awning closes immediately.
NOTICE The Carefree auto retract system is a premier electronic auto-
retract system that provides protection against adverse elements; but no auto-
retract system is a guarantee against severe or destructive weather; the effects
of wind and rain on an awning are unpredictable and may cause severe damage
to the awning and/or vehicle. If wind or extended periods of rain are expected,
roll up the awning.
D ISCLAIMERS
The Eclipse awning is a product of Carefree of Colorado, located in Broomfield,
Colorado, USA. The
information contained in or disclosed in this document is
considered proprietary to Carefree of Colorado.
Every effort has been made
to ensure that the information presented in the document is accurate and
complete. However, Carefree of Colorado assumes no liability for errors or for any
damages that result from
the useof thisdocument.
The information contained in this manual pertains to the current product listed on the
title page. Carefree of
Colorado reserves the right to cancel, change, alter or add any
parts and procedures, described in this
manual, without prior notice.
Carefree of Colorado agrees to allow the reproduction of this document for use
with Carefree of Colorado
products only. Any other reproduction or translation
of this document in whole or part is strictly prohibited
without prior written
approval fromCarefree ofColorado.

T RAVEL ' R P ATIO A WNING
3
S ERVICE AND S UPPORT
www.carefreeofcolorado.com/eclipse
[e-mail]
Carefree of Colorado
2145 W. 6
th
Ave.
Broomfield, CO
80020
Warnings and Cautions
This is the safety alert symbol. It is used to alert individuals to
potential personal injury hazards. Obey all safety messages that
follow this symbol to avoid possible personal injury or death.
NOTICE Awnings are designed to provide shade and protection from the
sun. The effects of wind and rain on an awning are unpredictable and can cause
severe damage to the awning and/or the vehicle. If wind or extended periods of
rain are expected, roll up the awning.
NOTICE It is recommended that if leaving the RV unattended for a
length of time, retract the awning to avoid unexpected weather conditions.
NOTICE If installed, LED lighting must be turned off when the awning
is in the rolled up position. This is to prevent possible damage to the LEDs
and/or canopy.
NOTICE When the awning is in the retracted (rolled up) position, shut
off the power switch to avoid accidentally extending the awning. For
safety, the power switch must be turned off before moving the RV.
WARNING Risk of fire. Keep all sources of heat and
flame away from the awning canopy. Fabric is NOT fireproof.
CALIFORNIA PROPOSITION 65
WARNING This product contains chemicals known to the state of
California to cause cancer or birth defects or other reproductive harm.
California’s Proposition 65 requires this warning to be given to customers
in the state of California.
Additional Warnings and Cautions are included in the text for the proper
operation of the awning.

Carefree of Colorado
4
O PERATION
The Direct Response system uses 3 switches at the control panel: Power Switch;
Patio Switch and Motion Sensitivity Switch.
P OWER S WITCH
P OWER ON ...Press the power switch to ON. When power is on, the Direct
Response system is active and the manual controls are active.
When power is OFF, all functions are disabled.
P
OWER OFF ...The down position shuts the system OFF.
P ATIO S WITCH
This is a two position momentary contact switch. This description also applies to
any additional patio switches that may be installed.
E
XTEND ..................Press and release the switch. The awning automatically
opens. To stop the awning before it is fully open, press and
release the extend switch a second time.
R
ETRACT ................Press and release the switch. The awning automatically
retracts until it is fully closed. To stop the awning before it is
closed, press and release the retract switch a second time.
M OTION S WITCH
HIGH ↔ MED ↔ LOW
Low requires less amount of motion before the awning closes automatically.
High requires more motion before the system closes automatically.
You may have to experiment to find the best setting for your preferences.
NOTE: If the motion switch is not installed, the system defaults to the medium setting.

TRAVEL'R PATIO AWNING
5
T ESTING THE D IRECT R ESPONSE S YSTEM
It is important to test the Direct Response system periodically to ensure that the
system is working properly. Follow the simple test below.
1. Extend the awning completely.
2. Set the motion sensitivity to the lowest setting.
3. Gently move the roller tube up and down in a vertical motion.
4. If the awning retracts, the system is working properly.
5. If the awning does not retract, contact an authorized Carefree dealer for repairs.
Operate the awning with the Patio switch until the system is repaired.
U SING THE K EY FOB R EMOTE C ONTROL
A remote control Key FOB is available only with the auto-retract
system. The remote provides the advantage of allowing you
to operate the awning from any convenient location.
The remote has a maximum operating range of 50 feet. Actual
distance may vary depending on the specific installation and
location of the receiver in the vehicle.
To use: turn system power ON at the control panel.
NOTE: Power ON/OFF and the Auto-Retract sensitivity can only
be operated at the control panel.
Extend Press and release. The awning will extend out to the full extension and stop
automatically.
Retract Press and release. The awning will retract and stop automatically when the
awning is fully retracted.
Stop Press and release. During extend and retract functions, the awning may be
stopped by pressing this button.
KEY FOB BATTERIES
The Key FOB w/ antenna uses a battery (Radio Shack p/n 23-279 or equivalent)
that should provide a long period of service. To access: Remove the small screw
from the back of the case and carefully snap off the back. Lift the old battery out
and insert the new battery.
Batteries are available through your local battery outlets.
Battery life is dependent on frequency of use, environmental conditions and
condition of remote.
Function
Buttons
Stop
DR010

Carefree of Colorado
6
P ROGRAMMING THE R EMOTE R ECEIVER
When adding or replacing a remote control, it is necessary to program the
transmitter and receiver.
1. Power to the control box must be on.
2. Press and release the “Press to Learn Transmitter” button on the bottom of the
receiver box. The receiver is in program mode when the red light comes on.
3. Press and release the STOP button on the remote. The red light will go out
after the receiver learns the remote signal.
NOTE: Pressing the stop button will cause the blue up arrow button to
default as the close (retract) function.
If a function button is pressed to train the receiver, it will be programmed as
the retract button. Example: Pressing the top button will program the top
button for retract and the bottom button as extend.
OPERATIONAL NOTES:
Transmitter and receiver operate on frequency 433 MHz.
The receiver exits the program mode after ten seconds.
If the light does not come on, the memory is full and must be cleared.
To clear the memory: PRESS AND HOLD the transmitter learn button. While holding the
button, the indicator light should be OFF for the full 5 seconds then come on.
If the light does not go out during programming, the receiver already knows the
transmitter's signal or the battery in the remote needs to be replaced.
The system may be programmed for up to 5 remotes. Additional remotes may be
ordered separately.
DR
0
2
0
TO EYE PORT
on RP24 Program Mode
Press to Learn Transmitter
UP
Program
Button
Indicator
Light
Stop
RR

T RAVEL ' R P ATIO A WNING
7
LED’ S
White (monotone) LEDs are a popular option providing lighting beneath the
awning. Factory installed LEDs are located on the roller tube or can be mounted
at the awning rail.
To operate the White LED lights, you must have the LED
power switch ON.
NOTE: Some OEMS may furnish their own switch that may
appear differently than the switch pictured or may have the
LED’s operated through a multiplexing control center.
RGB (Color) LEDs
Select OEMs may offer RGB LEDs. These are
NOT controlled through the BT12
Control System.
These lights use a separate IR (Infrared) remote and sensor. The top of the
remote must be pointed at the infrared sensor on the LED receiver module.
The remote control provides:
Simple push button on/off
Adjustable dimming
15 color choices + white
Special effects
(flash, strobe, fade and smooth)
Dim OFF/ON
Color
Select Special
Effects
LEDRGB003
OFF ON
WRGB
FLASH
STROBE
FADE
SMOOTH

Carefree of Colorado
8
A DJUSTING THE P ITCH
The Travel'r arms have 6 pitch adjustment settings from minimum pitch to maximum
pitch. The awning can be extended and retracted in any of these positions without
having to reset the pitch between uses. See the Warnings about unequal pitch settings.
CAUTION Use care when adjusting the pitch, the awning may move
abruptly.
With the Awning Open:
1. Hold on to the awning arm to keep it steady while adjusting the pitch.
2. Press in the pitch adjustment pin located on the long scissor arm.
Tip: Applying LIGHT pressure on the arm will decrease the force required to
press the pitch adjustment pins.
3. Slide the scissor arm to the desired set hole - towards the coach for a lower pitch
and away from the coach for a higher pitch.
With the Awning Closed:
1. Press in the pitch adjustment pin located on the long scissor arm.
2. Slide the inner scissor arm up or down to the desired set hole.
NOTICE Before retracting the awning, make sure that the individual arms
are not more than three (3) pitch positions different between the left and right
arms. Damage to the arms and canopy can occur if the awning is retracted when
the arms are set at more than 3 positions difference.
NOTICE For awnings under 12': the arms must be set at an equal pitch.
Damage to the arms and canopy can occur if the awning is retracted with
the arms uneven.
Minimum Pitch
Maximum Pitch
Press Pin
Support and Lift This Area TravelR059
Min. Min.
Max.
Awning Open Awning Closed
Max.
Inner
Channel
Outer
Channel

TRAVEL'R PATIO AWNING
9
E MERGENCY O PERATION
If the original power source fails or is unavailable, the Travel'r has emergency
override connections (12V). The override can be used with a 10V-14V power
source, such as a cordless drill battery or car battery.
WARNING Do not connect the Travel'r motor wires to a 110V power
source! Doing so will permanently damage the awning!
CAUTION Use care when retracting the awning, the awning may move
abruptly.
NOTE: Jumper cables may be built in one of two styles as shown below. The
procedures are the same for either cable style.
1. Shut off the power switch to the awning. This will disable the Direct Response
system.
2. Locate and separate the quick disconnects
located in the motor arm channel. Position
the wires from the motor on the outside of the
channel.
3. Attach jumper wires to the motor wires.
4. Connect the other ends of the jumper leads
to a 12-14V source. If the awning moves in
the wrong direction, reverse the leads.
5. Maintain contact throughout the retraction
process. Hold the wires from the motor on
the outside of the channel while closing the
awning. This provides access for opening
awning.
6. When power is restored, use the jumper
wires and extend the awning to access the
cable disconnects. Reattach the disconnects
and secure in the arm channel.
NOTE: Jumper cables may not be included with some OEM installations.
Cables are available through your dealer
Universal Cable with Alligator Clips Cables with Quick Disconnects for
Motor Cables with Quick Disconnects Only
TravelR061b
Quick Disconnects
in Arm Channel
TravelR061a
Hold Wires
Outside of Channel
When Arm is Closing
Awning
Closed
or
Motor
Cable
Jumper
Cable

Carefree of Colorado
10
C OMMON O PERATIONAL Q UESTIONS
The following items are operational items that may come up as questions during
normal operation.
1. The awning motor is equipped with a thermal protection circuit to protect the motor
from overheating. Operating the awning repeatedly over a short time period may
cause the circuit to sense a overheat condition and shut off the motor. If this
occurs, wait approximately 15 minutes to allow the motor to cool then operate the
awning in normal fashion.
2. The awning seems to extend and retract slowly. Normal operation time is 28-35
seconds to extend or retract. If the power supply is on the low side of the
acceptable voltage range (10VDC-14VDC) the awning will move slower.
3. The awning may appear to move jerkily. When the fabric is rolled out, the
Alumaguard or Uniguard may "bounce" creating a wave like motion in the canopy
fabric. This will create the appearance of moving jerkily.
4. With Uniguard, the awning sticks or hangs up. When Uniguard is installed with a
vinyl canopy, the vinyl will have a tendency to "cling" to the Uniguard when not
used over an extended period. Open and close the awning in short bursts 2 or 3
times, the awning will then open normally.
5. Ignition Lockout Sensors: If the optional Carefree EL ignition lockout is installed
the system will disable the extend function while the vehicle ignition key is in the
ON position. Special order RTL ignition lockouts will fully retract the awning and
disable the extend function when the vehicle ignition key is in the ON position.
Functions will return to normal operation when the ignition key is turned OFF.
RV manufacturers may install their own lockout design. Refer to the RV literature
for 12V power used for accessories.
If the awning does not operate, contact your Carefree Service Center. Visit our web site
at www.carefreeofcolorado.com for a listing of dealers and service centers.

TRAVEL'R PATIO AWNING
11
AWNING CARE
Maintaining a Carefree Awning is easy. Just follow these basic steps:
Always operate the awning according to the instructions.
Periodically check that the fasteners are tight. Tighten if necessary.
Keep the awning fabric and arms clean.
F ABRIC C ARE
NOTICE DO not use oil based cleaners or any caustic, granulated, or
abrasive type cleaners on your Carefree product.
1. One of the best ways to keep the fabric looking good and to delay the need for
deep or vigorous cleanings is to hose fabrics off on a monthly basis with clear
water. This practice helps prevent dirt from becoming deeply imbedded in the
fabric. In most environments, a thorough cleaning will be needed every two to
three years.
2. When it’s time for a thorough cleaning, the fabric can be cleaned while still
on the awning frame.
For Vinyl Fabric – Use a soft brush and warm water with soap.
For Acrylic Fabric – Use a stiff brush and warm water with soap.
3. When cleaning the fabric, it is important to observe the following:
Always use a natural soap, never detergent.
Water should be cold to lukewarm, never more than 100F.
Air-dry only. Never apply heat to the fabric.
Always allow the fabric to dry thoroughly before rolling up the awning.
MILDEW
Mildew is a fungus growth that looks like dirt. Vinyl coated polyester fabrics are
mildew resistant because of a chemical biocide in the vinyl coating. Under
ordinary conditions, mildew will not appear. However, in areas where high
temperature and humidity are common, mildew can be a problem and require the
material to be washed more frequently.
POOLING
When water collects on the top of the fabric, this is known as "pooling". This can
occur during inclement weather or if a running air conditioner discharges over the
awning. The water is dumped when the awning is retracted. It is recommended
that if water accumulates on the top; retract the awning in steps (8"-12") to dump the
water. This will help prevent the fabric from stretching or distorting.
The effects of wind and rain on an awning are unpredictable. Severe
damage to the awning and the vehicle may result. IF WIND OR EXTENDED
PERIODS OF RAIN ARE EXPECTED,ROLL UP THE AWNING AND SECURE FOR TRAVEL.
LEAKING
On vinyl canopies, side hems and poly cords are stitched in with a sewing machine. On
occasion, this stitching may allow water to seep or leak through. This is normal and not
a defect covered by warranty. Treat the seams with a quality seam sealer.
A RM C ARE
The best method of keeping the arms and braces operating smoothly is to clean them.
Dirt and debris can cause the arms not to move easily. Periodically wash out the
channels with running water (i.e. a hose). If the arms still do not move easily, lightly
spray the joints and pivot points with a dry silicone lubricant after the arms have been
cleaned and dried thoroughly.

052540-231r2 Printed in USA September, 2018
CAREFREE MAJOR PRODUCT LIMITED WARRANTY
Carefree of Colorado (hereafter referred to as Carefree) warrants to the first retail
Purchaser that the Carefree Product is free of defects in material and
workmanship within the terms and conditions as set forth in the warranty
statement available online at www.carefreeofcolorado.com. Carefree’s obligation
under this warranty is limited to the repair or replacement, at Carefree’s option, of
any defective component with new or factory refurbished components.
OWNER MUST RETAIN THE ORIGINAL PROOF OF PURCHASE AND/OR HAVE THE PRODUCT
WARRANTY REGISTRATION ON FILE AT CAREFREE FOR WARRANTY CLAIMS.
THIS WARRANTY IS NOT TRANSFERABLE.
Visit www.carefreeofcolorado.com for
- Warranty Duration;
- Warranty Coverage and Exclusions;
- Warranty Terms of Coverage; and,
- Warranty Claim Procedures
Register your Carefree products online at www.carefreeofcolorado.com
IMPORTANT NOTICE: It is strongly recommended that adjustments and repairs not
described in this book be performed by trained technicians at your Authorized
Carefree Dealer. Work performed by non-authorized persons or businesses may
void warranty.
Quality
Performance
Value
Style
Carefree of Colorado 2145 W. 6
th
Avenue Broomfield, CO 80020 a Scott Fetzer company