Cres Cor H-339-135-BK Series User manual

FL-0520-4
5925 Heisley Road •Mentor, OH 44060-1833
877/CRES COR (273-7267) •440/350-1100
Fax: [phone] •www.crescor.com
OPERATION AND MAINTENACE MANUAL:
BURGER KING HOLDING UNIT
MODEL: H339-135-BKC3

5925 Heisley Road •Mentor, OH 44060-1833
877/CRES COR (273-7267) •440/350-1100
Fax: [phone] •www.crescor.com
Insulated Hand-lift
Holding Cabinet FL-0520-4
Rev. 6 (7/00) Page 1 of 4
OPERATING and MAINTENANCE INSTRUCTIONS
For HAND-LIFT HOLDING CABINET, H-339-135-BK SERIES
ELECTRICAL SPECIFICATIONS:
MODELS Volts Watts Amps Hertz Phase NEMA
120 900 7.5 60 1 5-15
H-339-135-BK Series
240 900 3.8 60 1 6-15
All models are: Certified by Canadian Standards Assoc. under File No. LR-18148;
Approved by National Sanitation Foundation under Standard 4;
Listed by Underwriters’ Laboratories under filed E27846;
Designed for AC Service.
FIGURE 1
HOW TO INSTALL UNIT:
1. Lay cabinet down on its back; look at the bottom
plate and note that every corner has a (4) hole
pattern that matches up with the holes on the
caster plate.
2. Remove the (16) screws that are in those caster
mounting holes.
3. Unpack casters and attach them into the (16)
holes with the screws provided (add brake
casters to front of cabinet).
4. Plug cord into 15-amp wall outlet.
5. Place cabinet in a well ventilated area.
6. Push the switch on, turn the thermostat to No. 10
and run the unit for one hour.
NOTE: DO NOT PUT IN FOOD!
This step is to burn off manufacturing oils
and excessive adhesive.
7. Let the cabinet cool and wipe inside clean with
detergent and hot water before use.
HOW TO OPERATE UNIT: (Figure 1)
1. Push switch “ON”. Yellow light will come on.
2. Turn thermostat to the temperature you need.
NOTE: No. 6½ setting will give you about
180°F/82°C. Proper food holding temperature is
140° F/60°C or higher.
3. Preheat cabinet for 45 minutes
4. Put food into cabinet.
5. Turn the wing nut on the door vent to open the
vent when less humidity is needed.
To Turn Off Unit:
Push switch “OFF”. The yellow light will go off.
NOTE: Thermometer gives the inside cabinet
temperature.
DOOR
VENT
THERMOMETER
SWITCH LIGHT
“ON-OFF”
THERMOSTAT

5925 Heisley Road •Mentor, OH 44060-1833
877/CRES COR (273-7267) •440/350-1100
Fax: [phone] •www.crescor.com
Insulated Hand-lift
Holding Cabinet FL-0520-4
Rev. 6 (7/00) Page 2 of 4
OPERATING and MAINTENANCE INSTRUCTIONS
For HAND-LIFT HOLDING CABINET, H-339-135-BK SERIES
BEFORE CLEANING CABINET:
1. Remove Power Cord from cabinet.
2. Do NOT hose cabinet with water.
3. Do NOT get water on controls.
Do NOT use abrasives or harsh chemicals.
NO OVEN CLEANER!
Cleaning Hints:
1. Wipe up spills as soon as possible.
2. Clean cabinet regularly to avoid heavy dirt build-
up.
3. Make a test spot with cleaner.
4. Follow manufacturer’s directions on cleaner.
5. Do not mix cleaners
6. Avoid drips and splashes.
HOW TO CLEAN UNIT:
SOIL CLEANER METHOD
DIRT
Mild detergent* and hot
water, or mild abrasive
cleaner.
1. Use soft, damp cloth.
2. Rinse with hot water.
3. Wipe dry.
Steam (no strong alkaline
additive)
1. Rinse after steam cleaning.
2. Wipe dry.
Detergent* and hot water
1. Wipe with soft, damp cloth.
2. Rinse with hot water.
3. Wipe dry.
Chemical cleaner for
aluminum. Follow cleaner manufacturer’s directions.
FINGER PRINTS,
GREASE OIL
Mild abrasive cleaner.
Oily or waxy cleaner. Apply with soft, clean cloth
CABINET
Inside and
Outside
(Aluminum)
WATER SPOTS Mild abrasive cleaner. Wipe with damp cloth.
ROUTINE CLEANING Soap, Ammonia, or mild
*detergent and water.
1. Sponge on with cloth.
2. Rinse with water.
3. Wipe dry.
STUBBORN SPOTS
AND STAINS
Mild abrasive made for
stainless steel.
1. Apply with damp sponge or cloth.
2. Rub lightly.
BURNT-ON FOODS
OR GREASE
Chemical oven cleaner for
stainless steel.
Follow oven cleaner manufacturer’s
directions.
RACK
INSERT
Removable
(Stainless Steel)
HARD WATER
SPOTS and SCALE Vinegar 1. Swab or wipe with cloth. 2. Rinse and dry.
* Mild detergents include soaps and non-abrasive cleaners

5925 Heisley Road •Mentor, OH 44060-1833
877/CRES COR (273-7267) •440/350-1100
Fax: [phone] •www.crescor.com
Insulated Hand-lift
Holding Cabinet FL-0520-4
Rev. 6 (7/00) Page 3 of 4
OPERATING and MAINTENANCE INSTRUCTIONS
For HAND-LIFT HOLDING CABINET, H-339-135-BK SERIES
HOW TO REVERSE DOOR HARDWARE
FOR OPPOSITE HAND (Refer to Fig. 2 [hinge]):
1. Pop off hinge covers with a screwdriver.
2. Remove screws from hinges to door (Item 1)
and hinge brackets to cabinet (Item 2).
3. Remove screws from latch to door and latch
bracket to cabinet.
NOTE: Keep hinges and latch strike
mounted to the brackets.
4. Remove all remaining screws from both sides of
door and cabinet in that area. Keep all screws.
5. Turn latch strike bracket 180° and mount it to
the opposite side of the cabinet with the same
screws you removed. Do the same with the
hinge brackets.
6. Line up (4) latch holes to door holes on the
opposite side of the door. Mount latch with
same screws that were removed.
7. Mount hinges to the opposite side of the door
and snap on the hinge covers.
8. Plug remaining holes with screws.
FIGURE 2
TROUBLE-SHOOTING CHART
FAILURE POSSIBLE CAUSE/CHECK
1a. Thermostat turned up.
1. Unit does
not heat: 1b. Switch is “ON”.
1c. Cord is plugged into
outlet.
1d. Circuit breaker/fuse for
wall outlet
2a. Thermostat turned down.
2. Unit will not
turn off: 2b. Switch is “OFF”
If cause is none of the above, refer to our list of
authorized service agencies, FL-1400.
Instructions for replacing parts are included in
replacement parts kits.
REPLACEMENT PARTS
120V. 240V.
Cord Set 0810-029 0810-139
Switch Kit 0808-113-K 0808-113-01-K
Heater Kit 0811-066-K 0811-066-1K
Thermostat Kit 0848-008-ACK 0848-008-ACK
Terminal Block 0852-091 0852-091
Door Latch Kit 1006-142-K1
Hinge Kit 0519-030-K
Thermometer 5238-030-K
Gasket Kit 0861-077
Rack Insert 1104-083
Door Ass’y., (Reversible) 5508-087
Leg Kit 1206-064
Caster Kit, 3” Dia. 5544
Caster Kit, 5” Dia. 5518

5925 Heisley Road •Mentor, OH 44060-1833
877/CRES COR (273-7267) •440/350-1100
Fax: [phone] •www.crescor.com
Insulated Hand-lift
Holding Cabinet FL-0520-4
Rev. 6 (7/00) Page 4 of 4
OPERATING and MAINTENANCE INSTRUCTIONS
For HAND-LIFT HOLDING CABINET, H-339-135-BK SERIES