Direct Healthcare Group GATE Bure Ortho User manual

A DIRECT HEALTHCARE GROUP COMPANY
GATERD.SE
Bure Ortho
Bure Ortho S
Bure Space
Technical Manual

BURE ORTHO/ORTHO S/SPACE
GATERD.SE2

TECHNICAL MANUAL
3
GATERD.SE
Contents
1. Parts list 04
2. Spare parts 06
3. Accessories 07
4. Remote Control Plus 07
5. Other instructions T-Motion 08
6. General maintenance advice 09
7. Safety instructions 09
8. ID label 09
9. Recycling/Scrapping 09
10. Warranty 09
11. Dimensions 10
Bure Ortho
Bure Ortho S
Bure Space

BURE ORTHO/ORTHO S/SPACE
GATERD.SE4
1. Parts list
1Arm rest plate 12 Intermediate frame 22 Control box (T-Motion)
2Plastic washer 13 Bolts 23 Battery
3Knob 14 Protective cover 24 Holder/ remote
control
4Upper frame 15 Base frame 25 Remote contro
(T-Motion)
5Attachment bolt
(2pcs)
16 End bushing 26 A Gas strut
6Serrated washer 17 Castor BHandle
7Handle and grip 18 Bolt CArm/housing
8Chromium-plated
tube
19 Washer DBolt, washer (2 pcs),
nut (attachment at
bottom and top)
9Clamp 20 Cover/green
10 Knob 21 Actuator (T-Motion)
11 Guide sleeve
GAS

TECHNICAL MANUAL
5
GATERD.SE

BURE ORTHO/ORTHO S/SPACE
GATERD.SE6
2. Reservdelar
Nr. Art. Nr. Beskrivning
1 57-357-R Arm rest plate, right
1 56-357-L Arm rest plate, left
2 57-904 Plastic washer/Arm support widening
3 56-364 Knob for adj. width of arm rest plates
4 57-356 Upper frame
5 57-816 Attachment bolt, M10x40
6 57-803 Serrated washer
7, 9, 10 56-353 Handle kit (2 pairs incl. attachment knob/clamps)
8 58-311 Guide tube with bronze bushings
10 56-363 Knob for adjusting handle
11 56-340 Guide sleeve
12 57-355 Intermediate frame
13 57-810 Bolt M8x45
14 56-375 Protective cover, plastic
15 57-354 Lower frame Bure Ortho
15 57-354-S Lower frame Bure Ortho S
15 57-373 Lower frame Bure Space
16 56-344 End piece, lower frame, Black/D45
17 56-361 Castor with brake 125mm
- 56-357 Castor without brake 100 mm
- 56-358 Castor with brake 100 mm
- 56-360 Castor without brake 125 mm
- 56-387 Castor with brake 75 mm
18 - Bolt M10x50
19 57-848 Nordloc washer
20 58-331 Cover/green (T-motion)
21 58-377 T-Motion - Actuator (Raise/Lower)
22 58-373 T-Motion - Control box 220 V
22 58-373-1 T-motion - Control box 110 V
23 58-376 T-Motion – Battery
24 57-041-2 Holder, hand controller
25 58-374-1 T-Motion – Hand control (Raise/Lower)
- 56-305 Touch-up paint, Bure Silver 8
- 58-326 T-Motion – Power cable, coiled
- 58-326-1 Power cable, coiled UK
- 58-326-2 Power cable, coiled US
- 58-326-3 Power cable, coiled AUS
26A 57-007-1 Gas strut 400mm
26B 57-329 Plastic handle
26C 57-008-2 Lever/Alu

TECHNICAL MANUAL
7
GATERD.SE
3. Tillbehör
Art. Nr. Beskrivning
56-326-0 Handbrake kit/2 handles
56-326-1 Handbrake kit/One-handed brake
56-327 Frame elevation kit, 70 mm
56-393 Footplate, short, Bure Ortho/Space
56-383 Footplate, long, Bure Ortho/Space
56-392 Drip holder
56-335 Attachment for drip holder
56-336 Oxygen holder
56-337 Side support, adjustable
56-338 Drip rod complete with attachment
56-389 Soft basket with attachment
56-061 Remote control PLUS (TH10) including Holder
4. Remote Control Plus
**1. Service indicator – ashes red after 11 months’ operation. Constant light (red) after 12 months’ operation.
The indicator is a reminder to review the maintenance instruction (see Instructions for Use/Technical Manual.
This should be done at least once every 12 months.
Reset: hold down buttons <2a> + <2b> for at least 30 seconds.
**The indicator will go out around 30 seconds after the remote control is activated
(battery conservation function).
1
2a 2b

BURE ORTHO/ORTHO S/SPACE
GATERD.SE8
5. Other instructions T-Motion
Control box wiring
Remove the control box cover to make the connections as described below. Use a screwdriver or similar; refer
to the special labels on the control box.
1. Socket for the raise/lower actuator. NOTE: Make sure that plugs are connected to the correct sockets
otherwise the actuators can be damaged.
2. Remote control socket.
3. Battery terminal socket.
4. Plug socket. NOTE: The plug must ALWAYS be connected to the control box for IP protection to be valid.
Battery charging
• Connect plug to 230V wall socket. Charging begins automatically and the battery LED ashes green.
• Make sure the battery is fully charged before using for the rst time. It takes around 25 h to fully charge the
battery.
• We recommend that the battery plug be removed from the control box if the product will be out of use for
an extended period (more than one week) or if the battery is switched off by means of the ON/OFF switch.
This eliminates the risk of disabling the battery as the control box always uses a small quantity of electricity
even when the walker is not in use.
LEDs on control box and battery
Control box – green light when power is available from battery/mains socket.
Battery:
• The LED ashes green during charging.
• ON/OFF: To use the product, press ON.
• The green lamp will begin to ash.
• Use the OFF button (hold down for 5 s) to switch off the battery if the product will not be used for an
extended period.
• The LED will shows a constant green light when the battery is fully charged.
• When the battery is in normal state/in operation, the LED ashes green at REGULAR intervals, namely 0.5
s ON, 4 s OFF.
1
2
3
4

TECHNICAL MANUAL
9
GATERD.SE
• When the battery requires charging (remaining charge <25%) the LED will ash orange/red at REGULAR
intervals, namely 0.5 s ON, 4 s OFF.
NOTE: The battery has an in-built device that automatically switches it off when remaining charge is <20%.
The LED is then extinguished. The battery must now be fully charged before the electronics can be used again.
6. General maintenance advice
• Wipe the walker and its armrests clean as necessary; use soap solution or alcohol-based surface
disinfectant.
• The product may be cleaned in a tunnel washer or similar as electrical systems have IP65 protection.
However, the product is not corrosion proof which means washing by machine may reduce its service life.
• Replace damaged parts immediately; must be done by experienced personnel.
• The product is only intended for indoor use.
7. Safety instructions
Bure Walker may only be used:
• As a WALKING AID indoors
• on HARD, LEVEL surfaces
MAX USER WEIGHT: 150 KG
8. ID label
1. Part number
2. Product name
3. Date of manufacture
4. Max user weight
5. Serial number
6. EAN code
9. Recycling/Scrapping
When the product is no longer usable it should be recycled in accordance with legislation and regulations
in the country concerned. All electrical parts including batteries must be removed and recycled as electrical
components. (Ask your local recycling station for further information about how the different materials in the
product (metals, plastics, electronics) should be recycled).
10. Warranty
We provide two years’ warranty for manufacturing faults (does not apply to wear parts). For further information
or enquiries please contact:
Gate Rehab Development AB
Industrigatan 2, 330 21 Reftele
tel [phone]
[email protected]
1
2
3
4
6
5
56-317T
Gåbord Bure Ortho
A DIRECT HEALTHCARE GROUP COMPANY

BURE ORTHO/ORTHO S/SPACE
GATERD.SE10
11. Dimensions
Ortho, S, Space
Product weight 20kg (Gas 15kg)
Product height 90-130cm
”LIFT” denotes suitable handhold for lifting the walker.
NOTE: At least two people are required for lifting.

TECHNICAL MANUAL
11
GATERD.SE

GATERD.SE
Gate Rehab Development AB
Industrigatan 2
Reftele, Sverige
S-330 21
T: 0371-318 00
F: 0371-318 01
E: [email protected]
LIT-00101 Issue 1
Date: January 2020
A DIRECT HEALTHCARE GROUP COMPANY