Direct Healthcare Group Bure XL User manual

Bure XL
User Manual
Technical Manual
Service Manual
DIRECTHEALTHCAREGROUP.COM Manual no: 801 rev. 1 210604
SWL: 240 kg/ 529 lbs
56-315
56-315/75
56-315/75-UK
56-315/75-PU
56-315-PU-AUS
56-315-AUS
56-315-CAN
56-315-PU
56-315-PU-UK
56-315-B/0
56-315-B/1
56-315-B/0-PU
56-315-S
56-315-UK
56-315/100

BURE XL
DIRECTHEALTHCAREGROUP.COM
2
Contents
1. Intended Use 03
2. Contraindications, Precautions and Warnings 03
3. Raising and Lowering the Frame 04
4. Adjusting the Handles 04
5. Left and Right Adjustment of Armrests 04
6. Locking/Unlocking Castors 04
7. Control Box Wiring 05
8. Battery Charging 05
9. LED on Control Box and Battery 05
10. Maintenance 06
11. General Maintenance Advice & Cleaning 07
12. Technical Specifications 07
13. Safety Instructions 08
14. Recycling/Disposal 08
15. Warranty 08
16. Electrical System - Technical Data (T-motion/Linak) 09
17. Parts List 10
18. Spare Parts 11
19. Accessories 11
20. Table of Symbols 12
Bure XL
Bure XL was designed for the bigger, heavier patient and therefore provides extra space and strength.
Because extra powerful aids are required in the care and nursing of heavier patients, Bure XL is always
supplied with electric drives.

BURE XL
3
DIRECTHEALTHCAREGROUP.COM
1. Intended Use
Walkers are indoor, movable and portable assistive aids, which together with approved accessories are
intended to be used for transfer from sitting to standing positions, and walking training. Walkers are to be used
by persons with reduced muscular strength, who shall be able to stand and perform simple leg movements.
Walkers are to be used for leaning on when walking and standing during early mobilization training. Walkers
and accessories are intended for indoor use only in Home Healthcare environment and Professional Healthcare
facility environment.
2. Contraindications, Precautions and Warnings
Contraindications
• The device may not be used by patients above the maximum weight indicated on the label of the device.
Precautions
• Check that the device is used on a dry and flat surface.
• Check the device is correctly mounted/assembled before its first use.
• Check the device after every folding/disassembly after any transport.
• Check height adjustment and leg spreading motions and inspect the actuators’ or gas pistons’ full ranges.
• Activate the brakes whenever the device is not in use.
• Check the function of the brakes before use.
• Inspect the device regularly to detect any signs of damage. If there are any visible signs of damage,
contact Direct Healthcare Group Customer Service.
• In case of an electrical model of the device, check that the hand control does not show signs of wear
before every use.
• Check that the hand control markings are in accordance with the lifting functions.
• Check the battery status of an electrically operated model, before using the device.
• It is important to never leave the user alone during the transfer.
• Warranty applies only if repairs or alterations are made by personnel who are authorized by Direct
Healthcare Group.
• Ensure that there are no obstacles or people in the way of the device, when moving.
• Handle batteries with care. Do not drop.
• Use only batteries and cables that are intended for the device as instructed by the manufacturer.
• Verify that potential accessories that might be used are properly attached to the device before use.
• Low speed is recommended when moving with the device.
• Take care not to drive the device over thresholds with high speed or force. Approach the threshold with
lower speed and communicate the coming threshold to the user.
• Keep the instructions for use together with the product so that it can be used as a reference if necessary.

BURE XL
DIRECTHEALTHCAREGROUP.COM
4
Warnings
• The caregiver must be able to read and understand the Manual/IFU of the product.
• It is important to only use approved accessories as stated in the manual/IFU to prevent unintended
detachment of components and subsequently a fall that may lead to patient injury.
• Use careful and gentle maneuvers when moving the device.
• Perform maintenance/service of the device, according to the instructions in the manual/IFU, at least once
every 12 months.
• Accessories must be properly attached. They should be tested in relation to the user’s needs and
functional ability.
• Special care must be taken when using strong electrical power sources such as diathermy and the like
so that diathermy cables are not placed on or near the device. In case of doubt consult with a Direct
Healthcare Group representative.
• When lifting the device, only use the denoted handholds. At least two people are required for lifting the
device
• Do not leave a user or patient unattended when the device is being used.
• Never move the lift by pulling on the actuator or gas piston.
• The device must not be lowered into water.
• The device must not be left or stored in a damp or humid environment.
• The device must not be cleaned using steam.
• The device must not be charged in a wet room.
• The device must not be used outdoors, only indoors.
3. Raising and Lowering the Frame
Adjust the height with the aid of the remote control <UP> and <DOWN> arrows.
4. Adjusting the Handles
To adjust handles to the desired position; loosen screw, adjust handle, tighten
screw.
5. Left and Right Adjustment of Armrests
The armrests can be adjusted sideways for optimal support; loosen screw, adjust
armrest, tighten screw.
6. Locking/Unlocking Castors
Depress the foot brake to set it and lock the castor.
Press down on the protruding part of the brake to release it.

BURE XL
5
DIRECTHEALTHCAREGROUP.COM
7. Control Box Wiring
Remove the control box cover to make the connections as described
below. Use a screwdriver or similar; refer to the special labels on the
control box.
NOTE! Make sure that plugs are connected to the correct sockets
otherwise the actuators can be damaged.
1. Battery terminal socket.
2. Plug socket. NOTE: The plug must ALWAYS be connected to the
control box for IP protection to be valid.
3. Remote control socket.
4. Socket for the raise/lower actuator.
8. Battery Charging
Battery charging must take place when the Walker is not in use (the battery
can never be overcharged). Charging is carried out by inserting the plug in
a wall socket.
The battery should be charged at least 24 hours before first time use.
9. LED on Control Box and Battery
Control box – green light when power is available from battery/mains
socket.
Battery:
• The LED flashes green during charging.
• ON/OFF: To use the product, press ON.
• The green lamp will begin to flash.
• Use the OFF button (hold down for 5 s) to switch off the battery if the
product will not be used for an extended period.
• The LED will shows a constant green light when the battery is fully
charged.
• When the battery is in normal state/in operation, the LED lashes green
at REGULAR intervals, namely 0.5 s ON, 4 s OFF.
• When the battery requires charging (remaining charge <25%) the LED
will flash orange/red at REGULAR intervals, namely 0.5 s ON, 4 s OFF.
NOTE: The battery has an in-built device that automatically switches it off
when remaining charge is <20%. The LED is then extinguished. The battery
must now be fully charged before the electronics can be used again.
1
2
3
4

BURE XL
DIRECTHEALTHCAREGROUP.COM
6
10. Maintanance
Recommended at least once per year.
Check that Action
General
The Walker feels firm/free from play.
The Walker does not rattle during manoeuvres.
The Walker is level and all of its castors are in contact with
the floor.
The Walker is not dirty.
Clean with lukewarm soap solution or
alcohol-based cleaning agent (no petroleum products).
Armrests
Armrests are intact and clean.
Armrest widening is functional.
Clean; replace if damaged.
Fit lock screws/plates as required
Handle
Grips are not damaged/dirty.
Handle adjustment is functional.
Clean with lukewarm soap solution (no petroleum
products).
Replace handle grips.
Fit lock screws/plates as required.
Height adjustment
Raising and lowering are functional.
The Walker feels stable at maximum settings.
There is no play between the vertical frame and bottom
frame.
Height adjustment clamps lock.
The electric actuator fitting must be free from play.
Height adjustment via remote control is functional. The
electric actuator must run smoothly at a constant speed.
Fit new guide sleeves (in frame) or end plugs (in chrome
tubes) as required.
Tighten all lock bolts.
Replace clamps.
Tighten the attachment fitting concerned; replace bolts/
lock nuts as necessary.
Check that the battery/remote control/actuator are
connected in accordance with the wiring diagram. Charge
the battery. Contact customer services.
Frame parts
There is no mechanical damage.
There are no scratches.
End plugs/lower frame fitted.
If damage is present, contact GATE’s customer services.
Touch up as necessary.
Fit new end plugs.
Castors/brakes
Castors roll easily/tread not damaged.
The castors are firmly fastened to the lower frame.
Castor brakes functional on all castors.
Handbrake functional.
Clean or replace castors.
NOTE: Castors are always fixed to the lower frame with
thread locker or lock nuts. Do not dismantle the castors;
replace the whole castor assembly instead.
Tighten the castor bolt and fit locking nut or use thread
locker (depends on model).
Replace castor assembly.
Adjust the brake or fit new castors.

BURE XL
7
DIRECTHEALTHCAREGROUP.COM
11. General Maintenance Advice & Cleaning
• Clean the Walker and its armrests clean as necessary - Wipe using a soap solution/surface disinfectant.
• The product may be cleaned in a tunnel washer or similar as electrical systems have IP65 protection.
However, the product is not corrosion proof which means washing by machine may reduce its lifetime.
• Replace damaged parts immediately; must be done by experienced personnel.
• If the product is to be cleaned in a washing tunnel / washing cabin, use PU-cushions.
• The product is only intended for indoor use.
12. Technical Specifications
Dimensions apply to Walkers with 125 mm castors
Part No. Product Product
width
Max user
weight
Length Height Armrest/
Internal
dimension
56-315 Bure XL EL 90cm 240kg 84cm 87-127cm 45-64cm
“LIFT” denotes suitable handhold for lifting the Walker
NOTE: At least two people are required for lifting.
Product weight: 29 kg
Max user weight: 240 kg

BURE XL
DIRECTHEALTHCAREGROUP.COM
8
13. Safety Instructions
The Bure Walker may only be used:
• As a WALKING AID, indoors
• On HARD, LEVEL surfaces
Max. user weight: 240 kg
14. Recycling/Disposal
When the product is no longer usable it should be recycled in accordance with legislation and regulations in
the country concerned. All electrical parts including batteries must be removed and recycled as electrical
components. (Ask your local recycling station for further information about how the different
materials in the product (metals, plastics, electronics) should be recycled).
15. Warranty
We provide two years warranty against manufacturing faults (does not apply to wear parts). For further
information or enquiries please contact:
Direct Healthcare Group Sverige AB
Torshamnsgatan 35,
SE-164 40 Kista, Sweden
Tel: [phone]
[e-mail]
www.directhealthcaregroup.com

BURE XL
9
DIRECTHEALTHCAREGROUP.COM
16. Electrical System - Technical Data (T-motion/Linak)
Actuator Lift Widening Lift Widening
Producer TiMotion TiMotion Linak Linak
Voltage 12V 24V 24 V 24 V
Push 2000N/1500N 1000N 1000N/1500N/2000N 1200 N
Pull 2000N/1500N 1000N 1000N/1500N/2000N 1200 N
Self-locking push 1000N 1000N 7A 3 A
Current 6.6 (+/-1,0)A 2.6 (+/-0,4)A 7A ut/7 A in 3A ut/3 A in
Colour Black Aluminium White White
Stroke 400mm 55mm 400 mm 55 mm
Mounting dim 605mm 167mm 606+/-2 mm 165 +/- 2 mm
Encapsulation IP66 IP66 IPX6 IPX6
IEC60601-1 3rd revision
Control box + Battery
Producer T-Motion Linak
Voltage 24V 230V/24V
Capacity 2.0AH 2,25 Ah
Encapsulation IP66 IPX6
Colour Black White
Electrical safety Class II Class II (Dubbel insulated)
IEC60601-1 3rd revision

BURE XL
DIRECTHEALTHCAREGROUP.COM
10
17. Parts List
1A
B
C
Armrest
Knob
Plastic washer
6M
N
O
P
Q
R
End bushing/plastic
Wheel
Bolt
Washer
Nut
Washer
2D
E
F
Handle and grip
Clamp
Knob
7Protective plate (left/right)
3Upper frame 8S
T
U
V
Remote control
Holder/remote control
Battery
Control box
4G
H
I
J
Chromium-plated tube
Attachment bolt
Washer
End bushing
9X
Y
Actuator (raise/lower)
Bolt, washer (2 pcs),
nut (attachment at bottom and
top)
5K
L
Frame with battery shelf
Guide sleeve

BURE XL
11
DIRECTHEALTHCAREGROUP.COM
18. Spare Parts
No. Part no. Description
- 56-305 Touch-up paint Bure, Silver 8
- 56-306 Touch-up paint Bure, Dark grey RAL 7021
1A 57-327 Armrest right
1A 57-328 Armrest left
T 56-328 Holder, hand controller
L 56-340 Guide sleeve
J 56-343 End piece, guide tube
U 56-346-1 Battery/LA31
U 56-346 Battery incl. circuit board/LA28
X 57-004-02 Actuator (raise/lower)/LA31
X 57-004-01 Actuator (raise/lower)/LA28
2 56-353 Handle kit, Bure Std (2 pairs incl. lock knob/clamps)
- 56-357 Wheel without brake 100 mm
- 56-358 Wheel with brake 100 mm
N 56-360 Wheel without brake 125 mm
- 56-361 Wheel with brake 125 mm
- 56-387 Wheel with brake 75 mm
E 56-356 Locking clamp, handle
F 56-363 Knob for adjusting handle
B 56-364 Knob for adj. width of armrest plates
S 56-370-1 Hand control 2channel (raise/lower)/LA31
S 56-370 Hand control 2channel (raise/lower)/LA28
- 56-374-1 Power cable/LA31
56-374 Charger/LA28
V 56-345-1 Control box 220 V
19. Accessories
Part no. Description
56-334 Drip holder
56-335 Attachment for drip holder
56-336 Oxygen holder
56-337 Side support, adjustable
56-338 Drip rod complete with attachment
56-386 Footplate, Bure XL (plate)
56-389 Soft basket with attachment

BURE XL
DIRECTHEALTHCAREGROUP.COM
12
This product complies with the
requirements of the Medical Device
Regulation 2017/745
Visual Inspection
Medical Device Read the manual
Caution Product Code
Manufacturer information Batch Code
Type BF, according to the degree of
protection against electric shock
The device is intended for indoor use
WEEE Symbol
May not be discarded in domestic
waste
Class II Equipment
Duty Cycle:
2 min in active (ON) mode.
18 min in rest (OFF) mode.
20. Table of Symbols

Direct Healthcare Group Sverige AB
Torshamnsgatan 35,
SE-164 40 Kista, Sweden
Tel: [phone]
[email protected]
www.directhealthcaregroup.com
Medical Device Class I. The product complies with the re-
quirements of the Medical Devices Regulation 2017/745.
Medical Device Class I