EasyPro ETP05N Operation and maintenance manual

ETP10N
ETP05N
This submersible trash pump handles sand, solids, leaves, algae and
other debris up to
3
/
8
" x 1" in size. Ideal for waterfalls where algae and
leaves are a problem, recirculating systems where solids removal is
needed, dewatering applications where sand and sludge are being
pumped, or any other dirty or clean water application where a high
quality, continuous duty pump is needed. Pump includes a 2" FPT
discharge, 115v motor, 20' power cord and two year limited warranty.
Specications
• Automaticoverloadandthermalprotectionwithselfreset
• Aluminummotorhousing
• Tophousingsmadeofengineeringcompositewithglassberrein-
forcement, bottom housing is made of cast iron
• WearresistantTPUimpeller
• Highprecisionmechanicalshaftseals
ETP05N-2"outlet,400w,1/2HP,3600GPH,20'cable
ETP10N-2"outlet,750w,1HP,5700GPH,20'cable
Submersible Trash Pump
Instructions for Operation • Safety • Warranty
ETP05N • ETP10N
1

Installation
•Donotpaintcasingasoverheatingmayoccur
•Liftonlybyhandle-notbypowercable
•Donothangwaterpumpinwater
•Installonasolidatbaseinuprightposition
•Installproperoutletadapterforpipeorhose
•Dischargeendofpipeorhosemustbeabovewaterlevel
•Makesurethatpowercableplugandpoweroutletareawayfromwater,
water discharge pipe or hose
Operation
• Turnopowersupplyorcircuitbreakerbeforeconnectingpowercableplug
• Donotstartoperationwithpeoplestandingnearintakeoroutlet
• Donotoperatewhensuspendedinair
• Usepumponlyforcirculation,transferorremovalofwaterorwastewater
• Donotpumpoil,saltwaterorchemicalliquids
•Thispumpmuststaysubmergedentirelywhenoperating.Ifusedinaskimmer,the
debrisnetmustbekeptcleantoensureadequatewaterowtopump.Running
pump low on water will cause overheating and premature failure which is not cov-
ered under warranty.
Safety
•Usededicatedpoweroutletonly
•Sharingtheoutletwithotherequipmentmaycauseoverheatingandre
•Installinaccordancewithallapplicablesafetyregulations
• Installationtobeperformedbyqualiedelectrician
• Donotusewithoutpropergroundingorelectricalshockmayoccur
Power Cord
•Donotuseanextensioncord
• Neversubmergeconnectingpowercableinwater
• Donottamperwiththepowercord
• Donotuseadapterthatisnotgrounded
• Makesurepowercabledoesnotbecomebent,twisted,abradedorcut
• Donotallowpowercabletocomeincontactwithheatedsurface
• Damagedcablemaycauseelectricleakage,shockorre
2

Caution
• Donotallowdryoperation
• Donotallowforeignobjectstoenterintake
• Incaseofpoweroutage,turnopowerswitchtoavoiddamagewhenpower
resumes
• Ifexcessivevibrationoccursturnopowerimmediately
Protection System
The motor has a built in protection system which stops the pump when overheating
occurs,duetoexcessiveload.Loadcouldbecausedbycloggingatinletoroutlet
andwhenauctuationinthepowersupplyoccurs.
Water Level
• Neveroperatebelowminimumwaterlevelwhichis6"abovebaselevel(abouthalf
way submerged)
• Continuousoperationwaterlevelisatleast14"abovebaselevel(submerged)
• Operateforamaximumofthirtyminutesifwaterlevelisbetween6"and14"
Inspection
• Alwaysturnopowerandremovepoweroutletplugfrompoweroutletbefore
performing inspection
• Checkregularlyfordropinperformanceandremoveanycloggedmaterialfrom
inlet area, outlet hose and pipe
• Checkandtightennutsandboltsifrequired
• Checkwithdealerforadviceonotherrepairs
Pump Storage
• Whenthepumpisoutofuseforanextendedperiod-washit,dryitandstore
indoors
• Donotleavepumpoutdoorsinfreezingconditions
• Ifthepumpisleftinwaterbutnotoperatingregularly,testrunitatleastoncea
week
Disassembly and Reassembly
• Donotattempttodisassemblepumpduringwarrantyperiod
• Ifimpellerreplacementisrequired,contactdealerforservice
3

8018•10/19
800-448-3873
Grant,Michigan
www.easypro.com
[email protected]
EasyPro Pond Products Limited Warranty
EasyProPondProducts(“EasyPro”)warrantstothepurchaserthatthisproduct("Product")
will be free from any mechanical or material defects for a period of two years from the
date of purchase. Impellers are considered a wearable item and are not covered by this
limited warranty. This warranty only covers properly installed and maintained Products
soldbyauthorizedEasyProSellerswhoaresubjecttoandfollowEasyPro’squalitycontrol
standards. Please note that because EasyPro is unable to control the quality of Products sold
by unauthorized sellers, unless otherwise prohibited by law, this warranty does not cover
Products purchased from unauthorized sellers.
Thiswarrantydoesnotcovernormalwearandtear,noranydeteriorationsueredthrough
overloading,improperuse,negligence,improperinstallation,actsofGodoraccident.
Similarly,anymodicationmadebythepurchasertotheProductwillcausethewarrantyto
be null and void. This warranty does not cover any cost associated with the installation or
removaloftheProductsubjecttoawarrantyclaim.
Allreturneditemswillbeinspectedtodeterminecauseoffailurebeforeawarrantyclaimis
approved.Theexclusiveremediesprovidedhereundershall,uponEasyPro’sinspectionand
option, be either repair or replacement of the Product or parts covered under this warranty.
Making a Claim: AReturnAuthorization(“RA”)numbermustrstbeobtainedbycallingEasyProat
800-448-3873 or via email at [email protected].
Itisthepurchaser’sresponsibilitytopaythereturnshippingcharges.BesuretoincludetheRA
number,originalreceipt(intheformofaninvoiceorsalesreceipt),yourname,yourreturnaddress
andyourphonenumberinsideofthepackage.Nowarrantyclaimswillbehonoredwithouttheoriginal
receiptthatshowsthatyourpurchasewasmadefromanAuthorizedEasyProSeller.
Ensuretheproductisproperlypackagedandinsuredforthereplacementvalue.Damagedueto
improperpackagingistheresponsibilityofthesender.
ALLOTHEREXPRESSORIMPLIEDWARRANTIESINCLUDINGMERCHANTABILITYOFFITNESS
FORAPARTICULARPURPOSEAREHEREBYLIMITEDINDURATIONTOTHEDURATIONOFTHE
WARRANTYASDESCRIBEDABOVE.SomeStatesdonotallowlimitationsonhowlonganimplied
warranty lasts, so the above limitations may not apply to you.
EasyPro shall not be held liable for any damages caused by defective components or materials of this
Product; or for loss incurred because of the interruption of service; or any consequential/incidental
damagesandexpensesarisingfromtheproduction,sale,useormisuseofthisProduct.SomeStates
do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation
or exclusion may not apply to you.
EasyProshallnotbeheldliableforanylossofsh,plantsoranyotherlivestockasaresultofanyfailure
ordefectofthisProduct.Thiswarrantygivesyouspeciclegalrights,andyoumayalsohaveother
rightsthatvaryfromStatetoState.