Furniture of America Prismo CMBK608TYW User manual

EASY
The Assembly Rating is a 5-point system that
shows the degree of effort needed in
assembling a specific product (with 1 being
easy and 5 being difficult). For some
products, two persons are recommended.
Allen Wrench (Included)
Assembly Instructions
Tools Required for Assembly:
Page 1 of 10
DIFFICULT
ASSEMBLY RATING
CM-BK608T
2 PERSONS RECOMMENDED
Phillips Screwdriver (Not Included)

Page 2 of 10

#4 x 1 pc
Lower Rear Side Rail
Parts List
#1 x 2 pcs
Lower End G/Rail
#3 x 1 pc
Upper Rt. End G/Rail
#7 x 1 pc
Upper Front Side Rail
Before you begin, please read Page 2
for “Assembly and Care Advice” AND
Page 10 for “Safety Warnings”.
And remember, do not tighten until
each step is completed or instructed.
MD
Page 3 of 10
#9 x 2 pcs
Front Guardrail
#6 x 1 pc
Upper Rear Side Rail
#10 x 2 pcs
Guardrail Support
#2 x 1 pc
Upper Lt. End G/Rail
#5 x 1 pc
Lower Front Side Rail
#8 x 2 pcs
Rear Guardrail
#11 x 1 pc
Right Ladder Rail
#14 x 2 sets
Twin Slat Kit
#13 x 4 pcs
Ladder Rung
#12 x 1 pc
Left Ladder Rail

#D x 6 pcs
Bolt 1/4”x1-9/16”
Hardware List
#A x 22 pcs
Bolt 1/4”x4-1/4”
#C x 6 pcs
Bolt 1/4”x1-3/16”
#I x 1 pc
Allen Wrench
Page 4 of 10
#F x 16 pcs
Screw 3/16”x1-3/16”
#B x 22 pcs
Barrel Nut
#E x 8 pcs
Screw 5/16”x2”
#H x 4 pcs
Metal Dowel 90mm
Due to the size and/or weight of this product, it
is highly recommended that the assembly
should be done near the area of its intended
location. Make sure you have enough space to
move around during the assembly. ALWAYS
have at least two people to help with
transporting and assembling the product to
avoid any potential injury and/or damage.
#G x 12 pcs
Wood Dowel 40mm
Note: Right and left are
determined by facing the
ladder of the bunk bed in its
upright position.

Page 5 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#A x 8 pcs
#B x 8 pcs
#A x 12 pcs
#B x 12 pcs
#G x 8 pcs

Page 6 of 10
Turn right (clockwise) to tighten
#A x 2 pcs
#B x 2 pcs
#C x 6 pcs
#G x 4 pcs
#H x 4 pcs

Page 7 of 10
Turn right (clockwise) to tighten
#E x 8 pcs

Page 8 of 10
Turn right (clockwise) to tighten
Turn right (clockwise) to tighten
#D x 6 pcs
#F x 8 pcs

Page 9 of 10
Turn right (clockwise) to tighten
ASSEMBLY IS COMPLETED
Safety is ALWAYS the main priority. Please take the time to
inspect the assembly and FULLY tighten all bolts/screws.
Read and follow the
information on the
WARNINGS shown on the end
structure of the upper bunk
and on the carton. Do not
remove warning label from the
bed. Keep these instructions
for future reference.
#F x 8 pcs
Must use Bunkie mattress or
Bunkie board (sold separately).

Safety Warnings for Bunk Beds
1. Read and follow the information on the WARNINGS shown on the end
structure
of
the
upper
unk and on the carton.
2. Do not remove
warning
la el from the ed.
3. Keep these instructions for future reference.
4. IMPORTANT: Must use Bunkie mattress or Bunkie board. The proper
sizes for the UPPER/LOWER TWIN-SIZE Bunkie mattress or unkie oard
should e 74'' - 75''
long
and 38-1/2'' wide with no more than 6''
5. Surface of mattress must e at least 5 inches (127mm) BELOW the upper
edge of guardrails.
6. The M XIMUM weight capacity for the upper unk is not to exceed 150 l s.
7. Do not allow children under 6 years of age to use the upper unk.
8.
Periodically
check and ensure that the
guardrails,
ladder, handle and
other
components
are in
their
proper
position,
free from
damage,
and that all
connectors are tightened and secured.
9. DO NOT allow horseplay, rough playing or jumping on the eds and do not
allow playing or hiding under the eds.
10.
Always
use the
ladder
for
entering
or
leaving
the
upper
unk.
11. Do not use su stitute
parts.
Contact the manufacturer
or
dealer
for
replacement parts.
12. Use of a nightlight may provide added safety precaution for a person using
the upper unk.
13.
Always
use the
guardrails
on oth sides
of
the
upper
unk.
14.
If
the unk ed will e
placed
next to a wall, the
guardrail
that runs the full
length of the ed should e placed against the wall to prevent entrapment
etween the ed and the wall.
15. The use of water or sleep flotation mattresses is prohi ited.
16. No more than one
person
is allowed on the
upper
unk at all times
W RNING:
STR NGUL TION H Z RD
Never attach or hang o jects to any part of the unk ed
that are not designed for use with the ed. O jects such as
hanger, hook, elt, ag, rope, string, etc. should not e used
on or around the unk ed.
Safety Warnings for Bunk Beds
!
37-1/2'' -
Page 10 of 10