IEI Technology ECN-360A-HM65 User manual

ECN-360A-HM65 Embedded System
Page i
IEITechnology Corp.
User Manual
,
MODEL:
ECN-360A-HM65
Embedded System with Intel®Celeron®dualcore 847E Processor,
Dual HDMI, VGA, GbE, Two USB 3.0, Two USB 2.0,
Three COMand RoHS Compliant
Rev. 1.00 – 25 June 2013

ECN-360A-HM65 Embedded System
Page ii
Revision
Date Version Changes
25 June 2013 1.00 Initial release

ECN-360A-HM65 Embedded System
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

ECN-360A-HM65 Embedded System
Page iv
Ta b le ofContents
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 MODEL VARIATIONS ................................................................................................... 2
1.3 FEATURES................................................................................................................... 2
1.4 TECHNICAL SPECIFICATIONS ...................................................................................... 3
1.5 FRONT PANEL............................................................................................................. 4
1.6 REAR PANEL............................................................................................................... 5
1.7 DIMENSIONS............................................................................................................... 7
2 UNPACKING................................................................................................................. 8
2.1ANTI-STATIC PRECAUTIONS........................................................................................ 9
2.2 UNPACKING PRECAUTIONS......................................................................................... 9
2.3 UNPACKING CHECKLIST ........................................................................................... 10
3 INSTALLATION ......................................................................................................... 12
3.1 INSTALLATION PRECAUTIONS................................................................................... 13
3.2 INSTALLATION AND CONFIGURATION STEPS ............................................................. 13
3.3 HARD DISK DRIVE (HDD) INSTALLATION................................................................ 13
3.4 WI-FI ANTENNA INSTALLATION (WIRELESS MODEL ONLY)..................................... 15
3.5 MOUNTING BRACKET INSTALLATION ....................................................................... 16
3.6 EXTERNAL PERIPHERAL INTERFACE CONNECTORS................................................... 17
3.6.1 Audio Connection............................................................................................. 17
3.6.2 HDMI Device Connection................................................................................ 18
3.6.3 LAN Connection............................................................................................... 19
3.6.4 DB-9 Serial Port Connection........................................................................... 20
3.6.5 USB Device Connection................................................................................... 21
3.6.6 VGA Monitor Connection ................................................................................ 22
4 SYSTEM MOTHERBOARD ..................................................................................... 24
4.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 25
4.1.1 Layout .............................................................................................................. 25

ECN-360A-HM65 Embedded System
Page v
4.1.2 Internal Peripheral Connectors....................................................................... 26
4.1.3 External Interface Panel Connectors............................................................... 27
4.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 27
4.2.1 Audio Connector.............................................................................................. 27
4.2.2 Battery Connector............................................................................................ 28
4.2.3 Digital Input/Output (DIO) Connector............................................................ 29
4.2.4 Debug Connector............................................................................................. 30
4.2.5 Fan Connector (CPU)...................................................................................... 31
4.2.6 Fan Connector (System) .................................................................................. 31
4.2.7 Front Panel Connector .................................................................................... 32
4.2.8 LVDS Backlight Inverter Connector................................................................ 33
4.2.9 Keyboard/Mouse Connector ............................................................................ 34
4.2.10 LVDS LCD Connector ................................................................................... 35
4.2.11 PCIe Mini Card Slot....................................................................................... 36
4.2.12 Power Connector ........................................................................................... 38
4.2.13 SATA 6Gb/s Connector................................................................................... 39
4.2.14 SATA Power Connectors................................................................................ 40
4.2.15 Serial Port Connectors (COM 1 and COM 2)............................................... 40
4.2.16 Serial Port Connector (COM3) ..................................................................... 41
4.2.17 SMBus Connector .......................................................................................... 42
4.2.18 SPI Flash Connector...................................................................................... 43
4.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 44
4.3.1 Ethernet Connectors ........................................................................................ 45
4.3.2 HDMI Connectors............................................................................................ 46
4.3.3 USB 2.0 Connectors......................................................................................... 46
4.3.4 USB 3.0 Connectors......................................................................................... 47
4.3.5 VGA Connector................................................................................................ 48
4.4 JUMPER SETTINGS .................................................................................................... 49
4.4.1 AT/ATX Power Mode Select Jumper................................................................ 49
4.4.2 Clear CMOS Jumper........................................................................................ 50
4.4.3 LVDS Voltage Selection Jumper....................................................................... 51
4.4.4 LVDS Panel Resolution Selection Jumper....................................................... 52
4.4.5 TPM Setting Jumper......................................................................................... 53
4.4.6 Flash Descriptor Security Override Jumper.................................................... 54

ECN-360A-HM65 Embedded System
Page vi
5 BIOS.............................................................................................................................. 55
5.1 INTRODUCTION......................................................................................................... 56
5.1.1 Starting Setup................................................................................................... 56
5.1.2 Using Setup...................................................................................................... 56
5.1.3 Getting Help..................................................................................................... 57
5.1.4 Unable to Reboot After Configuration Changes.............................................. 57
5.1.5 BIOS Menu Bar................................................................................................ 57
5.2 MAIN........................................................................................................................ 58
5.3ADVANCED............................................................................................................... 59
5.3.1 ACPI Settings................................................................................................... 59
5.3.2 RTC Wake Settings........................................................................................... 60
5.3.3 CPU Configuration.......................................................................................... 62
5.3.4 SATA Configuration ......................................................................................... 63
5.3.5 USB Configuration........................................................................................... 64
5.3.6 Super IO Configuration ................................................................................... 65
5.3.6.1 Serial Port n Configuration....................................................................... 65
5.3.7 H/W Monitor.................................................................................................... 68
5.3.7.1 Smart Fan Mode Configuration................................................................ 69
5.3.8 Serial Port Console Redirection ...................................................................... 70
5.3.8.1 Console Redirection Settings.................................................................... 71
5.4 IEI FEATURE ............................................................................................................. 74
5.5 CHIPSET ................................................................................................................... 74
5.5.1 NorthBridge Configuration.............................................................................. 76
5.5.1.1 Graphics Configuration............................................................................. 77
5.5.2 Southbridge Configuration .............................................................................. 79
5.6 BOOT........................................................................................................................ 81
5.7 SECURITY................................................................................................................. 83
5.8 EXIT......................................................................................................................... 84
ASAFETY PRECAUTIONS......................................................................................... 86
A.1 SAFETY PRECAUTIONS ............................................................................................ 87
A.1.1 General Safety Precautions............................................................................. 87
A.1.2 Anti-static Precautions .................................................................................... 88
A.1.3 Product Disposal............................................................................................. 89
A.2 MAINTENANCE AND CLEANING PRECAUTIONS........................................................ 89

ECN-360A-HM65 Embedded System
Page vii
A.2.1 Maintenance and Cleaning.............................................................................. 89
A.2.2 Cleaning Tools................................................................................................. 90
B BIOS MENU OPTIONS............................................................................................. 91
C ONE KEY RECOVERY............................................................................................. 94
C.1 ONE KEY RECOVERY INTRODUCTION ...................................................................... 95
C.1.1 System Requirement ........................................................................................ 96
C.1.2 Supported Operating System........................................................................... 97
C.2 SETUP PROCEDURE FOR WINDOWS.......................................................................... 98
C.2.1 Hardware and BIOS Setup.............................................................................. 99
C.2.2 Create Partitions............................................................................................. 99
C.2.3 Install Operating System, Drivers and Applications..................................... 103
C.2.4 Building the Recovery Partition.................................................................... 104
C.2.5 Create Factory Default Image ...................................................................... 106
C.3AUTO RECOVERY SETUP PROCEDURE.....................................................................111
C.4 SETUP PROCEDURE FOR LINUX...............................................................................115
C.5 RECOVERY TOOL FUNCTIONS .................................................................................119
C.5.1 Factory Restore............................................................................................. 120
C.5.2 Backup System............................................................................................... 121
C.5.3 Restore Your Last Backup.............................................................................. 122
C.5.4 Manual .......................................................................................................... 123
C.6 RESTORE SYSTEMS FROM A LINUX SERVER THROUGH LAN.................................. 124
C.6.1 Configure DHCP Server Settings.................................................................. 125
C.6.2 Configure TFTP Settings............................................................................... 126
C.6.3 Configure One Key Recovery Server Settings............................................... 127
C.6.4 Start the DHCP, TFTP and HTTP................................................................. 128
C.6.5 Create Shared Directory................................................................................ 128
C.6.6 Setup a Client System for Auto Recovery...................................................... 129
C.7 OTHER INFORMATION............................................................................................ 132
C.7.1 Using AHCI Mode or ALi M5283 / VIA VT6421A Controller ...................... 132
C.7.2 System Memory Requirement........................................................................ 134
D WATCHDOGTIMER .............................................................................................. 135
E HAZARDOUS MATERIALS DISCLOSURE ....................................................... 138
E.1 HAZARDOUS MATERIALS DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS

ECN-360A-HM65 Embedded System
Page viii
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY..................................... 139

ECN-360A-HM65 Embedded System
Page ix
List of Figures
Figure 1-1: ECN-360A-HM65..........................................................................................................2
Figure 1-2: ECN-360A-HM65 Front Panel.....................................................................................5
Figure 1-3: ECN-360A-HM65 Rear Panel ......................................................................................6
Figure 1-4: Physical Dimensions (mm)........................................................................................7
Figure 3-1: Retention Screws Removal......................................................................................14
Figure 3-2: HDD Bracket ..............................................................................................................14
Figure 3-3: HDD Retention Screws .............................................................................................15
Figure 3-4: Wi-Fi Antenna Installation........................................................................................16
Figure 3-5: Mounting Bracket Retention Screws ......................................................................16
Figure 3-6: Audio Connector.......................................................................................................18
Figure 3-7: HDMI Connection......................................................................................................19
Figure 3-8: LAN Connection........................................................................................................20
Figure 3-9: DB-9 Serial Port Connector......................................................................................21
Figure 3-10: USB Device Connection.........................................................................................22
Figure 3-11: VGA Connector .......................................................................................................23
Figure 4-1: Connectors and Jumpers Locations.......................................................................25
Figure 4-2: Audio Connector Location.......................................................................................28
Figure 4-3: Battery Connector Location.....................................................................................28
Figure 4-4: DIO Connector Location...........................................................................................29
Figure 4-5: EC Debug Connector Location................................................................................30
Figure 4-6: CPU Fan Connector Location..................................................................................31
Figure 4-7: System Fan Connector Location.............................................................................32
Figure 4-8: Front Panel Connector Location .............................................................................33
Figure 4-9: Backlight Inverter Connector Location...................................................................34
Figure 4-10: Keyboard/Mouse Connector Location..................................................................35
Figure 4-11: LVDS Connector Location......................................................................................36
Figure 4-12: PCIe Mini Card Slot Location.................................................................................37
Figure 4-13: CPU Power Connector Location............................................................................38
Figure 4-14: SATA Drive Connector Locations .........................................................................39
Figure 4-15: SATA Power Connector Locations .......................................................................40

ECN-360A-HM65 Embedded System
Page x
Figure 4-16: COM Connector Locations.....................................................................................41
Figure 4-17: Serial Port Connector Location.............................................................................42
Figure 4-18: SMBus Connector Location...................................................................................43
Figure 4-19: SPI Flash Connector Location...............................................................................44
Figure 4-20: External Peripheral Interface Connectors............................................................44
Figure 4-21: RJ-45 Ethernet Connector......................................................................................45
Figure 4-22: HDMI Connector......................................................................................................46
Figure 4-23: VGA Connector .......................................................................................................48
Figure 4-24: AT/ATX Power Mode Jumper Location.................................................................50
Figure 4-25: Clear CMOS Jumper ...............................................................................................51
Figure 4-26: LVDS Voltage Selection Jumper Location ...........................................................52
Figure 4-27: LVDS Screen Resolution Jumper Locations........................................................53
Figure 4-28: TPM Setting Jumper Location ...............................................................................54
Figure 4-29: Flash Descriptor Security Override Jumper Location ........................................54
Figure C-1: IEI One Key Recovery Tool Menu ...........................................................................95
Figure C-2: Launching the Recovery Tool...............................................................................100
Figure C-3: Recovery Tool Setup Menu ...................................................................................100
Figure C-4: Command Prompt ..................................................................................................101
Figure C-5: Partition Creation Commands...............................................................................102
Figure C-6: Launching the Recovery Tool...............................................................................104
Figure C-7: Manual Recovery Environment for Windows......................................................104
Figure C-8: Building the Recovery Partition............................................................................105
Figure C-9: Press Any Key to Continue ...................................................................................105
Figure C-10: Press F3 to Boot into Recovery Mode................................................................106
Figure C-11: Recovery Tool Menu ............................................................................................106
Figure C-12: About Symantec Ghost Window.........................................................................107
Figure C-13: Symantec Ghost Path ..........................................................................................107
Figure C-14: Select a Local Source Drive ................................................................................108
Figure C-15: Select a Source Partition from Basic Drive .......................................................108
Figure C-16: File Name to Copy Image to ................................................................................109
Figure C-17: Compress Image...................................................................................................109
Figure C-18: Image Creation Confirmation..............................................................................110
Figure C-19: Image Creation Complete....................................................................................110
Figure C-20: Image Creation Complete....................................................................................110
Figure C-21: Press Any Key to Continue .................................................................................111

ECN-360A-HM65 Embedded System
Page xi
Figure C-22: Auto Recovery Utility...........................................................................................112
Figure C-23: Launching the Recovery Tool.............................................................................112
Figure C-24: Auto Recovery Environment for Windows ........................................................112
Figure C-25: Building the Auto Recovery Partition.................................................................113
Figure C-26: Factory Default Image Confirmation..................................................................113
Figure C-27: Image Creation Complete....................................................................................114
Figure C-28: Press any key to continue...................................................................................114
Figure C-29: Partitions for Linux...............................................................................................116
Figure C-30: Manual Recovery Environment for Linux ..........................................................117
Figure C-31: Access menu.lst in Linux (Text Mode)...............................................................118
Figure C-32: Recovery Tool Menu ............................................................................................118
Figure C-33: Recovery Tool Main Menu...................................................................................119
Figure C-34: Restore Factory Default.......................................................................................120
Figure C-35: Recovery Complete Window...............................................................................121
Figure C-36: Backup System.....................................................................................................121
Figure C-37: System Backup Complete Window ....................................................................122
Figure C-38: Restore Backup ....................................................................................................122
Figure C-39: Restore System Backup Complete Window......................................................123
Figure C-40: Symantec Ghost Window ....................................................................................123

ECN-360A-HM65 Embedded System
Page xii
List of Tables
Table 1-1: Model Variations...........................................................................................................2
Table 1-2: Technical Specifications..............................................................................................4
Table 2-1: Package List Contents...............................................................................................11
Table 4-1: Peripheral Interface Connectors...............................................................................26
Table 4-2: Rear Panel Connectors ..............................................................................................27
Table 4-3: Audio Connector Pinouts ..........................................................................................28
Table 4-4: Battery Connector Pinouts........................................................................................29
Table 4-5: DIO Connector Connector Pinouts...........................................................................29
Table 4-6: Debug Connector Pinouts .........................................................................................30
Table 4-7: CPU Fan Connector Pinouts.....................................................................................31
Table 4-8: System Fan Connector Pinouts................................................................................32
Table 4-9: Front Panel Connector Pinouts.................................................................................33
Table 4-10: Backlight Inverter Connector Pinouts....................................................................34
Table 4-11: Keyboard/Mouse Connector Pinouts .....................................................................35
Table 4-12: LVDS Connector Pinouts.........................................................................................36
Table 4-13: PCIe Mini Card Slot Pinouts ....................................................................................38
Table 4-14: CPU Power Connector Pinouts...............................................................................39
Table 4-15: SATA Drive Connector Pinouts...............................................................................39
Table 4-16: SATA Power Connector Pinouts.............................................................................40
Table 4-17: COM Connector Pinouts..........................................................................................41
Table 4-18: Serial Port Connector Pinouts ................................................................................42
Table 4-19: DB-9 RS-422/485 Pinouts.........................................................................................42
Table 4-20: SMBus Connector Pinouts ......................................................................................43
Table 4-21: SPI Flash Connector.................................................................................................44
Table 4-22: LAN Pinouts ..............................................................................................................45
Table 4-23: RJ-45 Ethernet Connector LEDs.............................................................................45
Table 4-24: HDMI Connector Pinouts.........................................................................................46
Table 4-25: USB 2.0 Port Pinouts................................................................................................47
Table 4-26: USB 3.0 Port Pinouts................................................................................................47
Table 4-27: VGA Connector Pinouts...........................................................................................48

ECN-360A-HM65 Embedded System
Page xiii
Table 4-28: Jumpers.....................................................................................................................49
Table 4-29: AT/ATX Power Mode Jumper Settings ...................................................................50
Table 4-30: Clear CMOS Jumper Settings..................................................................................51
Table 4-31: LVDS Voltage Selection Jumper Settings..............................................................52
Table 4-32: LVDS Screen Resolution Jumper Settings............................................................53
Table 4-33: TPM Setting Jumper Settings..................................................................................53
Table 4-34: Flash Descriptor Security Override Jumper Settings...........................................54
Table 5-1: BIOS Navigation Keys................................................................................................57

ECN-360A-HM65 Embedded System
Page 1
Chapter
1
1Introduction

ECN-360A-HM65 Embedded System
Page 2
1.1 Overview
Figure 1-1: ECN-360A-HM65
The ECN-360A-HM65 embedded system is a fanless system with two HDMI ports and
one VGA port for dual display. It is powered by Intel® Celeron® dual core 847E 1.1GHz
processor and supports two 204-pin DDR3 SDRAM SO-DIMM modules up to 8 GB (4GB
memory preinstalled). The ECN-360A-HM65 supports a 2.5” SATA HDD with up to 6 Gb/s
data transfer rate. Three serial ports, two USB 3.0 ports and two USB 2.0 ports ensure
simplified connectivity to a variety of external peripheral devices.
1.2 ModelVariations
The model variations of the ECN-360A-HM65 series are listed below.
Models Wireless
ECN-360A-HM65/4G-R10 N/A
ECN-360AW-HM65/4G-R10 802.11b/g/n
Table 1-1: Model Variations
1.3 Features
The ECN-360A-HM65 features are listed below:
On-board CPU: Intel Celeron® 847E dual core 1.1GHz
Rich video output solution: 2 x HDMI + 1 x VGA
Ruggedized embedded computer: support -10°C~60°C with air flow (SSD)

ECN-360A-HM65 Embedded System
Page 3
1.4 TechnicalSpecifications
The ECN-360A-HM65 technical specifications are listed in Table 1-1.
Chassis
Color Black
Dimens ion ( WxDxH) 255 x 130 x 63
System Fan Fanless
Chassis Construction SECC
Motherboard
Motherboard model NANO-HM651-847E
CPU Intel® Celeron® dual core 847E 1.1GHz
Chipset Intel® HM65
System Memory 2 x 204-pin DDR3 SDRAM SO-DIMM (System Max : 8GB)
Pre-installed DDR3 4GB memory
Ethernet 2 x Realtek RTL8111E PCIe GbE controller
Storage
Hard Drive 1 x 2.5'' SATA HDD Bay
I/O interfaces
USB 2 x USB 3.0
2 x USB 2.0
LAN 2 x RJ-45 LAN
RS-232 2 x RS-232 (DB-9 connector)
RS-422/485 1 x RS-422/485 (DB-9 connector)
Digital I/O 1 x DB-9 ; 8 bit Digital I/O , 4 bit input / 4 bit output
Display 1 x VGA
2 x HDMI
Resolution VGA: Up to 2048 x 1536 @ 75Hz
HDMI: Up to 1920 x 1200 @ 60Hz

ECN-360A-HM65 Embedded System
Page 4
Audio 1 x Line-out
Wireless 1 x 802.11 b/g/n ( optional)
Expansions
PCIe Min i 1 x Full size ( reserved for Wi-Fi )
Power
Power Input 9~36V DC ( IDD-936260A)
Power 1 : DC Jack
Power 2: Terminal block
Power Consumption [email protected]A
(Intel® Celeron® single core 827E 1.4GHz with 4GB DDR3 memory)
Reliability
Mounting Wall mount ; VESA 100
Operating Temperature -10°C~55°C with air flow (SSD)
0°C~45°C with air flow (HDD)
Storage Temperature -20°C ~ 60°C
Operating Shock Half-sine wave shock 3G; 11ms; 3 shocks per axis
Operating Vibration MIL-STD-810F 514.5C-1
Weight (Net/Gross) 2.2 kg / 3 kg
Safety /EMC CE / FCC Class A
OS
Supported OS Microsoft® WES7E
Microsoft® Windows® XP Embedded
Table 1-2: Technical Specifications
1.5 Front Panel
The front panel of the ECN-360A-HM65 has the following features (Figure 1-2):
1 x HDD LED
1 x Power button

ECN-360A-HM65 Embedded System
Page 5
Figure 1-2: ECN-360A-HM65 Front Panel
1.6 Rear Panel
The rear panel of the ECN-360A-HM65 has the following features (Figure 1-3):
1 x DIO connector
1 x Line-out
2 x HDMI connectors
1 x 9 V ~ 36 V power jack
1 x Reset button
2 x RJ-45 LAN connectors
2 x RS-232 (DB-9 connector)
1 x RS-422/485 (DB-9 connector)
1 x 9 V ~ 36 V terminal block
2 x USB 3.0 connectors
2 x USB 2.0 connectors
1 x VGA connector
2 x WiFi antenna connectors

ECN-360A-HM65 Embedded System
Page 6
Figure 1-3: ECN-360A-HM65 Rear Panel

ECN-360A-HM65 Embedded System
Page 7
1.7 Dimensions
The physical dimensions are shown below:
Figure 1-4: Physical Dimensions (mm)