IEI Technology PPC-F06B-BT User manual

PPC-F06B-BT Panel PC
Page I
User Manual
PPC-F06B-BT Panel PC
MODEL:
PPC-F06B-BT
Industrial Panel PC with Intel® Celeron® Processor N2807,
Touchscreen, PCIe Mini, USB 3.0, USB 2.0, RS-232,
RS-422/485, Dual PCIe GbE, 9 V ~ 30 V DC-in
IP 65 Compliant Front Panel and RoHS Compliant
Rev. 1.03 – December 13, 2017

PPC-F06B-BT Panel PC
Page II
Revision
Date Version Changes
December 13, 2017 1.03 Updated Section 1.8: Specifications
Updated Section 2.3: Optional Items
August 8, 2016 1.02 Added Section 3.8: Wireless LAN Module Installation
(Optional)
June 1, 2016 1.01 Updated I/O panel photos
Updated Chapter 4: BIOS Setup
Added Section 3.15: OS Installation
June 23, 2015 1.00 Initial release

PPC-F06B-BT Panel PC
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

PPC-F06B-BT Panel PC
Page IV
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

PPC-F06B-BT Panel PC
Page V
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 FEATURES .................................................................................................................. 3
1.3 FRONT PANEL............................................................................................................. 3
1.4 REAR PANEL............................................................................................................... 4
1.5 SIDE PANELS .............................................................................................................. 4
1.6 BOTTOM PANEL.......................................................................................................... 5
1.7 DIMENSIONS............................................................................................................... 6
1.8 SPECIFICATIONS ......................................................................................................... 7
2 UNPACKING................................................................................................................. 9
2.1 UNPACKING.............................................................................................................. 10
2.2 PACKING LIST........................................................................................................... 10
2.3 OPTIONAL ITEMS...................................................................................................... 12
3 INSTALLATION ......................................................................................................... 13
3.1ANTI-STATIC PRECAUTIONS...................................................................................... 14
3.2 INSTALLATION PRECAUTIONS................................................................................... 14
3.3 PREINSTALLED COMPONENTS................................................................................... 15
3.4 INSTALLATION AND CONFIGURATION STEPS ............................................................. 15
3.5 REMOVING THE BACK COVER.................................................................................. 16
3.6 SATA DOM INSTALLATION...................................................................................... 16
3.7 MSATA MODULE INSTALLATION.............................................................................. 18
3.8 WIRELESS LAN MODULE INSTALLATION (OPTIONAL)............................................. 19
3.9 SERIAL PORT CONFIGURATION AND CONNECTION.................................................... 24
3.9.1 RS-232 Serial Port Pinouts (COM1) ............................................................... 24
3.9.2 RS-232 Serial Port Pin 9 Selection.................................................................. 24
3.9.3 RS-422/485 Serial Port Pinouts (COM2)........................................................ 25
3.10AT/ATX MODE SELECTION.................................................................................... 26
3.10.1 AT Power Mode.............................................................................................. 26
3.10.2 ATX Power Mode........................................................................................... 26

PPC-F06B-BT Panel PC
Page VI
3.11 MOUNTING THE SYSTEM ........................................................................................ 27
3.11.1 Wall Mounting................................................................................................ 27
3.11.2 Panel Mounting.............................................................................................. 29
3.11.3 Rack Mounting ............................................................................................... 31
3.11.4 Arm Mounting ................................................................................................ 33
3.11.5 Stand Mounting .............................................................................................. 34
3.12 POWERING ON THE SYSTEM................................................................................... 35
3.13 RESET THE SYSTEM................................................................................................ 36
3.14 CLEAR CMOS........................................................................................................ 36
3.15 OS INSTALLATION .................................................................................................. 37
3.16 DRIVER INSTALLATION........................................................................................... 37
3.16.1 Keypad AP...................................................................................................... 38
3.17 SYSTEM MAINTENANCE ......................................................................................... 39
4 BIOS SETUP................................................................................................................ 40
4.1 INTRODUCTION......................................................................................................... 41
4.1.1 Starting Setup................................................................................................... 41
4.1.2 Using Setup...................................................................................................... 41
4.1.3 Getting Help..................................................................................................... 42
4.1.4 Unable to Reboot after Configuration Changes.............................................. 42
4.1.5 BIOS Menu Bar................................................................................................ 43
4.2 MAIN........................................................................................................................ 43
4.3ADVANCED............................................................................................................... 45
4.3.1 ACPI Settings................................................................................................... 46
4.3.2 F81866 Super IO Configuration...................................................................... 47
4.3.2.1 Serial Port n Configuration....................................................................... 48
4.3.3 F81866 H/W Monitor....................................................................................... 50
4.3.4 RTC Wake Settings........................................................................................... 51
4.3.5 Serial Port Console Redirection ...................................................................... 52
4.3.6 IEI Feature....................................................................................................... 53
4.3.7 CPU Configuration.......................................................................................... 54
4.3.8 IDE Configuration........................................................................................... 56
4.3.9 USB Configuration........................................................................................... 57
4.4 CHIPSET ................................................................................................................... 58
4.4.1 North Bridge Configuration............................................................................. 59

PPC-F06B-BT Panel PC
Page VII
4.4.1.1 Internal IGD Configuration....................................................................... 59
4.4.2 South Bridge Configuration............................................................................. 61
4.5 SECURITY................................................................................................................. 62
4.6 BOOT........................................................................................................................ 63
4.7 SAVE &EXIT............................................................................................................ 66
5 INTERFACE CONNECTORS................................................................................... 68
5.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 69
5.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 70
5.2.1 Audio Connector (AUDIO1)............................................................................ 71
5.2.2 Battery Connector (BAT2) ............................................................................... 71
5.2.3 Inverter Connector (INV_CN1) ....................................................................... 72
5.2.4 LCD Connector (PANEL1)............................................................................... 72
5.2.5 MCU Connector (JSPI2).................................................................................. 73
5.2.6 PCIe Mini Connector (M_PCIE1)................................................................... 73
5.2.7 Power Input Connector (CN1)......................................................................... 74
5.2.8 Power LED Connector (PW_LED1)................................................................ 74
5.2.9 SATA DOM Connector (SATA1)....................................................................... 74
5.2.10 SATA Power Connector (SATA_PWR1)......................................................... 75
5.2.11 Serial Port Connector, RS-422/485 (COM2) ................................................. 75
5.2.12 SPI Flash Connector (JSPI1)......................................................................... 75
5.2.13 Touch Panel Connector (TOUCH1)............................................................... 76
5.2.14 USB 2.0 Connector (TOUCH_USB1)............................................................ 76
5.2.15 USB 2.0 Connector (TOUCH_USB2)............................................................ 76
5.2.16 VGA Connector (VGA_CON1) ...................................................................... 77
5.3 EXTERNAL INTERFACE PANEL CONNECTORS............................................................ 77
5.3.1 Ethernet Connectors (LAN1 & LAN2)............................................................. 78
5.3.2 Power Connector (CN2) ............................................................................... 78
5.3.3 RS-232 Serial Port (COM1)............................................................................. 78
5.3.4 USB 2.0 Connectors (USB1)............................................................................ 79
5.3.5 USB 3.0 Connectors (USB_CON1).................................................................. 79
A REGULATORY COMPLIANCE.............................................................................. 80
B BIOS CONFIGURATION OPTIONS....................................................................... 86
B.1 BIOS CONFIGURATION OPTIONS ............................................................................. 87

PPC-F06B-BT Panel PC
Page VIII
C SAFETY PRECAUTIONS......................................................................................... 89
C.1 SAFETY PRECAUTIONS............................................................................................. 90
C.1.1 General Safety Precautions............................................................................. 90
C.1.2 Anti-static Precautions.................................................................................... 91
C.1.3 Product Disposal............................................................................................. 92
C.2 MAINTENANCE AND CLEANING PRECAUTIONS ........................................................ 93
C.2.1 Maintenance and Cleaning ............................................................................. 93
C.2.2 Cleaning Tools................................................................................................. 93
D WATCHDOG TIMER ................................................................................................ 95
E HAZARDOUS MATERIALS DISCLOSURE ......................................................... 98

PPC-F06B-BT Panel PC
Page IX
List of Figures
Figure 1-1: PPC-F06B-BT Series Panel PC ..................................................................................2
Figure 1-2: Front View....................................................................................................................3
Figure 1-3: Rear View.....................................................................................................................4
Figure 1-4: Side View......................................................................................................................4
Figure 1-5: Bottom Panel...............................................................................................................5
Figure 1-6: PPC-F06B-BT Dimensions (mm) ...............................................................................6
Figure 3-1: Back Cover Retention Screws.................................................................................16
Figure 3-2: SATA Connector Location .......................................................................................17
Figure 3-3: SATA DOM Installation.............................................................................................17
Figure 3-4: mSATA Module Slot Location..................................................................................18
Figure 3-5: mSATA Module Installation......................................................................................19
Figure 3-6: Knockout for Wireless Antenna (Left Side Panel).................................................19
Figure 3-7: PCIe Mini Slot Location............................................................................................20
Figure 3-8: Removing Screw and Standoff................................................................................20
Figure 3-9: Installing the Standoff ..............................................................................................21
Figure 3-10: Inserting the WLAN Module...................................................................................21
Figure 3-11: Securing WLAN Module .........................................................................................22
Figure 3-12: Connecting RF Cables............................................................................................22
Figure 3-13: Securing SMA Connector and External Antenna Installation ............................23
Figure 3-14: Serial Port Locations..............................................................................................24
Figure 3-15: COM1 Serial Port Pin 9 Setting Jumper Location................................................25
Figure 3-16: AT/ATX Mode Selection..........................................................................................26
Figure 3-17: Attach Wall Mounting Kit to the Wall ....................................................................27
Figure 3-18: Hook onto Wall Mounting Kit.................................................................................28
Figure 3-19: Tighten Retention Screw........................................................................................29
Figure 3-20: Panel Cutout Dimensions.......................................................................................30
Figure 3-21: Tighten the Mounting Clamp Screws....................................................................30
Figure 3-22: The Rack/Cabinet Bracket......................................................................................31
Figure 3-23: Secure the Rack/Cabinet Bracket..........................................................................32
Figure 3-24: Install into a Rack/Cabinet .....................................................................................32
Figure 3-25: Arm Mounting (ARM-11-RS)...................................................................................34

PPC-F06B-BT Panel PC
Page X
Figure 3-26: Stand Mounting (Stand-B08)..................................................................................35
Figure 3-27: Powering on the System ........................................................................................35
Figure 3-28: Reset Button Location............................................................................................36
Figure 3-29: Clear CMOS Button Location.................................................................................36
Figure 3-30: BIOS Option–OS Selection ....................................................................................37
Figure 3-31: Keypad AP ...............................................................................................................38
Figure 5-1: Main Board Layout Diagram (Front Side)...............................................................69
Figure 5-2: Main Board Layout Diagram (Solder Side).............................................................70

PPC-F06B-BT Panel PC
Page XI
List of Tables
Table 1-1: System Specifications..................................................................................................8
Table 2-1: Packing List.................................................................................................................11
Table 2-2: Optional Items.............................................................................................................12
Table 3-1: RS-232 Serial Port (COM1) Pinouts ..........................................................................24
Table 3-2: COM1 Serial Port Pin 9 Setting Jumper Settings....................................................25
Table 3-3: RS-422/485 Serial Port Pinouts .................................................................................25
Table 4-1: BIOS Navigation Keys................................................................................................42
Table 5-1: Peripheral Interface Connectors...............................................................................71
Table 5-2: Audio Connector (AUDIO1) Pinouts .........................................................................71
Table 5-3: Battery Connector (BAT2) Pinouts...........................................................................71
Table 5-4: Inverter Connector (INV_CN1) Pinouts.....................................................................72
Table 5-5: LCD Connector (PANEL1) Pinouts ...........................................................................72
Table 5-6: MCU Connector (JSPI2) Pinouts...............................................................................73
Table 5-7: PCIe Mini Connector (M_PCIE1) Pinouts .................................................................74
Table 5-8: Power Input Connector (CN1) Pinouts.....................................................................74
Table 5-9: Power LED Connector (PW_LED1) Pinouts.............................................................74
Table 5-10: SATA Connector (SATA1) Pinouts .........................................................................75
Table 5-11: SATA Power Connector (SATA_PWR1) Pinouts...................................................75
Table 5-12: Serial Port Connector (COM2) Pinouts...................................................................75
Table 5-13: SPI Flash Connector (JSPI1) Pinouts.....................................................................75
Table 5-14: Touch Panel Connector (TOUCH1) Pinouts...........................................................76
Table 5-15: USB 2.0 Connector (TOUCH_USB1) Pinouts.........................................................76
Table 5-16: USB 2.0 Connector (TOUCH_USB2) Pinouts.........................................................76
Table 5-17: VGA Connector (VGA_CON1) Pinouts ...................................................................77
Table 5-18: Rear Panel Connectors............................................................................................77
Table 5-19: Ethernet Connectors (LAN1 & LAN2) Pinouts.......................................................78
Table 5-20: Power Connector (CN2) Pinouts.............................................................................78
Table 5-21: RS-232 Serial Port (COM1) Pinouts ........................................................................78
Table 5-22: USB 2.0 Connectors (USB1) Pinouts......................................................................79
Table 5-23: USB 3.0 Connectors (USB_CON1) Pinouts............................................................79

PPC-F06B-BT Panel PC
Page XII
List of BIOS Menus
BIOS Menu 1: Main.......................................................................................................................43
BIOS Menu 2: Advanced..............................................................................................................46
BIOS Menu 3: ACPI Settings .......................................................................................................46
BIOS Menu 4: F81866 Super IO Configuration..........................................................................47
BIOS Menu 5: Serial Port n Configuration Menu.......................................................................48
BIOS Menu 6: F81866 H/W Monitor.............................................................................................50
BIOS Menu 7: RTC Wake Settings..............................................................................................51
BIOS Menu 8: Serial Port Console Redirection.........................................................................52
BIOS Menu 9: IEI Feature.............................................................................................................53
BIOS Menu 10: CPU Configuration.............................................................................................54
BIOS Menu 11: IDE Configuration...............................................................................................56
BIOS Menu 12: USB Configuration.............................................................................................57
BIOS Menu 13: Chipset................................................................................................................58
BIOS Menu 14: North Bridge Configuration ..............................................................................59
BIOS Menu 15: Internal IGD Configuration................................................................................59
BIOS Menu 16: South Bridge Configuration..............................................................................61
BIOS Menu 17: Security...............................................................................................................62
BIOS Menu 18: Boot.....................................................................................................................63
BIOS Menu 19: Save & Exit..........................................................................................................66

PPC-F06B-BT Panel PC
Page 1
1 Introduction
Chapter
1

PPC-F06B-BT Panel PC
Page 2
1.1 Overview
Figure 1-1: PPC-F06B-BT Series Panel PC
The PPC-F06B-BT series is a quad-core Intel® Celeron® processor N2807 powered flat
bezel panel PC with a rich variety of functions and peripherals. The rugged and trendy
design can be applied in harsh industrial environments and enriches aesthetic experience
at the same time.
The Intel® Celeron® processor N2807 is a SoC (System-on-Chip) that ensures optimal
memory, graphics, and peripheral I/O support. The major external device connections
include USB 3.0, USB 2.0, RS-232, RS-422/485, audio line-out jack and two GbE
connectors. Furthermore, the PPC-F06B-BT has one full-size/half-size PCIe Mini card
slots, allowing installation of a wide variety of PCIe Mini cards, such as Wi-Fi modules and
mSATA modules.

PPC-F06B-BT Panel PC
Page 3
1.2 Features
Some of the features of the PPC-F06B-BT panel PC include:
Robust aluminum IP 65 compliant front bezel
Compact and fanless design for easy installation
Supports 1.58 GHz dual-core Intel® Celeron® processor N2807
2 GB 1600 MHz DDR3L on-board memory (system max. 4 GB)
One full-size/half-size PCIe Mini card slot supports mSATA or Wireless LAN
module
Rich I/O interfaces, including two GbE, one RS-232, one RS-422/485, two
USB 3.0, two USB 2.0 and audio line-out jack
Optional wireless LAN module
RoHS compliant
1.3 Front Panel
The front side of the PPC-F06B-BT (Figure 1-2) is a flat panel LCD screen surrounded by
an aluminum frame.
Figure 1-2: Front View

PPC-F06B-BT Panel PC
Page 4
1.4 Rear Panel
The rear panel has four VESA mounting holes and several retention screws. The VESA
mounting holes are circled in the following diagrams.
Figure 1-3: Rear View
1.5 Side Panels
Each side panel has one knockout hole for optional wireless LAN antenna and two
pre-formed holes for panel/rack mounting clamps.
Figure 1-4: Side View

PPC-F06B-BT Panel PC
Page 5
1.6 Bottom Panel
The bottom panel has the following interfaces:
1 x Power input connector
1 x Power button
1 x Power LED indicator
2 x USB 3.0 connectors
2 x USB 2.0 connectors
1 x Reset button
2 x RJ-45 GbE connectors
1 x RS-232 connectors (COM1)
1 x RS-422/485 connector (COM2)
1 x Audio line-out jack
1 x AT/ATX switch
Figure 1-5: Bottom Panel

PPC-F06B-BT Panel PC
Page 6
1.7 Dimensions
Figure 1-6: PPC-F06B-BT Dimensions (mm)

PPC-F06B-BT Panel PC
Page 7
1.8 Specifications
The technical specifications for the PPC-F06B-BT system are listed in Table 1-1.
PPC-F06B-BT
LCD Display 5.7” (4:3)
Max. Resolution 640 (W) x 480 (H)
Brightness 550 cd/m2
Contrast Ratio 800:1
LCD Color 262K
Pixel Pitch (mm) 0.18 (H) x 0.18 (V)
Viewing Angle (H-V) 160°/140°
Backlight MTBF 50,000 hours
SBC Model PPCMB2-BT-R10
CPU (SoC) 1.58 GHz dual-core Intel® Celeron® processor N2807
Memory 2 GB 1600 MHz DDR3L on-board memory
(system max. 4 GB by MOQ=300 pcs)
Touchscreen
4-wire resistive type flat touchscreen
Controller: PenMount DMC9000
Surface hardness: 3H
Storage mSATA or SATA DOM (Disk on Module)
Expansion One full-size/half-size PCIe Mini card slot supports
mSATA module or wireless LAN module
Ethernet 2 x Realtek RTL8111E GbE controller
Wireless LAN Optional 802.11a/b/g/n/ac Wi-Fi PCIe Mini module
Audio Codec Realtek ALC662 HD Audio codec
Power Input 9 V–30 V DC

PPC-F06B-BT Panel PC
Page 8
PPC-F06B-BT
Power Adapter
36W power adapter
Input: 90V - 264V AC, 50/60Hz
Output: 12V DC
Power Consumption 24 W
I/O Ports, Switches and
Buttons
2 x GbE (RJ-45)
2 x USB 3.0
2 x USB 2.0
1 x RS-232 (DB-9)
1 x RS-422/485 (DB-9)
1 x Audio line-out jack
1 x Power jack (lockable)
1 x Power button
1 x Reset button
1 x AT/ATX switch
Mounting VESA75 mm x 75 mm
Panel, wall, rack, stand and arm
Construction Material Aluminum front cover and sheet metal rear cover
Enclosure Color Black
Operating Temperature
(with air flow) -10ºC–50ºC
Storage Temperature -20ºC–60ºC
Humidity 10%–95%, non-condensing
IP Level IP 65 compliant front panel
Safety and EMC CE, FCC Class A
Dimensions (H x W x D) 136.4 mm x 178.5 mm x 56.3 mm
Net Weight 0.89 kg
Table 1-1: System Specifications