Kraus Elavo KCU-242 User manual

www.kraususa.com I Toll Free: 1.800.775.0703 I © 2022 Kraus USA Plumbing LLC I REV. July 26, 2022
Elavo™ White Ceramic
Undermount Bathroom Sinks
w/ Overflow
KCU-242, KCU-243, KCU-244,
KCU-272, KCU-273
R
INSTALLATION MANUAL

2
Congratulations on the purchase of your new
Kraus plumbing fixture!
Please keep the box and packaging materials until your product is
completely installed. If you have any questions, require technical
assistance or have any problems with your product:
Please contact our Customer Service Team
1-800-775-0703 / [email protected]
Have the model number available and retain a copy of your
receipt with purchase date for reference.
If for any reason this product does not meet your expectations,
please be sure to repack this product in the original box and
packaging material to avoid damage during transit.
DO NOT RETURN TO STORE
STOP
R

Prior to Installation:
·Make sure that you have all necessary parts by checking the parts list. If any part is
missing or damaged, please contact Kraus Customer Service at 800-775-0703 for a
replacement.
·Inspect the sink prior to installation to make sure that it has not been cracked or
chipped during shipping.
·Use the cut-out template provided by Kraus
·Observe all plumbing and building codes according to your state requirements
·Additional floor and wall preparation may be required to avoid damaging the sink
WARNING: This product is fragile and can break, chip or cause injury if handled
recklessly. Please consult with a professional when installing.
3
For technical assistance or replacement parts, please contact Kraus
Customer Service and one of our representatives will be happy to help:
Toll-Free: 800-775-0703 or [email protected]
The step-by-step guidelines in the installation instructions are a general reference for
installing a Kraus Sink. Should there be any discrepancies, Kraus cannot be held liable. It
is recommended to install all Kraus products by hiring a licensed professional.
R
STOP

4
KCU-242
21 1/8" x 13 3/4" x 7 1/4"
Tools you will need
Safety Goggles Silicone Adhesive Jig Saw
Phillips Screwdriver Tape Measure Pencil
Drill Scissors
Screwdriver Putty Knife
NOTE: Specialized tools may be necessary to install Kraus Ceramic Undermount sinks
with countertop materials other than wood, marble, or granite
Parts List (included)
·Cut-Out Template
·Mounting Hardware
R
KCU-243
23" x 15" x 7 1/4"
Dimensions
15" (380mm)
23" (585mm)
20 1/2" (520mm)
12 5/8"
(320mm)
7 1/4" (185mm)
5 1/2"
(140.06mm)
R1 1/8"
(30mm)
3 1/8"
(80mm)
13 3/4" (350mm)
21 1/8" (535mm)
18 3/4" (475mm)
11 3/8"
(290mm)
7 1/4" (185mm)
5 3/8" (135mm)
R1 1/8"
(30mm)
3 1/8"
(80mm)

5
Dimensions
KCU-244
20 1/4" x 15 1/8" x 7 7/8"
KCU-272
19 1/4" x 16 1/8" x 7 1/2"
KCU-273
16 3/4" x 13 1/8" x 7 5/8"
15 1/8" (385mm)
20 1/4" (515mm)
17 3/4" (450mm)
12 3/4"
(325mm)
R1 3/4"
(45mm)
7 7/8" (200mm)
5 3/4"
(146mm)
4 3/8"
(110mm)
16 1/8" (410mm)
19 1/4" (490mm)
17 3/8" (440mm)
14 1/8"
(360mm)
7 1/2" (190mm)
5 1/2"
(140mm)
4 3/8"
(110mm)
13 1/8" (335mm)
16 3/4" (425mm)
15" (380mm)
11 3/8"
(290mm)
7 5/8" (195mm)
5 3/4"
(145mm)
4 3/8"
(110mm)

6
1. Cut paper template
·Use scissors to cut along the inside line of the paper template.
NOTE: Make sure clearance is suitable for backsplash, faucet, and sink plumbing.
2. Trace template
·Compare cut template with sink to ensure proper size.
·Place the cut-out template in the desired location on the countertop and trace
with a pencil.
·Mark the faucet hole centerline on the countertop using the vertical line in the
center of the paper template.
Clip Location
Rim of Lavatory
Cut Along This Line
Clip Location
Rim of Lavatory
Cut Along This Line

7
3. Cut countertop
·Cut the countertop opening by carefully following the pencil line traced from the
template.
NOTE: Please use the appropriate saw that best fits your countertop material.

8
4. Install anchors
·Flip countertop over and place on a foam pad for protection. Use cutout template to
mark the anchor placement on the countertop. Drill 5/16” diameter x 3/8” deep hole in
countertop.
·Place epoxy in the drilled hole. Insert brass nut anchors into the drilled hole and wait
until the epoxy cures.
NOTE:
·Please check epoxy directions for curing time.
·Please tap brass nut anchors lightly with hammer.

9
5. Install sink
·Use a bead of clear silicone (or preferred adhesive) around the rim of the sink. Check the
alignment of the sink to the opening in the countertop. Place sink over cutout hole and
press firmly.
·Attach mounting hardware to secure bowl. Remove excess sealant from inside lip.
·Allow sealant to set for 30 – 60 minutes.
NOTE: Use acetone or rubbing alcohol to remove any excess sealant.
6. Install plumbing fixtures
·Connect drain to sink. Connect trap to drain. Connect water supply connections to
faucet according to manufacturer’s instructions.
·Run water into sink and check for leaks.

10
Codes/Standards Applicable:
Ceramic Bathroom Sink - Lifetime Limited Warranty
Kraus USA Plumbing, LLC (“Kraus”) extends this warranty to the original purchaser for personal
household use of the Ceramic Bathroom Sink when purchased from an authorized Kraus dealer and in
the location of original installation. This warranty is non-transferable.
Kraus warrants the structure and finish of the Ceramic Bathroom Sink to be free from defects in material
and workmanship under normal usage for as long as the original purchaser resides in the residence in
which the Ceramic Bathroom Sink was first installed.
Any product reported to the authorized dealer or to Kraus as being defective within the warranty period
will be repaired or replaced with a product of equal value at the option of Kraus.
Commercial Warranty
Kraus USA Plumbing, LLC (“Kraus”) warrants its Products for a period of one (1) year to commercial
purchasers of Products used in industrial, commercial and business applications.
Care and Cleaning Instructions
Certain cleaning products may cause damage to a Product's finish and use of the following on the
Product will void this warranty:
·Abrasive cleaners such as powders, bleach, ammonia, alcohol or chorine
·Abrasive pads, steel wool or wire brushes
What is Not Covered
This warranty does not cover Products that were discontinued when purchased or display Products,
whether such Products were purchased at discount outlets, unauthorized dealers, and/or sold on
clearance. This warranty does not cover any free gifts included with purchase.
This warranty does not cover damage resulting from neglect, misuse (including use for an unintended
application), abuse, carelessness, accident, hard water or mineral deposits, exposure to corrosive
materials, improper maintenance, alteration of the Product, or failure to follow care, cleaning or
installation instructions enclosed with your Product. Kraus recommends that all Kraus Products be
installed by a fully licensed and insured trade professional with experience in the installation of bathroom
and/or kitchen manufactured goods.
UPC
CR
R