Life Fitness Club Series User manual

CLUBSERIESFLATBENCH
Part # 7149101
RevA. 1
ASSEMBLY INSTRUCTIONS
Revision: 6/20/01

PARTS LIST
PART #
71387
71389
71392
71391
69131
68769
3102922
KEY
1
2
3
4
5
6
7
QTY
1
1
1
1
1
1
5
KEY
8
9
10
11
12
13
14
OR
PART #
3102905
3202406
3102807
3102514
3228501
6866701
6866602
6866603
DESCRIPTION
3/8 X 3-3/4” BOLT
3/8 X 1-1/4” BUTTON HEAD BOLT
3/8” LOW HEIGHT LOCK NUT
3/8” SAE WASHER
3/8” BLACK SAE WASHER
3/8” RH WASHER
WHITE RH CAP
PLATINUM RH CAP
QTY
2
1
4
4
1
11
11
11
DESCRIPTION
BENCH FRAME
3 X 2 X 16” TUBE
REAR UPRIGHT
SUPPORTBRACKET
SEATPAD
BACK PAD
3/8 X 2-3/4” BOLT
BOLT LENGTH
Tools Required forAssembly
2
NOTE:BOLTLENGTH ISMEASUREDFROMTHE UNDERSIDEOFTHE HEADOFTHE BOLT.
Bolt Length Ruler
0123456
1/2 1/2 1/2 1/2 1/2 1/2
* Rubber mallet or hammer
* 9/16” wrench
* Ratchet with 9/16” socket
* 7/32”Allen wrench

3
10
3/8” LOW
HEIGHT LOCK
NUT
12
3/8” BLACK SAE
WASHER
14
RH CAP
(BLACK/WHITE/PLATINUM)
13
RH
WASHER
9 3/8 X 1-1/4” BUTTON HEAD BOLT
7 3/8 X 2-3/4” BOLT
8 3/8 X 3-3/4” BOLT
11
3/8” SAE
WASHER

STEP 1:
FIGURE 1
4
• SECURELY assemble the 3 X 2 X 16” TUBE (2) to the BENCH FRAME (1) using four RH CAPS (14), two 3/8 X 3-3/4”
BOLTS (8), four 3/8” RH WASHERS (13) and two 3/8” LOW HEIGHT LOCK NUTS (10) as shown in FIGURE 1.
• SECURELY assemble the REAR UPRIGHT (3) to the BENCH FRAME (1) using four RH CAPS (14), two 3/8 X 2-3/4” BOLTS
(7), four 3/8” SAE WASHERS (11), four 3/8” RH WASHERS (13) and two 3/8” LOW HEIGHT LOCK NUTS (10) as shown in
FIGURE 1.
0123456
1/2 1/2 1/2 1/2 1/2 1/2
3
13 11 10
8
13
10
14
7
14
1
3/8 X 2-3/4”
3/8 X 3-3/4”

STEP 2:
FIGURE 2
5
• SECURELY assemble the BACK PAD (6) to the BENCH FRAME (1) using two RH CAPS (14), two 3/8 X 2-3/4” BOLTS (7)
and two 3/8” RH WASHERS (13) as shown in FIGURE 2.
FIGURE 3
14 7
13
1
6
• SECURELY assemble the SUPPORT BRACKET (4) to the SEAT PAD (5) using one 3/8 x 1-1/4” BUTTON HEAD BOLT (9)
and one 3/8 BLACK SAE WASHER (12) as shown in FIGURE 3. (NOTE: Before Tightening, make sure that the SUP-
PORT BRACKET (4) is PARALLEL with the front of the SEAT PAD (5). See Detail.)
• SECURELY assemble the SEAT PAD (5) to the BENCH FRAME (1) using one RH CAP (14), one 3/8 x 2-3/4” BOLT (7) and
one 3/8” RH WASHER (13) as shown in FIGURE 3.
STEP 3:
1
9
12
4
5
14
7
13 5
3/8 X 2-3/4”
BLACK
3/8 X 1-1/4” BUTTON HEAD
BOLT
3/8 X 2-3/4”

Clean:
• Upholstery with mild soap and water.
• Guide rods with a cotton cloth.
• Hand grips with mild soap and water.
• Frame damage can be repaired with touch-up paint can be purchased from your LifeFitness customer service representative at
[phone].
Inspect:
• Cables for wear or damage and proper tension (should not exceed 3/4” deflection.) Pay close attention at bends and attachment
points.
• Hardware should be checked for looseness. Tighten as required.
• Frames should be inspected for wear or damage.
• Hand Grips should be checked for wear or damage
Lubricate:
• Lube the Guide Rods. Apply the lubricant to a cotton cloth, then run the cotton cloth up and down the guide rods as needed. Do not
spray lubricant directly on the Guide Rods.
PREVENTATIVE MAINTENANCE TIPS
There is a risk assumed by individuals who use this type of equipment. To minimize risk, please
follow these rules:
2. Do not allow minors or children to play on or around this equipment.
1. Inspect equipment daily. Tighten all loose connections and replace worn parts immediately.
Failure to do so may result in serious injury.
3. Exercise with care to avoid injury.
4. Consult your physician before beginning any exercise program.
6
ThankyouforpurchasingtheLifeFitness CLUBSERIES FLATBENCH.If unsure ofproper useof equip-
ment, call your local LifeFitness distributor or call the LifeFitness customer service department at (800)
351-3737.
CAUTION-PLEASE READ
Action DAILY WEEKLY QUARTERLY BI-ANNUALLY AS NEEDED
CLEAN
Upholstery X
Guide Rods X
Hand Grips X
INSPECT
Visual Overall X
Cables X
Hardware X
Frame X
Hand Grips X
LUBRICATE
Guide Rods X
WARRANTY INFORMATION
10YEARS STRUCTURUALFRAME
3 YEARS PILLOWBLOCKS,PULLEYS,WEIGHTPLATESANDGUIDE RODS
1YEAR CABLES
90 DAYS UPHOLSTERY