Little Giant WCR-9SP User manual

INTRODUCTION
IMPORTANT: Read all instructions in this instruction sheet
before operating. Check all applicable local codes and require-
ments before installing. Instruction sheet should be retained
for future reference.
Thank you for your purchase of the Little Giant water collection
removal basin. This product is designed primarily for use in resi-
dential applications to collect surface drainage and divert it away
from structures, erosion-poor landscapes, and poor drainage
areas. Locating low spots in landscaping which anticipate rainfall is
the key to installing this basin. The basin inlet is designed to fit a 4"
perforated PVC pipe, and the outlet can be routed to street curbs
or other runoff areas. The basin is to be installed so that the cover
is flush or above the surface level. The basin cover is not suitable
for heavy traffic load.
PRE-PACKAGED UNIT
Verify all parts with basin and cover assemblies are received intact.
1. Remove bolts and washers on cover and set aside.
2. Remove gasket material from hardware kit, and place material
around circumference of basin inside of bolt circle.
3. Place the pump on a flat surface and install the discharge pipe
in the discharge of the pump.
4. Install float switch 4" above discharge of pump with a 3-1/2"
tether length. Float switch should be installed in a manner that
will not allow it to contact the pump or side of basin during
operation. Refer to float switch instruction sheet for alternative
settings. Place the pump in the basin in the torque indenta-
tions (see Figure 2). Press the 2" grommet in the discharge
hole in the basin, and install check valve, 90° street elbow, and
discharge pipe as shown in Figure 2. Lube the grommet and
discharge pipe with dishwashing liquid for easier installation.
5. Install 2" bulkhead fitting, PVC conduit, and elbow as shown
in Figure 2. To ensure proper conduit connections, use only
adequate primers and solvent cements for PVC pipe. Pump
and switch cords are not intended for direct burial, and
improper connection will void the warranty. The provided 2"
PVC Schedule 40 conduit can be used to bring the power and
switch cords safely above ground if the basin is installed near
a structure, or it can be used to bring the cord to a depth of
at least 18" below surface. All electrical connection should be
made in accordance with National Electric Code (NEC), and
any state and local requirements.
6. To test, plug the unit in and run water into the basin until the
unit switches on. If the unit does not operate, refer to trouble-
shooting information in the instruction sheet for the pump.
7. Secure the lid to the basin using the bolts and washers provided.
8. A 4" perforated PVC pipe should be used to channel drainage
into the basin. The pipe should be cleaned on a regular basis
to prevent build-ups and possible clogging.
NOTE: Little Giant cannot be responsible for damages caused by
the faulty or negligent installation of this product. If you feel that
you may encounter problems in installing this product, we respect-
fully suggest you engage the services of a competent plumber,
electrician, or qualified service person.
WCR-9SP
WCR-9SS
Figure 1
Figure 2
REPLACEMENT PARTS LIST
PART NO. DESCRIPTION QTY
113095 BASIN, 20" x 30" 1
509500 PUMP, 9S-CIA-RFS 1
113003 COVER, 12 GAUGE STEEL 1
113002 COVER ASSY, STRUCTURAL FOAM 1
113005 HARDWARE KIT, STEEL COVER 1
113006 HARDWARE KIT, STRUCTURAL FOAM COVER 1
940022 CHECK VALVE, 2" 1
944663 PIPE, 11" CONDUIT, PVC 1
944603 PIPE, 5" CONDUIT, PVC 1
944654 PIPE, 17" DISCHARGE, PVC 1
944653 PIPE, 10" DISCHARGE, PVC 1
943181 ELBOW, 90°, PVC 1
941181 ADAPTER, 2" SLIP, PVC 2
566257 ADAPTER, 2" BULKHEAD 1
943192 ELBOW, 90° STREET 1
925033 GROMMET, 2" 1
Franklin Electric Co., Inc.
P. O. Box 12010
Oklahoma City, OK 73157-2010
405.947.2511 • Fax: [phone]
www.LittleGiantPump.com
[email protected]
1

2
LIMITED WARRANTY
Each new Little Giant product is guaranteed to be in perfect condition
when it leaves the factory. The basin is warranted against defective
materials and workmanship for a period of five years. Please see
pump instruction sheet for information on pump warranty. During
the time periods and subject to the conditions hereinafter set forth,
any product(s) that should fail due to materials or workmanship will
be replaced or repaired at the option of Little Giant.
For customers in the CONTINENTAL UNITED STATES please con-
tact Little Giant toll-free at 1-800-572-9933 or by fax at 405-947-
8720 for return information. All product(s) returned under warranty
will be fully inspected to determine the cause of the problem
before warranty repair or replacement is approved. Returns shells
include a brief description of the problem, how it occurred, and a
telephone number for a person to contact if there are questions.
If the product(s) are under warranty, a copy of the invoice and
date of installation should be included. Without an invoice, the
date of manufacture will be used if the unit(s) is under warranty.
Before using the user shall determine the suitability of the product
for the intended use, and the user assumes all risk and liability
whatsoever in connection therewith. Little Giant is not responsible
for any charges necessitated by the removal and re-installation of
any unit(s).
PRODUCT IMPROVEMENTS: Little Giant reserves the right to
change or improve its products, or any portion thereof, without
being obligated to provide such a change or improvement for units
already sold or shipped prior to any change or improvement.
NEITHER THE SELLER NOR MANUFACTURER SHALL BE LIABLE
FOR ANY INJURY, LOSS OR DAMAGE, WHETEHER DIRECT,
INCIDENTAL OR CONSEQUENTIAL (INCLUDING, BUT NOT
LIMITED TO DAMAGES FOR LOST PROFIT, LOST SALES,
INJURY TO PERSON OR PROPERTY OR ANY OTHERANY OTHER
CONSEQUENTIAL LOSS), ARISING OUT OF THE USE OR
INABILTY TO USE THE PRODUCT. THE USER AGREES THAT
NO REMEDY SHELL BE AVAILABLE OTHER THAN THE STATED
HEREIN.
DISCLAIMER: THE FOREGOING WARRANTY IS AN EXCLUSIVE
WARRANTY INLIEU OF ANY OTHER EXPRESSED WARRANTIES
OR IMPLIED WARRANTIES (INCLUDING BUT NOT LIMITED TO
ANY IMPLIED WARRANTY OR MERCHANTIBILITY OR FITNESS
FOR A PARTICULAR PURPOSE).
Some states do not allow limitations on how long an implied warranty
lasts or the exclusion or limitation of incidental or consequential
damages; therefore, the above limitations or exclusions may not
apply to you. This warranty gives you specific legal rights and you
may also have other rights that vary from state to state.
For parts or repair, please contact . . . . . . . . . . . . . . . . . . . . 1.888.572.9933
For technical assistance, please contact . . . . . . . . . . . . . . . 1.888.956.0000
www.LittleGiantPump.com
[email protected]
Form 987363 - 09/24/2009
©2008 Franklin Electric Co., Inc.
Little Giant® is a registered trademark of Franklin Electric Co., Inc.