Meanwell APV-25 User manual

InstallationManual

Type：LEDPowerSupply
（Families：LP,AP,ELN,LPF,PLN,HLN,PLC,PCD,PLD,PLP,HLP,CEN,CLG,HLG,HSG,HVG(C),LCM,PLM,HBG,
ULP）
Introduction
TheLEDpowersupplyisadedicatedLEDdrivingdevicethatdeliversaconstantcurrent/voltageorgeneratesan
adjustablecurrentcontrolledbyanexternaldimmertoLEDs.Dependingonitstypesordesignconcept,someof
themnotonlyhavePFCcapabilitybutalsocanbelocatedinaharshenvironmentsuchasdusty,humidplaces.
MeanWell’sLEDpowersuppliesincludemetalcase,plasticcase,andPCBtypes.
Installation
（1）Beforecommencinganyinstallationormaintenancework,pleasedisconnectthepowersupplyfromtheutility.
Ensurethatitcannotbere‐connectedinadvertently!
（2）Keepproperventilationaroundtheunitanddonotstackanyobjectonit.Alsoa10‐15cmclearancemustbe
keptwhentheadjacentdeviceisaheatsource.
（3）Mountingorientationsotherthanstandardorientationoroperateunderhighambienttemperaturemay
increasetheinternalcomponenttemperatureandwillrequireade‐ratinginoutputcurrent.Pleasereferto
thespecificationsheettoreceivetheoptimummountingpositionandinformationaboutthede‐ratingcurve.
（4）Currentratingofanapprovedprimary/secondarycableshouldbegreaterthanorequaltothatoftheunit.
Pleaserefertoitsspecification.
（5）ForLEDpowersupplieswithwaterproofconnectors,verifythatthelinkagebetweentheunitandthelighting
fixtureistightsothatwatercannotintrudeintothesystem.
（6）FordimmableLEDpowersupplies,makesurethatyourdimmingcontrolleriscapableofdriving
theseunits.ForELNseries,either“D”or“P”type,require40mAeachunit;forthosewith“3in1”dimming
function,e.g.HLGandLPFseries,require0.15mAeachunit.
（7）Wiring:Thewirecolorwillvarybycountry,pleaserefertothetablebelow.
NorthAmerica EuropeanHarmonized
LiveandACL Black Brown
NeutralandACNwhite Blue
PEandFG(ClassIonly)Green Green/yellow
（a）ConnecttheFGwire(greenorgreen/yellow)oftheLEDpowersupplytoPE(greenorgreen/yellow),this
stepcanbeskippedwhentheunitismarkedclassII,ungrounded.
（b）ConnecttheACLwire(blackorbrown)oftheLEDpowersupplytoLive(blackorbrown).
（c）ConnecttheACNwire(whiteorblue)oftheLEDpowersupplytoNeutral(whiteorblue).

InstallationManual

（8）ThemaximumnumberoftheLEDPSUsthatcanbeconnectedtoacircuitbreakerat230Visshownasbelow.
ModelB10 B16 C10 C16
CEN‐6017271727
CEN‐7512191219
CEN‐10010151015
CLG‐6017271727
CLG‐1001234
CLG‐1501224
HLG‐40H58814
HLG‐60H46711
HLG‐80H3458
HLG‐100H2447
HLG‐120H2447
HLG‐150H2346
HLG‐185H2446
HLG‐240H1224
HLG‐320H1223
HLG‐60H‐C3558
HLG‐80H‐C2447
HVG‐100(440V)7111219
HVG‐150(480V)46611
HVGC‐100(440V)7111219
HVGC‐150(480V)46611
HSG‐703569
ULP‐1502446
LDV‐1851224
APV‐1259915
APV‐1659915
APV‐2558914
APV‐353558
APC‐1259915
APC‐167121220
APC‐2558914
APC‐353558
LPL‐18(115V)8131321
LPH‐1858814
LPV‐2046611
LPV‐352447
LPV‐602335
LPV‐1001113
LPHC‐186101117
LPLC‐18(115V)8141321
LPC‐2047711

InstallationManual
ModelB10 B16 C10 C16
LPC‐352446
LPC‐602335
ELN‐303558
ELN‐601234
PCD‐1633533353
PCD‐2522362236
PLD‐1633533353
PLD‐2522362236
LPF‐167121220
LPF‐257121321
LPF‐4059915
LPF‐6046711
LPF‐902446
PLC‐3033533353
PLC‐4527432743
PLC‐6017271727
PLC‐1001234
PLN‐2033533353
PLN‐3033533353
PLN‐4527432743
PLN‐6017271727
PLN‐1001224
HLN‐40H58914
HLN‐60H3559
HLN‐80H2447
LCM‐4010161728
LCM‐609151626
PLP‐2033533353
PLP‐3033533353
PLP‐4522362236
PLP‐6017271727
HLP‐40H58914
HLP‐60H3569
HLP‐80H3458
ULP‐1502446
HBG‐1002446
HBG‐1602336
HBG‐2401123
PLM‐1280128 83133
PLM‐2544714471
PLM‐4022362236


InstallationManual

Note:ThesecalculatedvaluesarebasedonMCBS200seriesmanufacturedbyABBexceptfor
HVG/HVGCseries,whicharecalculatedbyusingMCBS260seriesofthesamemanufacturer.
（9）Forotherinformationabouttheproducts,pleaserefertowww.meanwell.comfordetails.

Warning/Caution!!
（1）Riskofelectricalshockandenergyhazard.Allfailureshouldbeexaminedbyaqualifiedtechnician.Pleasedo
notremovethecaseofthepowersupplybyyourself!
（2）Riskofirreparabledamage.LEDpowersupplieswithIP64toIP66ratingmustbelocatedindoorsorina
locationwheretheseunitscanbeshelteredfromtherainifoutdoors.
（3）PleasedonotinstallLEDpowersuppliesinplaceswithhighambienttemperatureorclosetofiresource.
Pleaserefertothespecificationsaboutthemaximumambienttemperaturelimitations.
（4）Outputcurrentandoutputwattagemustnotexceedtheratedvaluesonthespecifications.
（5）TheFG()mustbewellconnectedtoPE(protectiveearth)iftheunitequipswithit.
（6）AllMW’sPSUsaredesignedinaccordancewithEMCregulationsandtherelatedtestreportsareavailableby
request.Sincetheyarebelongtocomponentpowersuppliesandwillbeinstalledinsidesystemenclosure,
whentheyareintegratedintoasystem,theEMCcharacteristicsoftheendsystemmustbere‐verifiedagain.



Manufacturer：
MEANWELLENTERPRISESCo.,Ltd.
No.28,Wuquan3rdRoad,WuguDistrict,
NewTaipeiCity,Taiwan,24891
Tel:+886‐2‐2299‐6100
Web:www.meanwell.com
Importer:
Emtron electronic GmbH
Rudolf-Diesel-Str. 14
D-64569 Nauheim
Tel.: [phone]
Web: www.emtron.de