Nasco Healthcare Life/form LF03623 User manual

Life/form®Infant
Airway Management
Trainer with Stand
LF03623
INSTRUCTION MANUAL

About the Simulator
The Nasco Healthcare Life/form®Infant Airway Management
Trainer is a realistic simulator for the training of intubation
skills. Nasco Healthcare has taken great care to create an airway
management trainer that is anatomically correct in respect to
both size and detail.
Landmarks include gum line, tongue, oral and nasal pharynx,
larynx, epiglottis, arytenoids, false and true vocal cords, cricoid
ring, tracheal rings, trachea, esophagus, lungs, and stomach.
Nasco Healthcare’s Infant Airway Management Trainer allows
you to practice oral intubation, and suction techniques can also
be performed and evaluated.
The simulator was designed to use an uncuffed endotracheal
tube measuring up to 4.0 mm in diameter.
2

List of Components
3
A. Airway Management Trainer Head on a Stand
B. 8-oz. Bottle of Pump Spray Lubricant
C. Right and Left Simulated Lungs
D. Simulated Stomach
E. Packing Foam Block (Not Pictured) & Hard Carry Case
F. 2 Red Caps
3 3
About the Simulator
The Life/form® Infant Airway Management Trainer is a realistic simulator
for the training of intubation skills. Nasco has taken great care to create
an airway management trainer that is anatomically correct in respect to
both size and detail.
Landmarks include gum line, tongue, oral and nasal pharynx, larynx, epi-
glottis, arytenoids, false and true vocal cords, cricoid ring, tracheal rings,
trachea, esophagus, lungs, and stomach.
Nasco’s Infant Airway Management Trainer allows you to practice oral
intubation, and suction techniques can also be performed and evaluat-
ed. The simulator was designed to use an uncuffed endotracheal tube
measuring up to 4.0 mm I.D.
List of Components
A. Airway Management Trainer Head on a Stand
B. 8-oz. Bottle of Pump Spray Lubricant
C. Right and Left Simulated Lungs
D. Simulated Stomach
E. Packing Foam Block (Not Pictured) & Hard Carry Case
F. 2 Red Caps
About the Simulator
The Life/form® Infant Airway Management Trainer is a realistic simulator
for the training of intubation skills. Nasco has taken great care to create
an airway management trainer that is anatomically correct in respect to
both size and detail.
Landmarks include gum line, tongue, oral and nasal pharynx, larynx, epi-
glottis, arytenoids, false and true vocal cords, cricoid ring, tracheal rings,
trachea, esophagus, lungs, and stomach.
Nasco’s Infant Airway Management Trainer allows you to practice oral
intubation, and suction techniques can also be performed and evaluat-
ed. The simulator was designed to use an uncuffed endotracheal tube
measuring up to 4.0 mm I.D.
List of Components
A. Airway Management Trainer Head on a Stand
B. 8-oz. Bottle of Pump Spray Lubricant
C. Right and Left Simulated Lungs
D. Simulated Stomach
E. Packing Foam Block (Not Pictured) & Hard Carry Case
F. 2 Red Caps
D.
D.
E.
E.
F.
F.
A.
A.
B.
B.
C.
C.
NP066_94_LF03623_InfantAirwayHeadStand.indd 3 9/24/14 8:08 AM

Set Up
4
To protect your product during shipping, the head has been
removed from the board. Simply remove it from the carton and
unwrap the packing material.
To replace the head on stand:
1. Lift the bracket fixed on the board. (See Figure 1.)
2. Slide the 2 prongs into the bracket. (See Figure 2.)
3. Ensure the parts are secure before starting intubation
training.
Lubrication
Before using the Infant Airway Management Trainer, lubricate
both the oral cavity and the endotracheal tube you plan to
use with the Nasco lubricant provided. (See Figure 3.)
Note: Nasco Healthcare recommends the use of the provided
lubricant or a similar vegetable-based lubricant for the Infant
Airway Management Trainer. The use of a silicone-based or sim-
ilar lubricant may cause damage
to the simulator, thus voiding
Nasco Healthcare’s
warranty on the trainer.
Cleaning the Face
Normal soil can be removed
from the face of the trainer with
mild soapywater. Nasco Cleaner
(LF09919) will remove stubborn
4 4
Set Up
To protect your product during shipping, the head has been removed from
the board. Simply remove it from the carton and unwrap the packing mate-
rial. The lung and stomach bags are already in place and ready to use.
To replace the head on stand:
1. Lift the bracket fixed on the board. (See figure 1.)
2. Slide the 2 prongs into the bracket. (See figure 2.)
3. Ensure the parts are secure before starting intubation training.
Lubrication
Before using the Infant Airway
Management Trainer, lubricate
both the oral cavity and the
endotracheal tube you plan to
use with the Nasco lubricant pro-
vided. (See figure 3.)
Please Note:Nasco recom-
mends the use of the provided
lubricant or a similar vegeta-
ble-based lubricant for the Infant
Airway Management Trainer. The
use of a silicone-based or similar
lubricant may cause damage to the simulator, thus voiding Nasco’s war-
ranty on the trainer.
Care and Maintenance
Cleaning the Face and Head
Normal soil can be removed from the face of the trainer with mild soapy
water. Nasco Cleaner (LF09919U) will remove stubborn stains. Simply
apply Nasco Cleaner to the soiled area and wipe it clean with a soft cloth
or paper towel. Note:Do not apply Nasco Cleaner around the mouth or
nostrils as the residue of the cleaner could be toxic.
Set Up
To protect your product during shipping, the head has been removed from
the board. Simply remove it from the carton and unwrap the packing mate-
rial. The lung and stomach bags are already in place and ready to use.
To replace the head on stand:
1. Lift the bracket fixed on the board. (See figure 1.)
2. Slide the 2 prongs into the bracket. (See figure 2.)
3. Ensure the parts are secure before starting intubation training.
Lubrication
Before using the Infant Airway
Management Trainer, lubricate
both the oral cavity and the
endotracheal tube you plan to
use with the Nasco lubricant pro-
vided. (See figure 3.)
Please Note:Nasco recom-
mends the use of the provided
lubricant or a similar vegeta-
ble-based lubricant for the Infant
Airway Management Trainer. The
use of a silicone-based or similar
lubricant may cause damage to the simulator, thus voiding Nasco’s war-
ranty on the trainer.
Care and Maintenance
Cleaning the Face and Head
Normal soil can be removed from the face of the trainer with mild soapy
water. Nasco Cleaner (LF09919U) will remove stubborn stains. Simply
apply Nasco Cleaner to the soiled area and wipe it clean with a soft cloth
or paper towel. Note:Do not apply Nasco Cleaner around the mouth or
nostrils as the residue of the cleaner could be toxic.
Figure 3 Figure 3
Figure 1 Figure 1
Figure 2 Figure 2
NP066_94_LF03623_InfantAirwayHeadStand.indd 4 9/24/14 8:08 AM
4 4
Set Up
To protect your product during shipping, the head has been removed from
the board. Simply remove it from the carton and unwrap the packing mate-
rial. The lung and stomach bags are already in place and ready to use.
To replace the head on stand:
1. Lift the bracket fixed on the board. (See figure 1.)
2. Slide the 2 prongs into the bracket. (See figure 2.)
3. Ensure the parts are secure before starting intubation training.
Lubrication
Before using the Infant Airway
Management Trainer, lubricate
both the oral cavity and the
endotracheal tube you plan to
use with the Nasco lubricant pro-
vided. (See figure 3.)
Please Note:Nasco recom-
mends the use of the provided
lubricant or a similar vegeta-
ble-based lubricant for the Infant
Airway Management Trainer. The
use of a silicone-based or similar
lubricant may cause damage to the simulator, thus voiding Nasco’s war-
ranty on the trainer.
Care and Maintenance
Cleaning the Face and Head
Normal soil can be removed from the face of the trainer with mild soapy
water. Nasco Cleaner (LF09919U) will remove stubborn stains. Simply
apply Nasco Cleaner to the soiled area and wipe it clean with a soft cloth
or paper towel. Note:Do not apply Nasco Cleaner around the mouth or
nostrils as the residue of the cleaner could be toxic.
Set Up
To protect your product during shipping, the head has been removed from
the board. Simply remove it from the carton and unwrap the packing mate-
rial. The lung and stomach bags are already in place and ready to use.
To replace the head on stand:
1. Lift the bracket fixed on the board. (See figure 1.)
2. Slide the 2 prongs into the bracket. (See figure 2.)
3. Ensure the parts are secure before starting intubation training.
Lubrication
Before using the Infant Airway
Management Trainer, lubricate
both the oral cavity and the
endotracheal tube you plan to
use with the Nasco lubricant pro-
vided. (See figure 3.)
Please Note:Nasco recom-
mends the use of the provided
lubricant or a similar vegeta-
ble-based lubricant for the Infant
Airway Management Trainer. The
use of a silicone-based or similar
lubricant may cause damage to the simulator, thus voiding Nasco’s war-
ranty on the trainer.
Care and Maintenance
Cleaning the Face and Head
Normal soil can be removed from the face of the trainer with mild soapy
water. Nasco Cleaner (LF09919U) will remove stubborn stains. Simply
apply Nasco Cleaner to the soiled area and wipe it clean with a soft cloth
or paper towel. Note:Do not apply Nasco Cleaner around the mouth or
nostrils as the residue of the cleaner could be toxic.
Figure 3 Figure 3
Figure 1 Figure 1
Figure 2 Figure 2
NP066_94_LF03623_InfantAirwayHeadStand.indd 4 9/24/14 8:08 AM

Set Up
5
stains. Simply apply Nasco Cleaner to the soiled area and wipe it
clean with a soft clothor paper towel.
Note: Do not apply Nasco Cleaner around the mouth or nostrils
as the residue of the cleaner could be toxic.
Cleaning the Airway
1. Remove the head from the
board, and take the trainer to an
area with a sink and open
counter space. Remove the lungs
and stomach.
2.Using the two red caps supplied,
plug the esophagus and trachea.
(SeeFigure 4.)
3.Stabalize the head on the
counter face up (towels work
well for this) with the plugged tubes over the sink.
4.Carefully pour warm soapy water (mild dish soap works best)
into the mouth until the water level covers the tongue. You
may need to tilt the head up slightly to allow the water to
completely fill the system.
5. Take a small soft brush and gently scrub the inside of the
mouth and nostrils (a small soft toothbrush and cotton swabs
work well for this).
6. When done, pull the plug from the esophagus and drain the
water into the sink.
7. Holding the head vertically over the sink, pull the other plug
from the trachea to completely empty the system.
8. Rinse the airway with warm tap water following the same
procedure to clean until all the soap has been flushed from
the system.
Disinfecting the Airway
1. Repeat steps 1-4 of the cleaning procedure using a bleach
solution mixed as specified for the Centers for Disease Control.
2. Fill the system with the bleach solution until it reaches the
corners of the mouth. Note: Start filling with the simulator on
a flat surface and tilt the head up as needed to fill the system.
3. When filled, allow the head to sit for at least 10 minutes.
4. Drain and rinse as described in steps 7-8 of the cleaning
procedures.
5 5
Cleaning the Airway
1. Remove the head from the board, and take the trainer to an area with
a sink and open counter space. Remove the lungs and stomach.
2. Using the two red caps supplied, plug the esophagus and trachea.
(See figure 4.)
3. Stabilize the head on the counter face up (towels work well for this)
with the plugged tubes over the sink.
4. Carefully pour warm soapy water (mild dish soap works best) into the
mouth until the water level covers the tongue. You may need to tilt the
head up slightly to allow the water to completely fill the system.
5. Take a small soft brush and gently scrub the inside of the mouth and
nostrils (a small soft toothbrush and cotton swabs work well for this).
6. When done, pull the plug from the esophagus and drain the water
into the sink.
7. Holding the head vertically over the sink, pull the other plug from the
trachea to completely empty the system.
8. Rinse the airway with warm tap water following the same procedure to
clean until all the soap has been flushed from the system.
Disinfecting the Airway
1. Repeat steps 1-4 of the cleaning procedure using a bleach solution
mixed as specified for the Centers for Disease Control.
2. Fill the system with the bleach solution until it reaches the corners of
the mouth. Note: Start filling with the simulator on a flat surface and tilt
the head up as needed to fill the system.
3. When filled, allow the head to sit for at least 10 minutes.
4. Drain and rinse as described in steps 7-8 of the cleaning procedures.
5. Set the head aside and allow to air dry completely prior to next use or
storage.
Storage
Store clean, dry, Infant Airway Management Head while attached to a
manikin or stand in the hard carry case.
Cleaning the Airway
1. Remove the head from the board, and take the trainer to an area with
a sink and open counter space. Remove the lungs and stomach.
2. Using the two red caps supplied, plug the esophagus and trachea.
(See figure 4.)
3. Stabilize the head on the counter face up (towels work well for this)
with the plugged tubes over the sink.
4. Carefully pour warm soapy water (mild dish soap works best) into the
mouth until the water level covers the tongue. You may need to tilt the
head up slightly to allow the water to completely fill the system.
5. Take a small soft brush and gently scrub the inside of the mouth and
nostrils (a small soft toothbrush and cotton swabs work well for this).
6. When done, pull the plug from the esophagus and drain the water
into the sink.
7. Holding the head vertically over the sink, pull the other plug from the
trachea to completely empty the system.
8. Rinse the airway with warm tap water following the same procedure to
clean until all the soap has been flushed from the system.
Disinfecting the Airway
1. Repeat steps 1-4 of the cleaning procedure using a bleach solution
mixed as specified for the Centers for Disease Control.
2. Fill the system with the bleach solution until it reaches the corners of
the mouth. Note: Start filling with the simulator on a flat surface and tilt
the head up as needed to fill the system.
3. When filled, allow the head to sit for at least 10 minutes.
4. Drain and rinse as described in steps 7-8 of the cleaning procedures.
5. Set the head aside and allow to air dry completely prior to next use or
storage.
Storage
Store clean, dry, Infant Airway Management Head while attached to a
manikin or stand in the hard carry case.
Figure 4
Figure 4
NP066_94_LF03623_InfantAirwayHeadStand.indd 5 9/24/14 8:09 AM

Set Up
4
5. Set the head aside and allow to air dry completely prior to next
use or storage.
Storage
Store clean, dry, Infant Airway Management Head while attached
to a manikin or stand in the hard carry case.•
Important
It is vital that the packing
foam is retained for stor-
age purposes. This step will
certainly prevent damage
to your simulator. With the
mounting bracket in a verti-
cal position, place the foam
piece over the head so the
opening circles are under the
chin and over the bridge of
the nose.
Cautions
• Ink, ball-point pen, and some printed plastics or paper may
leave an indelible stain. Avoid placing the simulator in contact
with these materials.
• Cosmetics or other Moulage type make-up may also transfer an
indelible stain.
• Silicone-based or similar lubricants may cause damage to
the simulator.
• Use uncuffed 4.0 mm In diameter endotracheal tubes or smaller.
• Damage to the gum line, tongue, oral and nasal pharanx,
larynx, epiglottis, arytenoids, false and true vocal cords, cricoid
ring, trachea rings, trachea, and esophagus must be returned
to Nasco Healthcare for repair.
• Actual product may vary slightly from photo. Nasco Healthcar
reserves the right to change product color, materials, supplies,
or function as needed.
6 6
Important
It is vital that the packing
foam is retained for storage
purposes. This step will cer-
tainly prevent damage to your
simulator. With the mounting
bracket in a vertical position,
place the foam piece over the
head so the opening circles
are under the chin and over
the bridge of the nose.
Cautions
•Ink, ball-point pen, and some printed plastics or paper may leave an
indelible stain. Avoid placing the simulator in contact with these
materials.
•Cosmetics or other Moulage type make-up may also transfer an
indelible stain.
•Silicone-based or similar lubricants may cause damage to the
simulator.
•Use uncuffed 4.0 mm I.D. endotracheal tubes or smaller.
•Damage to the gum line, tongue, oral and nasal pharanx, larynx,
epiglottis, arytenoids, false and true vocal cords, cricoid ring,
trachea rings, trachea, and esophagus must be returned to Nasco
for repair.
•Actual product may vary slightly from photo. Nasco reserves the
right to change product color, materials, supplies, or function as
needed.
Supplies and Replacement Parts
LF03598U Replacement Stomach
LF03599U Replacement Lung Set
LF03644U 8-oz. Pump Spray Lubricant
LF09919U Nasco Cleaner
Important
It is vital that the packing
foam is retained for storage
purposes. This step will cer-
tainly prevent damage to your
simulator. With the mounting
bracket in a vertical position,
place the foam piece over the
head so the opening circles
are under the chin and over
the bridge of the nose.
Cautions
•Ink, ball-point pen, and some printed plastics or paper may leave an
indelible stain. Avoid placing the simulator in contact with these
materials.
•Cosmetics or other Moulage type make-up may also transfer an
indelible stain.
•Silicone-based or similar lubricants may cause damage to the
simulator.
•Use uncuffed 4.0 mm I.D. endotracheal tubes or smaller.
•Damage to the gum line, tongue, oral and nasal pharanx, larynx,
epiglottis, arytenoids, false and true vocal cords, cricoid ring,
trachea rings, trachea, and esophagus must be returned to Nasco
for repair.
•Actual product may vary slightly from photo. Nasco reserves the
right to change product color, materials, supplies, or function as
needed.
Supplies and Replacement Parts
LF03598U Replacement Stomach
LF03599U Replacement Lung Set
LF03644U 8-oz. Pump Spray Lubricant
LF09919U Nasco Cleaner
NP066_94_LF03623_InfantAirwayHeadStand.indd 6 9/24/14 8:09 AM

Supplies and Replacement Parts
5
LF03598 Replacement Stomach
LF03599 Replacement Lung Set
LF03644 8-oz. Pump Spray Lubricant
LF09919 Nasco Cleaner

NASCO HEALTHCARE
16 Simulaids Drive
Saugerties, NY 12477
1-833-NASCOHC (627-2642)
[e-mail]
www.nascohealthcare.com
NP66-94 06/21
©2021 NASCO HEALTHCARE
Other Available Simulators
901 Janesville Avenue, P.O. Box 901
Fort Atkinson, Wisconsin 53538-0901
1-800-558-9595
eNasco.com • E-mail: [email protected]
901 Janesville Avenue, P.O. Box 901
Fort Atkinson, Wisconsin 53538-0901
1-800-558-9595
eNasco.com • E-mail: [email protected]
Fort Atkinson Fort Atkinson
LF03601U Adult Airway Management
Trainer with Stand
LF03602U Adult Airway Management
Trainer with Stand
LF03609U Child Airway Management
Trainer with Stand
LF03616U Child CRiSis™ Manikin
LF03617U Deluxe Child CRiSis™
Manikin with Arrhythmia Tutor
LF03620U PALS Update Kit
LF03623U Infant Airway Management
Trainer with Stand
LF03632U Child Intraosseous Infusion/
Femoral Access Leg on a Stand
LF03633U Child Airway Management
Trainer Torso
LF03693U Basic Buddy
®
CPR Manikin
LF03699U “Airway Larry“ Airway
Management Trainer
LF03709U Infant CRiSis™ Manikin
LF03720U Basic Buddy
®
Infant CPR
Manikin
LF03770U Chest Tube
LF03953U CRiSis™ Manikin, Complete
LF03955U Deluxe CRiSis™ Manikin
LF03956U Deluxe “Plus” CRiSis™
Manikin
LF03965U Adult CRiSis™ Auscultation
Manikin
LF03601U Adult Airway Management
Trainer with Stand
LF03602U Adult Airway Management
Trainer with Stand
LF03609U Child Airway Management
Trainer with Stand
LF03616U Child CRiSis™ Manikin
LF03617U Deluxe Child CRiSis™
Manikin with Arrhythmia Tutor
LF03620U PALS Update Kit
LF03623U Infant Airway Management
Trainer with Stand
LF03632U Child Intraosseous Infusion/
Femoral Access Leg on a Stand
LF03633U Child Airway Management
Trainer Torso
LF03693U Basic Buddy
®
CPR Manikin
LF03699U “Airway Larry“ Airway
Management Trainer
LF03709U Infant CRiSis™ Manikin
LF03720U Basic Buddy
®
Infant CPR
Manikin
LF03770U Chest Tube
LF03953U CRiSis™ Manikin, Complete
LF03955U Deluxe CRiSis™ Manikin
LF03956U Deluxe “Plus” CRiSis™
Manikin
LF03965U Adult CRiSis™ Auscultation
Manikin
COPYRIGHT © NASCO 1994 PRINTED IN U.S.A. NP66-94/RV 9-14 COPYRIGHT © NASCO 1994 PRINTED IN U.S.A. NP66-94/RV 9-14
Other Available Simulators Other Available Simulators
LF03609U
LF03609U
LF03601U
LF03601U
LF03709U
LF03709U
NP066_94_LF03623_InfantAirwayHeadStand.indd 8 9/24/14 8:09 AM