Nokia TFF-3 Series User manual

Technical Documentation
Programs After Market Services (PAMS)
Copyright E1999. Nokia Mobile Phones Ltd. All Rights Reserved.
SERVICE
MANUAL
[NMP Part No.0275402 + Update 0275437]
TFF-3 SERIES
WLL TERMINAL
(FOR USE ON THE NMT–450 NETWORK)
Issue 2 : 02/00

TFF-3
Foreword PAMS Technical Documentation
Issue 2 02/00
Page 2 ENokia Mobile Phones Ltd.
AMENDMENT RECORD SHEET
Amendment
Number Date Inserted By Comments
08/99 OJuntune Issue1
Issue 2 02/00 J Watson Section 03:
WN1 Basic Parts List (v. 3.8) added
WN1C Variation Module Parts List
(v. 1.4) added.
WN1T Variation Module Parts List
(v. 1.3) added.
WN1F Variation Module Parts List
(v 1.4) added.
JM1 Layout 07 added.
New pagination.

TFF-3
Foreword
PAMS Technical Documentation
Issue 2 02/00 Page 3 ENokia Mobile Phones Ltd.
Chapter1
Foreword

TFF-3
Foreword PAMS Technical Documentation
Issue 2 02/00
Page 4 ENokia Mobile Phones Ltd.
TFF-3
SERIES CELLULAR PHONES
SERVICE MANUAL
CONTENTS:
Chapter 1: Foreword
Chapter 2: General Information
Chapter 3: System Module JM1
Chapter 4: Transceiver TFF–3 variants
Chapter 5: Service Software Instructions
Chapter 6: Tuning Instructions
Chapter 7: Service Tools
Chapter 8: Troubleshooting Instructions
Chapter 9: Non–serviceable Accessories

TFF-3
Foreword
PAMS Technical Documentation
Issue 2 02/00 Page 5 ENokia Mobile Phones Ltd.
IMPORTANT
This document is intended for use by qualified service personnel only.
Company Policy
Ourpolicyisofcontinuousdevelopment;detailsofalltechnicalmodificationswill
be included with service bulletins.
Whileeveryendeavourhasbeenmadetoensuretheaccuracyofthisdocument,
some errors may exist. If any errors are found by the reader, NOKIA MOBILE
PHONES Ltd should be notified in writing.
Please state:
Title of the Document + Issue Number/Date of publication
Latest Amendment Number (if applicable)
Page(s) and/or Figure(s) in error
Please send to: Nokia Mobile Phones Ltd
PAMS Technical Documentation
PO Box 86
24101 SALO
Finland

TFF-3
Foreword PAMS Technical Documentation
Issue 2 02/00
Page 6 ENokia Mobile Phones Ltd.
Warnings and Cautions
Please refer to the phone’s user guide for instructions relating to operation,
care and maintenance including important safety information. Note also the
following:
Warnings:
1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES
FITTED WITH ELECTRONIC ENGINE MANAGEMENT
SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER
CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN
AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE
VEHICLE DEALER/MANUFACTURER TO DETERMINE THE
IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF
ENERGY.
2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED
IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE
ATMOSPHERES EG PETROL STATIONS (SERVICE STATIONS),
BLASTING AREAS ETC.
3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT,
INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH
THE FUNCTIONALITY OF INADEQUATELY PROTECTED
MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE
MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE
ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY
ALSO BE SUBJECT TO INTERFERENCE.
Cautions:
1. Servicing and alignment must be undertaken by qualified
personnel only.
2. Ensure all work is carried out at an anti–static workstation and that
an anti–static wrist strap is worn.
3. Ensure solder, wire, or foreign matter does not enter the telephone
as damage may result.
4. Use only approved components as specified in the parts list.
5. Ensure all components, modules screws and insulators are
correctly re–fitted after servicing and alignment. Ensure all cables
and wires are repositioned correctly.