Nokia 3806 User manual

Nokia Customer Care
Service Manual
RM-583 (Nokia 3806; L3&4)
Mobile Terminal
Part No: (Issue 1)
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia. All rights reserved.

RM-583
Amendment Record Sheet
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
ii Issue 1
Amendment Record Sheet
Amendment No Date Inserted by Comments
Issue 1 10/2009 Lancy.Yang

RM-583
Copyright
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
iii
Issue 1
Copyright
Copyright© 2009 Nokia. All rights reserved.
Reproduction, transfer, distribution or storage of part or all of the contents in this document in any form without
the prior written permission of Nokia is prohibited.
Nokia, Nokia Connecting People, X and Y are trademarks or registered trademarks of Nokia Corporation. Other
product and company names mentioned herein may be trademarks or tradenames of their respective owners.
Nokia operates a policy of continuous development. Nokia reserves the right to make changes and
improvements to any of the products described in this document without prior notice.
Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental,
consequential or indirect damages howsoever caused.
The contents of this document are provided "as is". Except as required by applicable law, no warranties of any
kind, either express or implied, including, but not limited to, the implied warranties of merchantability and fitness
for a particular purpose, are made in relation to the accuracy, reliability or contents of this document. Nokia
reserves the right to revise this document or withdraw it at any time without prior notice.
The availability of particular products may vary by region.
IMPORTANT
This document is intended for use by qualified service personnel only.

RM-583
Warnings and cautions
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
iv Issue 1
Warnings and cautions
Please refer to the phone’s user guide for instructions relating to operation, care and maintenance including
important safety information. Note also the following:
WARNINGS
zCARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE
MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT
CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT
THE VEHICLE DEALER/MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE
ELECTRONIC SYSTEMS TO RF ENERGY.
zTHE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN
POTENTIALLY EXPLOSIVE ATMOSPHERES, EG PETROL STATIONS (SERVICE STATIONS),
BLASTING AREAS ETC.
zOPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES,
MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES.
CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY
QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
CAUTIONS
zServicing and alignment must be undertaken by qualified personnel only.
zEnsure that all work is carried out at in anti–static workstation and that an anti–static wrist strap is worn.
zUse only approved components as specified in the parts list.
zEnsure that all components, modules screws and insulators are correctly re–fitted after servicing and
alignment.
zEnsure that all cables and wires are correctly repositioned.

RM-583
For your satety
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
v
Issue 1
For your safety
QUALIFIED SERVICE
Only qualified personnel may install or repair mobile terminal equipment.
ACCESSORIES AND BATTERIES
Use only approved accessories and batteries. Do not connect incompatible products.
CONNECTING TO OTHER DEVICES
When connecting to any other device, read its user’s guide for detailed safety instructions. Do not connect
incompatible products.

RM-583
ESD protection
ESD protection
Nokia requires that product service points have sufficient ESD protection (against
static electricity) when servicing products.
Any product of which the covers are removed must be handled with ESD protection.
The SIM card can be replaced without ESD protection if the product is otherwise
ready for use.
To replace the covers ESD protection must be applied.
All electronic parts of the product are susceptible to ESD. Resistors, too, can be
damaged by static electricity discharge.
All ESD sensitive parts must be packed in metallized protective bags during
shipping and handling outside any ESD Protected Area (EPA).
Every repair action involving opening the product or handling the product
components must be done under ESD protection.
ESD protected spare part packages MUST NOT be opened/closed out of an ESD
Protected Area.
For more information and local requirements about ESD protection and ESD
Protected Area, contact your local Nokia After Market Services representative.
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
vi Issue 1

RM-583
Care and maintenance
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
vii
Issue 1
Care and maintenance
This product is of superior design and craftsmanship and should be treated with care. The suggestions
below will help you to fulfill any warranty obligations and to enjoy this product for many years.
Keep the phone and all its parts and accessories out of the reach of small children.
Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will
corrode electronic circuits.
Do not use or store thephone in dusty, dirty areas. Its moving parts can be damaged.
Do not store the phone in hot areas. High temperatures can shorten the life of electronic devices, damage
batteries, and warp or melt certain plastics.
Do not store the phone in cold areas. When it warms up (to its normal temperature), moisture can form
inside, which may damage electronic circuit boards.
Do not drop, knock or shake the phone. Rough handling can break internal circuit boards.
Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the phone.
Do not paint the phone. Paint can clog the moving parts and prevent proper operation.
Use only the supplied or an approved replacement antenna. Unauthorized antennas, modifications or
attachments could damage the phone and may violate regulations governing radio devices.
All of the above suggestions apply equally to the product, battery, charger or any accessory.

RM-583
Company policy
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
viii
Issue 1
Company policy
Our policy is of continuous development; details of all technical modifications will be included with service
bulletins.
While every endeavor has been made to ensure the accuracy of this document, some errors may exist. If
any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing.
Please state:
Title of the Document + Issue Number/Date of publication
Latest Amendment Number (if applicable)
Page(s) and/or Figure(s) in error
Please send to:
NOKIA CORPORATION
Nokia Mobile Phones Business Group
Nokia Customer Care
PO Box 86
FIN-24101 SALO
Finland

RM-583
Battery information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
ix
Issue 1
Battery information
Note that a new battery's full performance is achieved only after two or three complete charge and
discharge cycles!
The battery can be charged and discharged hundreds of times but it will eventually wear out. When the
operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery.
Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers
approved by the manufacturer. Unplug the charger when not in use. Do not leave the battery connected to a
charger for longer than a week, since overcharging may shorten its lifetime. If left unused a fully charged
battery will discharge itself over time.
Temperature extremes can affect the ability of your battery to charge.
For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by leaving the
product switched on until it turns itself off (or by using the battery discharge facility of any approved
accessory available for the product). Do not attempt to discharge the battery by any other means.
Use the battery only for its intended purpose.
Never use any charger or battery that is damaged.
Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object (coin, clip or pen)
causes direct connection of the + and – terminals of the battery (metal strips on the battery) for example
when you carry a spare battery in your pocket or purse. Short-circuiting the terminals may damage the
battery or the connecting object.
Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions, will reduce
the capacity and lifetime of the battery. Always try to keep the battery between 15°C and 25°C (59°F and
77°F). A phone with a hot or cold battery may temporarily not work, even when the battery is fully charged.
Batteries' performance is particularly limited in temperatures well below freezing.
Do not dispose of batteries in a fire!
Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste.

RM-583
Battery information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
x
Issue 1
(This page left intentionally blank.)

RM-583
Nokia 3806 Service Manual Structure
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
xi
Issue 1
Nokia 3806 Service Manual Structure
1- General Information
2- Parts Lists and Exploded View
3- Service Software Instruction
4- Service Tools
5- Antenna Description and Troubleshooting
6- Baseband Description and Troubleshooting
7- RF Description and Troubleshooting
8- Schematics
Glossary

RM-583
Nokia 3806 Service Manual Structure
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
xii
Issue 1
(This page left intentionally blank.)

COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Page 1-1 Issue 1
Nokia Customer Care
1- General Information

RM-583
General Information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Issue 1Page 1-2
(This page left intentionally blank.)

RM-583
General Information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Page 1-3Issue 1
Table of Contents
Product selection....................................................................................................................page 1-5
RM-583 PCI overview...............................................................................................................page 1-6
Phone features and sales package..........................................................................................page 1-7
Accessories............................................................................................................................page 1-8
Technical Specifications..........................................................................................................page 1-9
General specifications.....................................................................................................page 1-9
Battery endurance...........................................................................................................page 1-9

RM-583
General Information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Issue 1Page 1-4
(This page left intentionally blank.)

RM-583
General Information
Product selection
RM-583 (Nokia 3806) mobile terminal offers a CDMA single band engine and supports following
features:
Figure 1: View of RM-583
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Page 1-5Issue 1

RM-583
General Information
RM-583 PCI overview
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Issue 1Page 1-6

RM-583
General Information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Page 1-7Issue 1
Phone features and sales package
Hardware & Mechanics
z800MHz, CDMA2000 1xRTT
z2.2” 240*320 QVGA, 262K
zCamera 1.92MP
z4-way Navigation Keys
zInternal antenna
zIHF speaker
zBattery (860mAh, BL-4C)
zFM radio
zRUIM
z2.5mm stereo and mono headset jack
zMicro-USB 2.0
zWhite Backlighting
zLanyard notch/ hole
zBluetooth 2.1
zSDCC 2.0
SW
zBrew 3.1
zVoice mail
zMultimedia (music/video/media player)
zDownload/DRM
zKeypad lock via software
zWAP browser
zLong SMS, MMS, Instant Messaging and vCard
zAlarm Clock; Calculator; Calendar; Timer; World Clock; Translator Application
zOTAPA/OTASP supported

RM-583
General Information
COMPANY CONFIDENTIAL
Copyright © 2009 Nokia.All rights reserved.
Issue 1Page 1-8
zAirplane Mode supported
zOMSI Interface supported
zSupport GIF,JPG,PNG image formats and BMP image formats
z72 polyphonic chords, MIDI, AAC, AAC+, EAAC+, MP3 supported
Sales package contents
zTransceiver: RM-583
zStandard Battery (860 mAh Li-on): BL-4C
zCharger: AC-6
zUser Guide
Accessories
Supported accessories
Type Name
DC-6 Car Charger
AC-6 Travel Charger
HF200 Car Kits
HS-47 Stereo Headset
WH-200 Mono Headset
BH214 Stereo Bluetooth
BH104 Mono Bluetooth
HF310 BT speakerphone
CA-101 Micro USB Cable