Pentair EVERPURE QL3B User manual

SPECIFICATIONS FOR A SINGLE UNIT
A two-part unit consisting of a permanently mountable head assembly complete with integral shut-off valve and mounting
bracket, and a disposable cartridge which installs into the head.
HEAD ASSEMBLY - Reinforced nylon-only part in head assembly in contact with water. Multi-position, zinc-coated steel bracket.
Quick-Change Cartridges - Aluminum pressure vessel, with a bonded lining of polyolefin, sealed to an ABS top cap.
SELECTING A LOCATION
Mount the Water Filter in the vertical position only!
The location selected for the installation should:
1. Allow clearance for valve handle travel.
2. Allow clearance on either side of the blue ring so it can be grasped and turned.
3. Allow the cutout under the ring label to be clearly seen in both the raised and lowered positions to simplify cartridge
changing.
4. Allow a minimum of 2.5” (6.5 cm) under the cartridge so it can be lowered for removal.
5. Allow space for “in” and “out” water line connections.
INSTALLATION INSTRUCTIONS
NOTE: For installations in Australia and New Zealand product must be installed with a backflow prevention device in accordance with
AS/NZS 3500 and AS/NZS 2845.1.
Before the filter can be installed, the bracket must be removed and remounted in the position best suited to your installation. In
the center position (illustration B), three screws can be used. When the bracket is mounted 45° to the left or right of center (see
illustrations A and C), only two screws are used.
Refer to the instructions printed on the cartridge label for cartridge replacement.
After installation is completed, be sure to double-check that the incoming water line is connected to the inlet opening of the
QL3B Head, and the faucet line is connected to the outlet opening of the head. If in doubt, check the direction-of-flow arrow
molded into the top of the head. Flush cartridge by running water through at full force. This will purge air and fines. Please refer
to the chart below and corresponding cartridge to obtain required flushing time.
FILTER
TYPE
FLUSH
TIME
2DC 5 Minutes
AC 5 Minutes
AC25 Minutes
4C†5 Minutes
4C25 Minutes
4H†5 Minutes
4H25 Minutes
4DC 5 Minutes
OCS2†5 Minutes
OW200L 5 Minutes
FILTER
TYPE
FLUSH
TIME
BH25 Minutes
2CB5†5 Minutes
4CB5†5 Minutes
7CB5†5 Minutes
2CB5-K†5 Minutes
4CB5-K†5 Minutes
7CB5-K†5 Minutes
2CB5-S†5 Minutes
4CB5-S†5 Minutes
7CB5-S†5 Minutes
FILTER
TYPE
FLUSH
TIME
MC2†5 Minutes
MH25 Minutes
OW2 Plus 5 Minutes
OW4 Plus 5 Minutes
XC25 Minutes
2K Plus 5 Minutes
4K Plus 5 Minutes
†Denotes WaterMark
FOODSERVICE EVERPURE QL3B FILTER SYSTEMS INSTRUCTION AND OPERATION GUIDE
EVERPURE®QL3B FILTER SYSTEMS

AS/NZS 3497
WM-40204, 40205
Global-Mark.com.au
PARTS LIST FOR SINGLE UNIT
KEY DESCRIPTION PART NO.
AQL3B Head (12 pack) (shown) EV9259-24
BReplacement Cartridges Contact Factory
C#10 x 3/8" Self-tapping Screw (2 required) EV3062-04
Washer Lock #10 Ext Tooth Pltd (2 required) not shown EV3062-04
NOTES
Check for compliance with state and local laws and regulations.
Do not use with water that is microbiologically unsafe, or of
unknown quality without adequate disinfection before or after
the system. Systems certified for cyst reduction may be used on
disinfected waters that may contain filterable cysts.
This drinking water system must be maintained according
to the manufacturer’s instructions (including replacement
of the cartridge).
For installations in Massachusetts, the Commonwealth of
Massachusetts Plumbing Code 248 CMR shall be adhered to.
Consult your licensed plumber for installation of the system.
This system and its installation must comply with state and
local regulations.
WARNING: FOR CORRECT OPERATION OF THIS
APPLIANCE IT IS ESSENTIAL TO OBSERVE
THE MANUFACTURER’S INSTRUCTIONS.
The QL3B-2CB5, 2CB5-K, 2CB5-S, 4CB5, 4CB5-K,
4CB5-S, 7CB5, 7CB5-K & 7CB5-S Systems are Tested and
Certified against NSF/ANSI Standard 42 for the reduction
of the claims specified on the Performance Data Sheet.
The QL3B-2DC, 4C, 4C2, 4H, 4H2, AC, AC2, BH2, 4DC,
MC2, MH2, XC2, 2K Plus, 4K Plus, OCS2, OW2 Plus, OW4
Plus & OW200L are Tested and Certified against NSF/
ANSI Standard 42 and 53 for the reduction of the claims
specified on the Performance Data Sheet.
B
C
Q
L
3
B
QL
3
B
A
2 EVERPURE QL3B FILTER SYSTEMS INSTRUCTION AND OPERATION GUIDE

LIMITED WARRANTY
COMMERCIAL WATER TREATMENT EQUIPMENT
You have just purchased one of the finest water treatment units made. As an expression of confidence in this product, Pentair Filtration
Solutions, LLC (“PFS”) offers the following product warranty. This product is warranted against material defects in materials and
workmanship to the original end-user when installed in accordance with the PFS specifications. The warranty period commences on the
date of purchase and is administered as follows:
For a period of ONE YEAR Replaceable elements (i.e., filter & water treatment cartridges)*
For a period of FIVE YEARS The entire system (excluding replaceable elements)
The unit must be used in operating conditions that conform to PFS’s recommended guidelines. This warranty will not apply if the unit
has been modified, repaired or altered by someone not authorized by PFS.
If a part described above is found to have a material defect in materials or workmanship within the specified warranty period, you
should notify Pentair®Everpure technical service at the phone number listed below. Any part found materially defective within the terms
of this warranty will be repaired or replaced (at PFS’s discretion) by your local dealer or Pentair Everpure technical service. You pay only
freight from our factory and local dealer charges. Any item repaired or replaced pursuant to this warranty will be covered under the
original warranty terms of the system.
PFS is not responsible for damage caused by accident, fire, flood, freezing, Act of God, misuse, misapplication, neglect, oxidizing agents
(such as chlorine, ozone, chloramines and other related components), alteration, installation or operation contrary to our printed
instructions, or by the use of accessories or components which do not meet PFS’s specifications. Refer to the specifications section in
the Installation and Operating manual for approved application parameters.
Our product performance specifications are furnished with each water treatment unit. TO THE EXTENT PERMITTED BY LAW,
EVERPURE DISCLAIMS ALL IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION WARRANTIES OF MERCHANTABILITY AND
FITNESS FOR PARTICULAR PURPOSE; TO THE EXTENT REQUIRED BY LAW, ANY SUCH IMPLIED WARRANTIES ARE LIMITED IN
DURATION TO THE PERIOD SPECIFIED ABOVE FOR THE ENTIRE WATER TREATMENT UNIT.
As a manufacturer, we do not know the characteristics of your water supply or the purpose for which you are purchasing this product.
The quality of water supplies may vary seasonally or over a period of time, and your water usage rate may vary as well. Water
characteristics can also differ considerably if this product is moved to a new location. For these reasons, we assume no liability for
the determination of the proper equipment necessary to meet your requirements, and we do not authorize others to assume such
obligations for us. Further, we assume no liability and extend no warranties, express or implied, for the use of this product with a non-
potable water source or a water source which does not meet the conditions for use described in the owner’s guide or performance data
sheet for this product.
OUR OBLIGATIONS UNDER THIS WARRANTY ARE LIMITED TO THE REPAIR OR REPLACEMENT (AT PFS’S DISCRETION) OF THE
FAILED PARTS OF THE WATER TREATMENT UNIT, AND WE ASSUME NO LIABILITY WHATSOEVER FOR DIRECT, INDIRECT, INCIDENTAL,
CONSEQUENTIAL, SPECIAL, GENERAL OR OTHER DAMAGES.
Some states do not allow the exclusion of implied warranties or limitations on how long an implied warranty lasts, so the above
limitation may not apply to you. Similarly, some states do not allow the exclusion of incidental or consequential damages, so the above
limitation or exclusion may not apply to you. This warranty gives you specific legal rights, and you may also have other rights which vary
from state to state.
*Warranty applies to material defects in materials & workmanship only.
3EVERPURE QL3B FILTER SYSTEMS INSTRUCTION AND OPERATION GUIDE

WATER FILTRATION
EVERPURE-SHURFLO WORLD HEADQUARTERS, 1040 MUIRFIELD DRIVE, HANOVER PARK, IL 60133 USA • FOODSERVICE.PENTAIR.COM
800.942.1153 (US ONLY) • 630.307.3000 MAIN • 630.307.3030 FAX • [e-mail] EMAIL
EVERPURE-SHURFLO AUSTRALIA, 1-21 MONASH DRIVE, DANDENONG SOUTH, VIC 3175 AUSTRALIA
011.1300 576 190 TEL • 011.61.39.562.7237 FAX • AU.EVERP[email protected] EMAIL
EVERPURE-SHURFLO CHINA, 21F CLOUD 9 PLAZA, NO 1118, SHANGHAI, 200052, CHINA
86.21.3211.4588 TEL • 86.21.3211.4580 FAX • [email protected] EMAIL
EVERPURE-SHURFLO INDIA, GREEN BOULEVARD, B-9/A, 7TH FLOOR - TOWER B SECTOR 62, NOIDA - 201301
91.120.419.9444 TEL • 91.120.419.9400 FAX • INDIACUSTOM[email protected] EMAIL
EVERPURE-SHURFLO EUROPE, PENTAIR WATER BELGIUM BVBA, INDUSTRIEPARK WOLFSTEE, TOEKOMSTLAAN 30, B-2200 HERENTALS, BELGIUM
+32.(0).14.283.504 TEL • +32.(0).14.283.505 FAX • [e-mail] EMAIL
EVERPURE-SHURFLO JAPAN INC., HASHIMOTO MN BLDG. 7F, 3-25-1 HASHIMOTO, MIDORI-KU, SAGAMIHARA-SHI KANAGAWA 252-0143, JAPAN
81.(0)42.775.3011 TEL • 81.(0)42.775.3015 FAX • [e-mail] EMAIL
EVERPURE-SHURFLO SOUTHEAST ASIA, 390 HAVELOCK ROAD, #04-01 KING’S CENTRE, SINGAPORE 169662
65.6768.5800 TEL • 65.6737.5149 FAX • [e-mail] EMAIL
Pentair trademarks and logos are owned by Pentair plc or its affiliates. Third party registered and unregistered trademarks and logos are property of their
respective owners. Because we are continuously improving our products and services, Pentair reserves the right to change specifications without prior notice.
Pentair is an equal opportunity employer.
© 2017 Pentair Filtration Solutions, LLC. All Rights Reserved. 3126-56 Rev B OC17