Pentair ONGA FREEFLO FFCL-15-RPQ User manual

FFCL-15-RPQ
FFCL-25-RPQ
FFCL-35-RPQ
L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 1L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 1 30/03/2021 10:22:04 AM30/03/2021 10:22:04 AM

L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 2L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 2 30/03/2021 10:22:06 AM30/03/2021 10:22:06 AM

L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 3L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 3 30/03/2021 10:22:09 AM30/03/2021 10:22:09 AM

From pool
skimmer /
main drain
To pool
return jets
Backwash
to sewer
L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 4L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 4 30/03/2021 10:22:11 AM30/03/2021 10:22:11 AM

From pool
skimmer /
main drain
To pool
return jets
Backwash
to sewer
To solar
From solar
Check-valve
Actuator valve
From pool
skimmer /
main drain
To pool
return jets
Backwash
to sewer
Check-valve
L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 5L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 5 30/03/2021 10:22:13 AM30/03/2021 10:22:13 AM

L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 6L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 6 30/03/2021 10:22:15 AM30/03/2021 10:22:15 AM

L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 7L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 7 30/03/2021 10:22:17 AM30/03/2021 10:22:17 AM

L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 8L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 8 30/03/2021 10:22:20 AM30/03/2021 10:22:20 AM

FAULT / PROBLEM POSSIBLE CAUSE REMEDY
No ow.
All chlorine output LED`s
ashing as per page 4, note1.
Pump turned Off. Ensure pump is turned ON.
Closed valve. Open valve.
Air in system. Check all O-rings & grease.
Dirty lter. Clean or backwash lter.
Low water level. Fill up pool.
Calcium build-up on water probe
sensor.
Clean probe in a mild hydrochloric
acid- ref. page 4.
High Salt
Red LED illuminated.
Salt level too high,
above 4500ppm.
Turn chlorine control clockwise as per
page 7 note 2, until salt levels reduce.
Comment: This remedy does NOT
reduce the salt levels in the pool water,
it reduces the chlorine output of the
chlorinator to protect it.
No lights.
Circuit Breaker tripped. Page 3. Fig.6 Reset Circuit Breaker as per
page 8, note 6.
Mains power failure. Check switches and switchboard
circuit breaker.
Low / No chlorine
production.
Chlorine output too low. Increase chlorine production as per
page 7, note 2.
Salt level too low. Increase salt level to 4000ppm and
check stabiliser (Cyanuric) levels.
PH too high. Adjust PH between 7.2-7.4
Timer period too short. Increase running time.
High phosphate levels. Add starver.
Cell connection. Check connection at the junction box
on the underside of the unit.
Abnormal calcium
build-up in cell.
Calcium levels in swimming pool water
extremely high or water chemistry.
Reduce calcium level in pool. Lower
water level and ll with clean water.
Use a calcium reduction agent. Clean
cell with mild HCl solution.
Timer times-out of sync.
Timer not set correctly. Check setting procedure as per
page 7, note 5.
Chlorinator installed on off-peak tariff. Timer will need battery backup if
installed on off tariff.
Timer / Off / Manual switch not switched
correctly.
Make sure switch is selected as per
page 8, note 7.
Over temperature
Red LED only.
Salt too high, above 4500ppm.
Turn chlorine control clockwise as per
page 7, note 2. until salt levels (no other
lights) reduce.
Comment: This remedy does NOT
reduce the salt levels in the pool water,
it reduces the chlorine output of the
chlorinator to protect it.
Installed in an area where the ambient
temperature is extremely high.
Supply adequate cooling. Install outside
of the extreme temperature area.
L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 9L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 9 30/03/2021 10:22:21 AM30/03/2021 10:22:21 AM

NO. PART NO. QTY. DESCRIPTION
1801933 Replacement Cell 15g
1801934 Replacement Cell 25g
1801935 Replacement Cell 35g
2801936 Time Clock
3801937 Power PCB Kit
4801938 Control PCB Kit
5801939 Control PCB Knob
6801940 Transformer
7801941 Cell Lock Nut
8801942 O-ring Cell Union
9801943 Cell Casing
10 801944 Perspex Cover
7
8
9
1
10
2
6
3
5
4
L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 10L300266 C - 0321_FreeFlo Salt Chlorinator_Owners Manual_FA.indd 10 30/03/2021 10:22:26 AM30/03/2021 10:22:26 AM