Precor EFX 5.33 User manual

page 1
Owner’s Manual
Elliptical Fitness
Crosstrainer

page 2
When using an electrical appliance, basic precautions should always be taken,
including the following:
• Read all instructions before using the EFX®5.33.These instructions are
written to ensure your safety and to protect the unit.
Before beginning any fitness program, you should obtain a complete physical
examination by your physician.
Il est conseillé de subir un examen médical complet avant d’entreprendre tout
programme d’exercise. Si vous avez des étourdissements ou des faiblesses,
arrêtez les exercices immédiatement.
DANGER
To reduce the risk of electrical shock always unplug the EFX5.33 from the
electrical outlet immediately after using and before cleaning.
WARNING
To reduce the risk of burns, fire, electric shock, or injury to persons, take the
following precautions:
•When it is plugged in, do not leave the EFX5.33 unattended. Unplug the unit
from the power source when it is not in use, and before putting on or taking
off parts.
• Do not allow children on or near the EFX5.33.
• Use the EFX5.33 only for its intended purpose as described in this manual.Do
not use accessory attachments that are not recommended by the manufac-
turer—such attachments might cause injuries.
• Never operate the unit if it has a damaged cord or plug, if it is not working
properly, if it has been dropped or damaged, or dropped in water. Return
the EFX5.33 to a service center for examination and repair.
• Keep the power cord and plug away from heated surfaces.
• Never drop or insert objects into any opening. Keep hands away from moving
parts.
• Do not use outdoors.
• Do not operate where aerosol (spray) products are being used or where
oxygen is being administered.
• When the EFX5.33 is not in use, disconnect the unit by turning the power
switch to the OFF (O) position, then remove the power plug from the wall
outlet.
WARNING
Connect the EFX to a properly grounded outlet only. See Grounding Instructions
on page 5.
IMPORTANT SAFETY INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS

page 3
Personal Safety
When using the , take the following precautions:
• Do not allow children on or near the EFX5.33. Do not leave children unsuper-
vised around the unit.
• Assemble and operate the unit on a solid, level surface. Locate the EFX5.33 a few
feet from walls or furniture. Keep the area behind the unit clear.
• Maintain the EFX5.33 in good working condition. (Refer to the
Maintenance
section.) Run through a check list prior to each use.
• Keep all electrical components, such as the power cord and I/O switch, away from
liquids to prevent shock. Do not set anything on the handrails, display console, or
casing.Place liquids in the appropriate receptacles.
• Wear proper exercise clothing and shoes for your workout—no loose clothing.
Do not wear shoes with heels or leather soles.Tie long hair back. Keep towels
away from moving parts.
• Use care when getting on or off the unit. Use the stationary handrail whenever
possible.Keep your body and head facing forward. Never attempt to turn around
on the EFX.
Diagram 1
Avoid injury from the roller
arm mechanism.
Handlebar
Lower pivot arm
(handlebar linkage)
• Never place your hand(s) or feet in the path of the roller arm because injury may
occur to you or damage may occur to the equipment. Refer to Diagram 1.
• Do not rock the unit. Do not stand on the handrails, display console, or casing.
• Do not attempt to service the unit yourself other than the assembly and mainte-
nance instructions found in this manual. Refer to
Obtaining Service .
• Do not overexert yourself or work to exhaustion.If you feel any pain or abnormal
symptoms, stop your workout immediately and consult your physician.
Precor products are designed for the enjoyment of the serious runner as well as
the dedicated walker. By following the above precautions and using good common
sense, you will have many safe and pleasurable hours of healthful exercise with
your EFX5.33.
Precor Heart Rate Option—Safety Guidelines
A heart rate receiver is installed in the EFX5.33 display console. It is activated when
you wear a POLAR®chest strap during your workout. Once a heart beat is detected,
it is displayed on the console.
The Precor Heart Rate Option was created and designed exclusively for Precor
products.The equipment is extremely sensitive—you should use the heart rate option
with this in mind and take time to read the guidelines found on page 32.
Ramp

page 4
RFI — Radio Frequency Interference
Federal Communications Commission, Part 15
The EFX®5.33 has been tested and found to comply with the limits for a Class B
digital device, pursuant to Part 15 of the FCC Rules.These limits are designed to
provide reasonable protection against harmful interference in a residential installa-
tion.The EFX5.33 generates, uses, and can radiate radio frequency energy and, if
not installed and used in accordance with the owner’s manual instructions, may
cause harmful interference to radio communications. However, there is no guarantee
that interference will not occur in a particular installation.
If the EFX5.33 does cause harmful interference to radio or television reception, which
can be determined by turning the unit OFF and ON, you are encouraged to try to
correct the interference using one or more of the following measures:
• Reorient or relocate the receiving antenna for your TV, radio, VCR, etc.
• Increase separation between the unit and the receiver (TV, radio, etc.).
• Connect the unit into a different power outlet—on a dedicated circuit different
from the one used by the receiver (TV, radio, etc.). No other appliance should be
plugged into the same power outlet that the is connected to.
• Consult an experienced radio/TV technician for help.
CAUTION
Canadian Department of Communications
This digital apparatus does not exceed the Class B limits for radio noise emissions
from digital apparatus set out in the Radio Interference Regulations of the Canadian
Department of Communications.
Le présent appareil numérique n’émet pas de bruits radioéélectriques dépassant les
limites applicables aux appareils numériques de la class B prescrites dans le
Règlement sur le brouillage radioélectrique édicté par le ministére des Communica-
tions du Canada.
European Applications
This product conforms to the requirements of the European Council Directive 89/336/
EEC, Electromagnetic Compatibility and has been tested to the following standards:
EN55022, Limits & Methods of Measurement of Radio Interference, Information
Technology Equipment (Class A).
EN50082-1, Generic Immunity Standard for Residential, Commercial and Light
Industrial Products (Class A).
This product additionally conforms to the requirements of the European Council
Directive 73/23/EEC, Low Voltage Directive and has been tested to the following
standard:
IEC 335-1, Safety of Household and similar Electrical Appliances.
Per FCC rules, changes or modifications to the unit
not expressly approved by Precor, could void the
user’s authority to operate the equipment.

page 5
Safety Approval
When identified with the ETL-c logo, the unit has been tested and conforms to the
requirements of CAN/CSA-E-335-1/2-94, Safety of Household and Similar Electrical
Appliances.
Grounding Instructions
The EFX5.33 must be grounded.If it should malfunction or break down, grounding
provides a path of least resistance for electric current which reduces the risk of
electrical shock.The unit is equipped with a power cord having an equipment-
grounding conductor and a grounding plug.The plug must be inserted into an
appropriate outlet that is properly installed and grounded in accordance with all local
codes and ordinances. If you do not follow these Grounding Instructions , you could
void the Precor limited warranty.
DANGER
Improper connection of the equipment-grounding conductor can result in a risk of
electric shock. Check with a qualified electrician or service person if you are in doubt as
to whether the is properly grounded. Do not modify the plug provided with the —if it
doesn’t fit the outlet, get a proper outlet installed by a qualified technician.
120V Units Designated for U.S. Markets
The EFX5.33 is for use on a circuit with a nominal 120-volt rating.The unit’s ground-
ing plug looks like the plug illustrated in Diagram 2.The power outlet must have the
same configuration as the plug. No adapter should be used with this product.
ATTENTION: HauteTension
Débranchez avant de réparer
Diagram 2
Correct power outlet for
U.S. Markets: 15 amp
120-volt plug.
120-volt grounding plug

page 6
Important Safety Instructions............................................................. 2
Personal Safety ................................................................................. 3
Precor Heart Rate Option - Safety Guidelines .................................. 3
RFI — Radio Frequency Interference................................................ 4
European Applications ...................................................................... 4
Safety Approval ................................................................................. 5
Grounding Instructions ...................................................................... 5
BeforeYou Begin ..............................................................9
Obtaining Service .............................................................................. 9
Serial Number Location..................................................................... 9
Unpacking the EFX®5.33 ...................................................................10
Optional Equipment ...........................................................................10
Acquiring the Appropriate Tools ........................................................10
Hardware Kit ......................................................................................11
Setting Up the EFX®............................................................................................... 12
Installation Requirements..................................................................12
Assembly Instructions .......................................................................12
Turning the Unit ON and OFF............................................................18
Using the EFX .................................................................19
Removing the Locking Pin.................................................................19
Using the Handlebars........................................................................20
Using the Stationary Handrail ...........................................................20
Workout Tips......................................................................................20
Quick Steps to Working Out ..............................................................21
Cooling Down After a Workout ..........................................................21
Inserting the Locking Pin ...................................................................22
The Setup Mode and the Quick Start Feature...................................22
Pause, Cool Down, Workout Summary, and Exit Features ...............23
The EFX5.33 Display .....................................................25
Features on the Display Console ......................................................25
Smart Rate®Display ..........................................................................26
Heart Rate Display ............................................................................26
Setup Mode and Prompts..................................................................26
Center Display ...................................................................................27
Changing the Display Features Using the SELECT Key...................28
Keypad Tips .......................................................................................29
Special Keypad Functions Precor Banner.........................................29
Keys on the Display Console.............................................................29
Table of Contents
1
2
3
4

page 7
6
7
5AdvancedTechniques for the EFX5.33.........................30
Programming Tips .............................................................................30
Selecting a U.S. Standard or Metric Display......................................30
Viewing the Odometer, Hours of Use,
Software Version, and Error Log........................................................31
The EFX5.33 Course Features and Descriptions........32
Utilizing the Smart Rate®Feature......................................................32
Utilizing Heart Rate Interactive Capabilities ......................................32
Course Descriptions ..........................................................................33
Clearing the Settings on a Custom Course .......................................36
Using the POLAR®Equipment ......................................37
Wearing the POLAR®Chest Strap ....................................................37
Storing the POLAR®Chest Strap......................................................37
Maintaining the EFX .......................................................38
Cleaning the Equipment ....................................................................38
Servicing the EFX..............................................................................38
Long Term Storage ............................................................................38
Exploded Views .................................................................................39
Warranty Card ...................................................................................47
Specifications ..................................................................... back cover
8

page 8
Notes: :

page 9
Thank you for purchasing the Precor EFX®5.33.You can think of your new purchase as
the Elliptical Fitness “total body” Crosstrainer. Upper-body handlebars are mechanically
linked to the lower-body exercise system.The resistance range (1 through 20) simulta-
neously applies to both the lower-body pedals and upper-body handlebars.The incline
is fixed at 25 degrees.
The EFX5.33 offers an easy-to-understand display console that provides motivating
feedback about your workout. It can store workout information for two separate users
so that your last course used, workout time, weight, and age parameters are easily
retrieved.The ultra-sensitive keypad lets you select data and control your workout
session. Precor Smart Rate® — a visual aid that lets you see your heart rate with a glance,
provides the latest in cardiac monitoring. Note that for the heart rate features to appear, a
POLAR®chest strap must be worn.
The EFX5.33 is for household use only.To maximize your use of the EFX, please study
this guide thoroughly.
Obtaining Service
Do not attempt to service the EFX5.33 yourself except for the maintenance procedures
described in this manual.The EFX5.33 does not contain any user-serviceable parts.
For information about product operation or service, check out the Precor Web Site at
www.precor.com or call Precor Customer Support at 1-800-347-4404.
If you contact Precor Customer Support, have your model and serial number available.
Before You Begin
1
This manual explains how to assemble, use,
and maintain the EFX
®
.The following
conventions are used in this manual.
“Note:” Contains additional information that
applies to the preceding text.
“Important:” Indicates information to which
you should pay special attention.
“CAUTION:” Indicates steps or information
necessary to prevent harm to yourself or
damage to the equipment.
“WARNING:” Provides instructions to
prevent electrical damage to the equipment
and prevent injuries to yourself or others.
“DANGER:” Indicates steps you must
take to prevent electrical shock.
Diagram 3
EFX5.33 serial
number label
location.
EFX5.33
Serial Number Location
The serial number on the unit is printed on a label located on the rear cover.To locate
the serial number, verify that the EFXis turned OFF. See Diagram 3. For future
reference, write the serial number and date of purchase in the space provided below.
Model #: ________ Serial #: _________________________ Date purchased: ____

page 10
Unpacking the EFX®5.33
The EFX5.33 is carefully tested and inspected before shipment. Precor ships the unit
in several components, as listed below:
• base frame assembly • left and right handlebars
• upright support • display console assembly
• base frame stabilizers (left and right) • bracket cover
• owner’s manual and hardware kit
Optional Equipment
An additional POLAR®chest strap can be purchased by calling Retail Sales at 1-800-
786-8404 or visiting the Precor web site at www.precor.com.
Carefully unpack the pieces of the unit and lay them on the floor near the
location where you plan to use the EFX.
Acquiring the AppropriateTools
Obtain the following tools before assembling the EFX.
Wire cutter – for cutting wire ties
Phillips head screwdriver
Two 9/16" combination wrench (open-end and crescent)
SAE Standard socket set with socket extension (for 1/2" and 9/16" bolts)
Rubber mallet
CAUTION:This unit weighs over 231
pounds (104 kilograms).To avoid injury
and to ensure the safety of the unit and
yourself, get adequate assistance before
unpacking your EFX
®
. Break down the
container’s side walls before removing
anything from the box.