Rotel RSX-1067 V02 User manual

Technical
Manual
SURROUND SOUND RECEIVER
RSX-1067V02
Table of Contents
Specification......................................1
Parts List...........................................2~13
Adjustment........................................14~15
Disassembly Diagram and List.........16~17
.
Wiring................................................18
PCB Assembly..................................19~25
Schematic Diagram ..........................26~43
SHINSEN-BLD. 4F 10-10 SHINSEN-CHO, SHIBUYA-KU,
TOKYO 150-0045, JAPAN
Serial. NO.
Beginning
®
Quality Uncompromised
Y-373B-0702/pdf
THE ROTEL CO., LTD.
Specifications
Audio
Continuous Amplifier Power
(seven channels driven)
100 watts/ch (20-20k Hz, <0.05% THD, 8 ohms)
Continuous Amplifier Power
(two channels driven)
120 watts/ch (1kHz, <1.0% THD, 8 ohms, DIN)
Total Harmonic Distortion
<0.05%
Intermodulation Distortion (60 Hz:7 kHz)
<0.05%
Frequency Response
10 Hz – 120 kHz, ±3dB (analog bypass)
10 Hz – 95 kHz, ±3dB (digital input)
Signal to Noise Ratio (IHF A-weighted)
95dB (analog bypass)
92dB (Dolby Digital, dts) 0dBFs
Input Sensitivity/Impedance
Line Level: 200 mV/100K ohms
Preamp Output Level/Output Impedance
1.0 V / 1K ohms
Contour (LF/HF)
±6dB at 50 Hz/15 kHz
Decodable Digital Input Signals
Dolby Digital, Dolby Digital EX, DTS, DTS-ES,
DTS 96/24, LPCM (up to 192K), HDCD, MP3,
MPEG Multichannel
Video
Frequency Response
3 Hz – 10 MHz, ± 3dB (Digital Input)
3 Hz – 100 MHz, ± 3dB (Component V ideo)
Signal to Noise Ratio
45dB
Input Impedance
75 ohms
Output Impedance
75 ohms
Output Level
1.0 volt
FM Tuner
Usable Sensitivity
14.2dBf
Signal to Noise Ratio (at 65dBf)
70dBf
Harmonic Distortion (at 65 dBf)
0.03%
Stereo Separation (1 kHz)
45dB
Output level
1 V
Antenna Input
75 ohms unbalanced
AM Tuner
Sensitivity
500 mV/m
Signal to Noise Ratio
40dBf
Output level
500 mV
Antenna Input
Loop Antenna
General
Power Consumption:
990 watts
130 watts (idle)
19 watts (standby)
Power Requirements (AC)
115 volts, 60Hz (USA version)
230 volts, 50Hz (CE version)
Weight
20.4 Kg/44.97 lb.
Dimensions (W x H x D)
432 x 189 x 427 mm
17.01" x 7.44" x 16.81"
Front Panel Height
(feet removed for rack mount)
176 mm / 6.93"
4481001 ~

Surround Sound Receiver
12345
67890 MEMORYDIRECT
BAND
TUNING
MONO
CD TUNER TAPE VIDEO1 VIDEO2 VIDEO3 VIDEO4 VIDEO5
2CH DSP MULTI
INPUT MUTE RECZONE
VOLUME
LF HF
SURROUND SOUND RECEIVER RSX-1067
DTS
Neo 6
DOLBY
PL /3ST
STANDBY
OFF
ON
POWER
21 3 21435IN OUT VIDEO OUT
DIGITAL INPUT DIGITAL OUT
VIDEO INTAPECD
ZONE
OUT
COMPOSITE IN
23451
21
23123451S-VIDEO IN S-VIDEO OUT
213
SOFTWARE
UPGRADABLE
COMPUTER I/O
COMPONENT VIDEO IN
MON
OUT
YP
R
P
B
YP
R
P
B
3
2
1
21
COAXIAL COAXIAL OPTICAL
321
OPTICAL
IR OUT
2 ZONE1
12V TRIG OUT
EXTZONE
REM IN
CB 1REAR LFRONT L SUB 1CENTER 1
CB 2REAR RFRONT R SUB 2CENTER 2
CB 1
REAR L
FRONT L CENTER
CB 2REAR RFRONT R SUB
L
R
MON
OUT
MON
OUT
ZONE
OUT
COMPOSITE OUT
RIGHT
SURROUND FRONT/ZONE
CENTER BACK/ZONE
2/RIGHT 1/LEFT
LEFT
FRONT/ZONE SURROUND
CENTER SPEAKERS
AM
LOOP
ANTENNA
CAUTION
RISK OF ELECTRIC SHOCK
DO NOT OPEN
SURROUND SOUND RECEIVER
MODEL NO. : RSX-1067
POWER CONSUMPTION: 990W
AVIS:
RISQUE DE CHOC ELECTRIQUE–NE PAS OUVRIR
WARNING: SHOCK HAZARD DO NOT OPEN
Manufactured under license
from Dolby Laboratories
Licensing Corporation. "Dolby",
"Pro Logic", "Surround EX", and
the double-D symbol are
trademarks of Dolby Laboraties
Licensing Corporation.
Manufactured under license from Digital
Theater Systems, Inc. US Pat. No. 5,451,942,
5,956674, 5,974,380, 5,978,762, and other
world-wide patents issued and pending.
"DTS" and "DTS Digital Surround" are
registered trademarks of Digital Theater
Systems, Inc. Copyright 1996, 2000 Digital
Theater Systems, Inc. All rights reserved.
RP-421
Appearance
RSX-1067/V02
2

Parts List 1/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
501 E-1309-B PCB ASSY (FL DISPLAY)
IC34 031 RPM7138H9 REMOTE MODULE (REMOTE EYE)
IC31,32,33 031 TD62C950RF IC SMD (FL DRIVER)
FL31 035 HNR22ML02 FL TUBE
D31 037 KDS184RTK DIODE CHIP
C32,33 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C31,34-36 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
R31,33 055 ERJ6ENF10R0V RESISTOR CHIP 10
R32,34 055 ERJ6ENF1002V RESISTOR CHIP 10K
CP31 068 S10B-PH-KS CONNECTOR WAFER 10P
501 X-1358 PCB ASSY (POWER AMPLIFIER)
Q105,205,305,405,505,605,705 033 A1209-ST TRANSISTOR 2SA1209-ST
Q106,206,306,406,506,606,706 033 C2911-ST TRANSISTOR 2SC2911-ST
Q101-104,201-204,301-304,401-404 033 TA1016-FG TRANSISTOR 2SA1016KAA-FG
Q501-504,601-604,701-704,801 033 TA1016-FG TRANSISTOR 2SA1016KAA-FG
Q112,212,312,412,512,612,712 033 TC2362-FG TRANSISTOR 2SC2362KAA-FG
Q802,803 033 TC2362-FG TRANSISTOR 2SC2362KAA-FG
D101,102,201,202,301,302,401,402 034 2058322101 DIODE 1N4148TAP-50
D501,502,601,602,701,702,802 034 2058322101 DIODE 1N4148TAP-50
D801 034 TRD15JST1 ZENER DIODE 15V
D803 034 TRD9.1JST1 ZENER DIODE 9.1V
C113,213,313,413,513,613,713 041 TUTES1A101-7TF ELECTROLYTIC CAPACITOR 10V100uF
C802 041 TUTES1C471-7TF ELECTROLYTIC CAPACITOR 16V470uF
C803 041 TUTES1E101-7TF ELECTROLYTIC CAPACITOR 25V100uF
C108,208,308,408,508,608,708,801 041 TUTES1H010-7TF ELECTROLYTIC CAPACITOR 50V1uF
C101,201,301,401,501,601,701 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C109,110,209,210,309,310,409,410 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C509,510,609,610,709,710 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C111,112,211,212,311,312,411,412 041 TUTES1J471-7TS ELECTROLYTIC CAPACITOR 63V470uF
C511,512,611,612,711,712 041 TUTES1J471-7TS ELECTROLYTIC CAPACITOR 63V470uF
C107,207,307,407,507,607,707 043 TC50V050 CERAMIC CAPACITOR 5pF
C104-106,204-206,304-306,404-406 043 TC50V221 CERAMIC CAPACITOR 200pF
C504-506,604-606,704-706 043 TC50V221 CERAMIC CAPACITOR 220pF
C102,103,202,203,302,303,402,403 043 TC50V331 CERAMIC CAPACITOR 330pF
C502,503,602,603,702,703 043 TC50V331 CERAMIC CAPACITOR 330pF
R807 054 1WS2.7KJF MOF RESISTOR 1W 2.7K
R803 054 1WS3.3KJF MOF RESISTOR 1W 3.3K
R124,125,224,225,324,325,424,425 054 MPC74-0.22 NIR RESISTOR 0.22
R524,525,624,625,724,725 054 MPC74-0.22 NIR RESISTOR 0.22
R805 054 TMF1001 METAL RESISTOR 1K
R117-119,217-219,317-319,417-419 054 TMF16-1000 METAL RESISTOR 1/6W 100
R517-519,617-619,717-719 054 TMF16-1000 METAL RESISTOR 1/6W 100
R101,201,301,401,501,601,701 054 TMF16-1001 METAL RESISTOR 1/6W 1K
R111,211,311,411,511,611,711 054 TMF16-1001 METAL RESISTOR 1/6W 1K
R106,206,306,406,506,606,706 054 TMF16-1002 METAL RESISTOR 1/6W 10K
R801 054 TMF16-1003 METAL RESISTOR 1/6W 100K
R109,209,309,409,509,609,709 054 TMF16-1201 METAL RESISTOR 1/6W 1.2K
R115,215,315,415,515,615,715 054 TMF16-1201 METAL RESISTOR 1/6W 1.2K
R107,108,207,208,307,308,407,408 054 TMF16-1501 METAL RESISTOR 1/6W 1.5K
R507,508,607,608,707,708,804 054 TMF16-1501 METAL RESISTOR 1/6W 1.5K
R126,226,326,426,526,626,726 054 TMF16-1801 METAL RESISTOR 1/6W 1.8K
R127,227,327,427,527,627,727 054 TMF16-2001 METAL RESISTOR 1/6W 2K
R808 054 TMF16-2200 METAL RESISTOR 1/6W 220
R130,230,330,430,530,630,730 054 TMF16-2202 METAL RESISTOR 1/6W 22K
R112,212,312,412,512,612,712 054 TMF16-2702 METAL RESISTOR 1/6W 27K
R110,210,310,410,510,610,710 054 TMF16-3300 METAL RESISTOR 1/6W 330
R102-104,202-204,302-304,402-404 054 TMF16-3302 METAL RESISTOR 1/6W 33K
016 E-1309B00 PCB ASSY
016 X-1358A01-02 PCB ASSY
3

Parts List 2/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
R502-504,602-604,702-704 054 TMF16-3302 METAL RESISTOR 1/6W 33K
R113,114,213,214,313,314,413,414 054 TMF16-3302 METAL RESISTOR 1/6W 33K
R513,514,613,614,713,714 054 TMF16-3302 METAL RESISTOR 1/6W 33K
R105,205,305,405,505,605,705 054 TMF16-4700 METAL RESISTOR 1/6W 470
R116,216,316,416,516,616,716 054 TMF16-4700 METAL RESISTOR 1/6W 470
R120,220,320,420,520,620,720 054 TMF16-47R0 METAL RESISTOR 1/6W 47
R129,229,329,429,529,629,729,806 054 TMF16-6801 METAL RESISTOR 1/6W 6.8K
R121,221,321,421,521,621,721 054 TMF16-82R0 METAL RESISTOR 1/6W 82
R128,228,328,428,528,628,728 054 TMF16-9100 METAL RESISTOR 1/6W 910
R122,123,222,223,322,323,422,423 054 TMF3R30 METAL RESISTOR 3.3
R522,523,622,623,722,723 054 TMF3R30 METAL RESISTOR 3.3
R802 054 TMF6802 METAL RESISTOR 68K
CP851,JP1B 068 B2B-EH CONNECTOR WAFER 2P
501 E-1397 PCB ASSY (INPUT)
L301 021 TAL02TB100K MICRO INDUCTOR 10uH
L302 021 TAL02TB101K MICRO INDUCTOR 100uH
XT301 023 HC49U-001WR CRYSTAL 14.31818MHz
IC230-232 031 ADG704BRM IC SMD (4CH MPX) AD704BRM
IC233,235 031 ADG774BR IC SMD (MPX) ADG774BR
IC211,212 031 HEF4094BT IC SMD (SHIFT REGISTER) HEF4094BT
IC236 031 KS5520-1 IC SMD (SCREEN DISPLAY)
IC234 031 LT1397CS IC SMD (OPE AMP) LT1397CS
IC201-207 031 NJM5532M IC SMD (OPE AMP) NJM5532M
IC223 031 NJM7812FA IC (REGULATOR +12VDC)
IC208-210,215 031 TC9163CFG IC SMD (SWITCH ALLEY)
IC222 031 TC9459F IC SMD (VOLUME) TC9459F
IC213,214,216-221,224 031 TL072CD IC SMD (OPE DUAL) TL072CD
Q201-205 032 KRA107S TRANSISTOR CHIP
Q206-218,224,225 032 KRC231S TRANSISTOR CHIP
Q221 032 KTA1271 TRANSISTOR
D204 037 KDS226RTK DIODE CHIP
D201-203 037 KDS226RTK DIODE CHIP
C349,354-361,365,369-372,390,392 041 TUTES1A101-7TF ELECTROLYTIC CAPACITOR 10V100uF
C366-368,374,386,389 041 TUTES1A471-7TF ELECTROLYTIC CAPACITOR 10V470uF
C229,258-281,298-309,397,398 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
C376,380 041 TUTES1H010-7TF ELECTROLYTIC CAPACITOR 50V1uF
C230-257,282-287,296,297,310-326 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C335-342,345,346,353,393-396 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C379,382 041 TUTES1HR47 ELECTROLYTIC CAPACITOR 50V0.47uF
C387,388 043 TC50VCH330 CERAMIC CAPACITOR 33pF
C377,378 043 TC50VCH560 CERAMIC CAPACITOR 56pF
C383 047 ECJ2VB1H103K CERAMIC CAPACITOR CHIP 0.01uF
C294,295 047 ECJ2VB1H153K CERAMIC CAPACITOR CHIP 0.015uF
C290-293,351,352,399 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C288,289 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C375,385 047 ECJ2VF1H224Z CERAMIC CAPACITOR CHIP 0.22uF
C201-228,327-334,347,348,384 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
C343,344,381 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
R395-398 055 ERJ6ENF10R0V RESISTOR CHIP 10
R399,417,444 055 ERJ6ENF10R0V RESISTOR CHIP 10
R419 055 ERJ6ENF1000V RESISTOR CHIP 100
R418 055 ERJ6ENF1000V RESISTOR CHIP 100
R201-214,216-221,226,282-285,300,301,316-323 055 ERJ6ENF1001V RESISTOR CHIP 1K
R340-347,353,354,359,360,373,374,436,437 055 ERJ6ENF1001V RESISTOR CHIP 1K
R447 055 ERJ6ENF1001V RESISTOR CHIP 1K
R352,369,370,375,400 055 ERJ6ENF1002V RESISTOR CHIP 10K
R230-243,332-339,357,358,365,366 055 ERJ6ENF1003V RESISTOR CHIP 100K
R371,372,392-394,439 055 ERJ6ENF1003V RESISTOR CHIP 100K
016 E-1397D00 PCB ASSY
4

Parts List 3/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
R294,295,348-351,376,411-414 055 ERJ6ENF1003V RESISTOR CHIP 100K
R446 055 ERJ6ENF1004V RESISTOR CHIP 1M
R443 055 ERJ6ENF1201V RESISTOR CHIP 1.2K
R450 055 ERJ6ENF1800V RESISTOR CHIP 180
R367,368 055 ERJ6ENF1801V RESISTOR CHIP 1.8K
R296,297 055 ERJ6ENF1801V RESISTOR CHIP 1.8K
R438 055 ERJ6ENF2003V RESISTOR CHIP 200K
R258-281,302-315,361,362,457,458 055 ERJ6ENF2200V RESISTOR CHIP 220
R441 055 ERJ6ENF2201V RESISTOR CHIP 2.2K
R442 055 ERJ6ENF2202V RESISTOR CHIP 22K
R405-410,415,416 055 ERJ6ENF2700V RESISTOR CHIP 270
R435 055 ERJ6ENF2R2V RESISTOR CHIP 2.2
R286-289,324-331 055 ERJ6ENF3303V RESISTOR CHIP 330K
R355,356,451,452 055 ERJ6ENF3303V RESISTOR CHIP 330K
R445 055 ERJ6ENF3901V RESISTOR CHIP 3.9K
R222-225 055 ERJ6ENF3902V RESISTOR CHIP 39K
R455,456 055 ERJ6ENF3902V RESISTOR CHIP 39K
R401-404 055 ERJ6ENF47R0V RESISTOR CHIP 47
R448,449 055 ERJ6ENF47R0V RESISTOR CHIP 47
R244-257,290-293,453-456 055 ERJ6ENF4701V RESISTOR CHIP 4.7K
R440 055 ERJ6ENF5101V RESISTOR CHIP 5.1K
R380-391 055 ERJ6ENF75R0V RESISTOR CHIP 75
R298,299 055 ERJ6ENF8200V RESISTOR CHIP 820
RLY201 063 EA2-12NU RELAY
JAK201-204 066 C-4792A01 6P PIN JACK (WHT,RED)
JK206,207 066 C-4833A01 6P PIN JACK (G,BLG,R)
CP201 068 B13B-PH-KS CONNECTOR POST
501 E-1398 PCB ASSY (VIDEO)
L301,303 021 TAL02TB100K MICRO INDUCTOR 10uH
L302,304 021 TAL02TB101K MICRO INDUCTOR 100uH
XT303 023 CSBLA500KECZF23BO RESONATOR CSB500F23
XT301,302 023 HC49U-001WR CRYSTAL 14.31818MHz
XT304 023 HC49US-010 CRYSTAL 3.579545MHz
XT305 023 HC49US-011 CRYSTAL 4.433619MHz
IC303,309 031 KS5520-1 IC SMD (SCREEN DISPLAY) KS5520
IC312 031 µPC1830GT IC SMD (VIDEO CONVERTER)
IC301,302,307,308 031 TC9163CFG IC SMD (SWITCH ALLEY)
IC304-306,310,311,313 031 TSH94ID IC SMD (VIDEO AMP) TSH94ID
Q305 032 KRA107S TRANSISTOR CHIP
Q301,302,304 032 KRC107S TRANSISTOR CHIP
Q303 032 KRC231S TRANSISTOR CHIP
Q306 032 KTA1271 TRANSISTOR
D302,303 037 KDS184RTK DIODE CHIP
D301 037 KDS226RTK DIODE CHIP
C326-331,341-344,371,374,375,390-393 041 TUTES1A101-7TF ELECTROLYTIC CAPACITOR 10V100uF
C311,320,325,346,355,360 041 TUTES1A471-7TF ELECTROLYTIC CAPACITOR 10V470uF
C314,316,349,351,387 041 TUTES1H010-7TF ELECTROLYTIC CAPACITOR 50V1uF
C380 041 TUTES1H0R1-7TF ELECTROLYTIC CAPACITOR 50V0.1uF
C305-309,337-340,389 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C388 041 TUTES1H2R2-7TF ELECTROLYTIC CAPACITOR 50V2.2uF
C382 041 TUTES1H4R7-7TF ELECTROLYTIC CAPACITOR 50V4.7uF
C315,318,350,353,370 041 TUTES1HR47-7TF ELECTROLYTIC CAPACITOR 50V0.47uF
C323,324,358,359 043 TC50VCH220 CERAMIC CAPACITOR 22pF
C312,313,347,348 043 TC50VCH560 CERAMIC CAPACITOR 56pF
C383 044 BQ074D0105J MP CAPACITOR 63V1uF
C377,384 044 BQ014D0224J MP CAPACITOR 63V0.22uF
C378,379 047 3536150122 CERAMIC CAPACITOR CHIP 15pF
C319,354,381 047 ECJ2VB1H103K CERAMIC CAPACITOR CHIP 0.01uF
016 E-1398F00 PCB ASSY
5

Parts List 4/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
C369 047 ECJ2VB1H472K CERAMIC CAPACITOR CHIP 4700pF
C301-304,334-336,372,373,376,385,386 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C310,321,332,345,356,361 047 ECJ2VF1H224Z CERAMIC CAPACITOR CHIP 0.22uF
C317,322,352,357 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
C365 047 ECJ2VG1H102J CERAMIC CAPACITOR CHIP 1000pF
C366 047 ECJ2VG1H221J CERAMIC CAPACITOR CHIP 220pF
C367 047 ECJ2VG1H271J CERAMIC CAPACITOR CHIP 270pF
C368 047 ECJ2VG1H391J CERAMIC CAPACITOR CHIP 390pF
RV401,402 051 EVM3Y-B24 SEMI-FIXED RESISTOR 20KB
R334,368-373,411-414,421,427,459,466,467 055 ERJ6ENF100V RESISTOR CHIP 10
R340-348,393-398,430-432 055 ERJ6ENF101V RESISTOR CHIP 100
R322,323,326-329,338,349-364,367,389-392, 055 ERJ6ENF102V RESISTOR CHIP 1K
R399-408,415,416,428,434,439,440,458,425,463 055 ERJ6ENF102V RESISTOR CHIP 1K
R441,442,460,461 055 ERJ6ENF103V RESISTOR CHIP 10K
R330,417,438 055 ERJ6ENF104V RESISTOR CHIP 100K
R339,426 055 ERJ6ENF105V RESISTOR CHIP 1M
R337,424 055 ERJ6ENF122V RESISTOR CHIP 1.2K
RA471,472 055 ERJ6ENF151V RESISTOR CHIP 150
R462 055 ERJ6ENF152V RESISTOR CHIP 1.5K
R451 055 ERJ6ENF153V RESISTOR CHIP 15K
R453 055 ERJ6ENF184V RESISTOR CHIP 180K
R331,418 055 ERJ6ENF204V RESISTOR CHIP 200K
R456,457 055 ERJ6ENF220V RESISTOR CHIP 22
R320,321,324,325,385-388,455 055 ERJ6ENF221V RESISTOR CHIP 220
R333,420,443 055 ERJ6ENF222V RESISTOR CHIP 2.2K
R335,422 055 ERJ6ENF223V RESISTOR CHIP 22K
R448 055 ERJ6ENF242V RESISTOR CHIP 2.4K
R445 055 ERJ6ENF272V RESISTOR CHIP 2.7K
R429,437 055 ERJ6ENF2R2V RESISTOR CHIP 2.2
R444 055 ERJ6ENF331V RESISTOR CHIP 330
R336,365,366,409,410,423 055 ERJ6ENF392V RESISTOR CHIP 3.9K
R446 055 ERJ6ENF432V RESISTOR CHIP 4.3K
R454 055 ERJ6ENF433V RESISTOR CHIP 43K
R449 055 ERJ6ENF471V RESISTOR CHIP 470
R332,419 055 ERJ6ENF512V RESISTOR CHIP 5.1K
R452 055 ERJ6ENF684V RESISTOR CHIP 680K
R301-319,375-384,433,435,436,464,465 055 ERJ6ENF750V RESISTOR CHIP 75
R450 055 ERJ6ENF821V RESISTOR CHIP 820
R447 055 ERJ6ENF914V RESISTOR CHIP 910K
SW305,306 066 4TR-2964#10 3P PIN JACK (YEL)
SW301-303 066 C-4604B02 3-4P MINI DIN JACK YKP51-5520
SW304 066 C-4860A01 4P PIN JACK (YEL)
CN302,303 072 C-4772A02WR 1PIN WIRE 1P-250mm
501 E-1399-A PCB ASSY (DIGITAL)
(IC443) 019 0009-P POWER TRANSISTOR BUSH
T431-434 021 2888000010 DIGITAL COIL
XT402 023 CXO-002 CRYSTAL 12.288MHz
XT401 023 HC49U-009 CRYSTAL HC49U24.576MHz
L433,434 025 BK2125HS102 CHIP
L431,432,LCB451,LCW451,LF451,LS451 025 BK2125HS102 CHIP
L401 025 BK2125HS601 CHIP
L435,436 025 BK2125HS601 CHIP
IC438 031 39VF040-V34 IC (DSPROM) SST39VF040-70-4C-NH
IC440 031 74HC00 IC SMD (QUAD NANDGATE) 74HC00
IC436,446 031 74HCT125 IC SMD (QUAD BUFFER) 74HCT125D
IC441,442 031 74HC157 IC SMD (QUAD MPX) 74VHC157
IC445 031 74HC244 IC SMD (OCTAL BUFFER) 74VHC244
IC431 031 AK4114VQ IC SMD (D/A TRANCEIVER) AK4114VQ
016 E-1399F00 PCB ASSY
6

Parts List 5/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
IC447-450 031 AK4395VF IC SMD (D/A CONVERTER) AK4395VF
IC432 031 AK5383VS IC SMD (A/D CONVERTER) AK5383VS
IC403 031 IM29F004T-X67 IC (FLACH MEMORY)
IC443 031 AME1117BCBT IC CHIP (REGULATER)
IC444 031 AME1117CCGT IC CHIP (REGULATER)
IC404 031 AT24C16A10PU-2.7 IC (EEPROM) AT24C16PL
IC437 031 CS49400 IC SMD (DSP) CS49400-3
IC405 031 HIN232CB IC SMD (RS232) HIN232CB
IC402 031 IS62C256 IC SMD (SRAM) IS62C256
IC439 031 K4S161622H-UC IC SMD (MEMORY) K4S161622D
IC406,407 031 LTV817 IC (PHOTO COUPLER)
IC433-435,451-454 031 TL072CD IC SMD (OPE DUAL) TL072CD
IC401 031 TMP95C063F IC SMD (CPU) TMP95C063F
Q401,QCW451,QFL/R451 032 KRC107S TRANSISTOR CHIP
Q402-404 032 KRC231S TRANSISTOR CHIP
D401-406 037 KDS184RTK DIODE CHIP
C430 041 SCDA5R5104V BACKUP CAPACITOR 5.5V 0.1F
C418-421 041 TUTES1H010-7TF ELECTROLYTIC CAPACITOR 50V1uF
C414,417,438,439,441-443,453,482,483 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C485,486,CBL/R454,CCB454,456,CCT454 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
CCW454,456,CF454,456,CFL/R454 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
CS454,456,CSL/R454,CSW454 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C480,481,484,487,C406 041 TUTES1A101-7TF ELECTROLYTIC CAPACITOR 10V100uF
C503 041 TUTES1H2R2-7TF ELECTROLYTIC CAPACITOR 50V2.2uF
C416 041 TUTES1H3R3-7TF ELECTROLYTIC CAPACITOR 50V3.3uF
C454-462,512-519,CAL/R401-404 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
CCB455,CCW455,CF455,CS455 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
C415 041 TUTES1HR22-7TF ELECTROLYTIC CAPACITOR 50V0.22uF
C440 041 TUTES1HR47-7TF ELECTROLYTIC CAPACITOR 50V0.47uF
CCT455,CFL/R455 047 ECJ2VB1H223K CERAMIC CAPACITOR CHIP 0.022uF
C501 047 ECJ2VC1H122J CERAMIC CAPACITOR CHIP 1200pF
C449,C5383 047 ECJ2VF1H224Z CERAMIC CAPACITOR CHIP 0.22uF
CAL/R408,CSW452,453 047 ECJ2VB1H103K CERAMIC CAPACITOR CHIP 0.01uF
C409-411,422-428,436,437,447,450,451 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C467-479,488-490,492,496,498,500 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C504-509,520-523,CCB451-453 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
CCW451-453,CF451-453,CS451-453,OPT1 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C401-405,407,408,429,431-435,444-446,448 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
C452,463-465,491,493-495,499,510,511 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
CAL/R405 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
CBL/R452,453,CCT452,453,CFL/R452,453 047 ECJ2VG1H121J CERAMIC CAPACITOR CHIP 120pF
CSL/R452,453 047 ECJ2VG1H121J CERAMIC CAPACITOR CHIP 120pF
C412,413 047 ECJ2VG1H270J CERAMIC CAPACITOR CHIP 27pF
CBL/R451,CCT451,CFL/R451,CSL/R451,CSW451 047 ECJ2VG1H331J CERAMIC CAPACITOR CHIP 330pF
CAL/R406,407 047 ECJ2VG1H471J CERAMIC CAPACITOR CHIP 470pF
C502 047 ECJ2VG1H680J CERAMIC CAPACITOR CHIP 68pF
RM410-420 055 CN43-101 RESISTOR NETWORK CHIP 100
RM403-409 055 CN43-103 RESISTOR NETWORK CHIP 10K
RM410-418 055 CN43-331 RESISTOR NETWORK CHIP 330
RM401,402 055 CN43-332 RESISTOR NETWORK CHIP 3.3K
R407,408 055 ERJ6ENF100V RESISTOR CHIP 10
R426,444,445 055 ERJ6ENF100V RESISTOR CHIP 10
R405,406,409-411,458,4395 055 ERJ6ENF101V RESISTOR CHIP 100
R427,428,448,451,459-462,476-479,418 055 ERJ6ENF101V RESISTOR CHIP 100
RBL/R458,RCT458,RFL/R458,RSL/R458 055 ERJ6ENF102V RESISTOR CHIP 1K
RSW458 055 ERJ6ENF102V RESISTOR CHIP 1K
R415,416,430,R67V2,R1056 055 ERJ6ENF103V RESISTOR CHIP 10K
R401,402,412-414,447 055 ERJ6ENF103V RESISTOR CHIP 10K
RAL/R401,402,404,405 055 ERJ6ENF103V RESISTOR CHIP 10K
RBL/R457,RCT457,RFL/R457,RSL/R457 055 ERJ6ENF104V RESISTOR CHIP 100K
7

Parts List 6/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
RSW457 055 ERJ6ENF104V RESISTOR CHIP 100K
R403 055 ERJ6ENF105V RESISTOR CHIP 1M
R446 055 ERJ6ENF183V RESISTOR CHIP 18K
R480 055 ERJ6ENF220V RESISTOR CHIP 22
R452-457,466-473 055 ERJ6ENF221V RESISTOR CHIP 220
R435-438 055 ERJ6ENF221V RESISTOR CHIP 220
R463 055 ERJ6ENF302V RESISTOR CHIP 3K
RAL/R406,409 055 ERJ6ENF302V RESISTOR CHIP 3K
R464,465 055 ERJ6ENF332V RESISTOR CHIP 3.3K
R439-443 055 ERJ6ENF471V RESISTOR CHIP 470
R404,420-425 055 ERJ6ENF472V RESISTOR CHIP 4.7K
R419 055 ERJ6ENF472V RESISTOR CHIP 4.7K
R429,449,450,474,475,4394,5383 055 ERJ6ENF473V RESISTOR CHIP 47K
RAL/R403 055 ERJ6ENF473V RESISTOR CHIP 47K
RBL/R451-453,455,456,RCT451-453,455,456 055 ERJ6ENF562V RESISTOR CHIP 5.6K
RFL/R451-453,455,456,RSW451-453,455,456 055 ERJ6ENF562V RESISTOR CHIP 5.6K
RSL/R451-453,455,456 055 ERJ6ENF562V RESISTOR CHIP 5.6K
R431-434 055 ERJ6ENF750V RESISTOR CHIP 75
RAL/R407,410 055 ERJ6ENF911V RESISTOR CHIP 910
RBL/R454,RCT454,RFL/R454,RSL/R454 055 ERJ6ENF912V RESISTOR CHIP 9.1K
RSW454 055 ERJ6ENF912V RESISTOR CHIP 9.1K
RLY401-403 063 EA2-12NU RELAY EA2-12NU
SW401 064 KSP02H DIP SWITCH 2P
JAK407-413 065 YKB21-5103A 3.5ΦMANI JACK (ST)
JAK401,402 066 C-4859A01 2P PIN JACK (BLK)
JAK406 066 SY010-8P/K JACK RJ45 SY010-8P/K
JAK404,405 066 TORX179L JACK OPTICAL MODULE
JAK403 066 TOTX179L JACK OPTICAL TERMINAL
IC403,438 068 PLCC32GS IC SOCKET 32P
CP407 068 B5B-PH-KS CONNECTOR WAFER 5P
CP406 068 B7B-PH-KS CONNECTOR WAFER 7P
CP410 068 B8B-PH-KS CONNECTOR WAFER 8P
CP405,408 068 B10B-PH-KS CONNECTOR WAFER 10P
CP409 068 B12B-PH-KS CONNECTOR WAFER 12P
501 E-1400-A PCB ASSY (OUTPUT)
IC703-706,711-714 031 NJM5532M IC SMD (OPE AMP) NJM5532M
IC702 031 TC9162CFG IC SMD (SWITCH ALLEY) KIC9162CFG
IC701 031 TC9163CFG IC SMD (SWITCH ALLEY) KIC9163CFG
IC709,710 031 TC9482BFG IC SMD (VOLUME) KIC9482BFG
IC707,708 031 TL072CD IC SMD (OPE DUAL) TL072CD
QC702,QCB701,QF701,QS701,QSW702 032 KRA107S TRANSISTOR CHIP
Q701-703,QBL/R701,QC701,QFL/R701 032 KRC231S TRANSISTOR CHIP
QSL/R701,QSW701,Q704 032 KRC231S TRANSISTOR CHIP
D701,702,DC701,DCB701,DF701,DS701 037 KDS184RTK DIODE CHIP
DSW701,703 037 KDS184RTK DIODE CHIP
C701-705,707,709,711,CB701,702 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
CCB703,704,CCW701-704,CF701-704 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
CMW710,711,CS701-704 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
CBL/R702,704,705,708,CCT702,704,705,708 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
CFL/R702,704,705,708,CMW705 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
CSL/R702,704,705,708,CSW702,704,705,708 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
CMW707 047 ECJ2VB1H333K CERAMIC CAPACITOR CHIP 0.033uF
C706,708,710,712,713,714 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
CCB705,CCT709,CF705,CS705,CSW709 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
CMW706 047 ECJ2VF1H224Z CERAMIC CAPACITOR CHIP 0.22uF
CBL/R707,CCT707,CFL/R707,CSL/R707 047 ECJ2VG1H100D CERAMIC CAPACITOR CHIP 10pF
CBL/R701,703,706,CCT701,703,706 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
CFL/R701,703,706,CSW701,703,706,707 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
016 E-1400E00 PCB ASSY
8

Parts List 7/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
CSL/R701,703,706,CMW704 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
CMW708,709 047 ECJ2VG1H222J CERAMIC CAPACITOR CHIP 22pF
J701 055 ERJ6GEY0R00V RESISTOR CHIP 0
RBL/R701,707,RCT701,707,RFL/R701,707 055 ERJ6ENF1000V RESISTOR CHIP 100
RMW709,RSL/R701,707,RSW701,707 055 ERJ6ENF1000V RESISTOR CHIP 100
RBL/R705,RCT705,RFL/R705,RSL/R705,RSW705 055 ERJ6ENF1000V RESISTOR CHIP 100
R703-705,708-710,713-715,718-720 055 ERJ6ENF1001V RESISTOR CHIP 1K
RBL/R712,RCT712,RFL/R712,RMW712,713 055 ERJ6ENF1001V RESISTOR CHIP 1K
RSL/R712,RSW710,712 055 ERJ6ENF1001V RESISTOR CHIP 1K
RBL/R709,RCT709,RFL/R703,709 055 ERJ6ENF1002V RESISTOR CHIP 10K
RMW711,715,716,RSL/R709 055 ERJ6ENF1002V RESISTOR CHIP 10K
RBL/R702,708,711,RCB706,RCT702,708,711,714 055 ERJ6ENF1003V RESISTOR CHIP 100K
RF705,706,RFL/R702,708,711,RMW710,714 055 ERJ6ENF1003V RESISTOR CHIP 100K
RS706,RSL/R702,708,711,RSW702,708,711,714 055 ERJ6ENF1003V RESISTOR CHIP 100K
RBL/R706,RCB705,RCT706,713,RFL/R706 055 ERJ6ENF1003V RESISTOR CHIP 100K
RS705,RSL/R706,RSW706,713 055 ERJ6ENF1003V RESISTOR CHIP 100K
RBL/R704,RCT704,RSL/R704 055 ERJ6ENF1201V RESISTOR CHIP 1.2K
RBL/R703,RCT703,RMW706,707,RSL/R703 055 ERJ6ENF1202V RESISTOR CHIP 12K
RSW709 055 ERJ6ENF1502V RESISTOR CHIP 15K
R721-730,RMW705,R731-734 055 ERJ6ENF1801V RESISTOR CHIP 1.8K
RSW703 055 ERJ6ENF2002V RESISTOR CHIP 20K
R701,702,706,707,711,712,716,717 055 ERJ6ENF2200V RESISTOR CHIP 220
RB701,702,RCB703,704,RCW701-704 055 ERJ6ENF2200V RESISTOR CHIP 220
RF701-704,RMW717,718,RS701-704 055 ERJ6ENF2200V RESISTOR CHIP 220
RBL/R710,RCT710,RFL/R710,RSL/R710 055 ERJ6ENF2201V RESISTOR CHIP 2.2K
RMW708 055 ERJ6ENF2702V RESISTOR CHIP 27K
RSW704 055 ERJ6ENF3301V RESISTOR CHIP 3.3K
RFL/R704 055 ERJ6ENF3901V RESISTOR CHIP 3.9K
RY701-703 063 EA2-12NU RELAY EA2-12NU
TER702 066 C-4784A02 4P PIN JACK (BLK)
TER701 066 C-4792A01 6P PIN JACK (WHT,RED)
CP204,701 068 B3B-PH-KS CONNECTOR WAFER 3P
CP203 068 B6B-PH-KS CONNECTOR WAFER 6P
CP706 068 B7B-PH-KS CONNECTOR WAFER 7P
CP705 068 B8B-PH-KS CONNECTOR WAFER 8P
CP401,402,702 068 B15B-PH-KS CONNECTOR WAFER 15P
CP302 069 B1P-LV-TA 1P LA PIN
501 E-1401 PCB ASSY (MULTI INPUT)
IC715-718 031 TL072CD IC SMD (OPE DUAL) TL072CD
CMB707,708,CMC707,708,CMF707,708 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
CMS707,708 041 TUTES1E470-7TF ELECTROLYTIC CAPACITOR 25V47uF
CMB703,704,CMC702,CMF703,704 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
CMS703,704,CMW702 041 TUTES1H100-7TF ELECTROLYTIC CAPACITOR 50V10uF
C713,714 047 ECJ2VF1H104Z CERAMIC CAPACITOR CHIP 0.1uF
CMB705,706,CMC703,CMF705,706 047 ECJ2VG1H100D CERAMIC CAPACITOR CHIP 10pF
CMS705,706 047 ECJ2VG1H100D CERAMIC CAPACITOR CHIP 10pF
CMB701,702,710,711,CMC701,710 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
CMF701,702,710,711,CMS701,702,710,711 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
CMW701,703,710 047 ECJ2VG1H101J CERAMIC CAPACITOR CHIP 100pF
RMB701,702,RMC701,RMF701,702 055 ERJ6ENF1000V RESISTOR CHIP 100
RMS701,702,RMW701 055 ERJ6ENF1000V RESISTOR CHIP 100
RMB705,706,RMB711,712,RMC703,705 055 ERJ6ENF1002V RESISTOR CHIP 10K
RMF705,706,RMS705,706,711,712 055 ERJ6ENF1002V RESISTOR CHIP 10K
RMB703,704,RMC702,RMF703,704 055 ERJ6ENF1003V RESISTOR CHIP 100K
RMS703,704,RMW702 055 ERJ6ENF1003V RESISTOR CHIP 100K
RMW703,704 055 ERJ6ENF1202V RESISTOR CHIP 12K
RMB707,708,RMC707,708,RMF707,708 055 ERJ6ENF2200V RESISTOR CHIP 220
RMS707,708 055 ERJ6ENF2200V RESISTOR CHIP 220
016 E-1401B00 PCB ASSY
9

Parts List 8/10 RSX-1067v02
SYMBOL.NO PARTS NO. DESCRIPTION
RMF711,712 055 ERJ6ENF3301V RESISTOR CHIP 3K
RMF709,710 055 ERJ6ENF3303V RESISTOR CHIP 330K
RMB709,710,RMC704,RMS709,710 055 ERJ6ENF4301V RESISTOR CHIP 4.3K
JAK702 066 C-4764A02 2P PIN JACK (B,B)
JAK701 066 C-4861A01 6P PIN JACK (WHT,RED)
501 E-1402 PCB ASSY (SPEAKER)
L501-507 021 TRL-332 SPEAKER COIL 1F 23T
Q501-504 032 TC3708-ST TRANSISTOR 2SC3708AA-ST
D501-504 034 T1N4004-TB DIODE 1N4004-F
C508-521 044 BQ014E0472J MP CAPACITOR 63V4700pF
C501-507 044 BQ014E0473J MP CAPACITOR 63V0.047uF
R512-519 053 CR14-390J-A CARBON RESISTOR 1/4W 39
R508-511 053 CR14-472J-A CARBON RESISTOR 1/4W 4.7K
R501-507 054 1WS10J MOF RESISTOR 1WS 10
RL501-504 063 DH2TU-24 RELAY DH24D2-OT(M)
JAK501,503,504 067 C-4761A01 4P SPEAKER TERMINAL
JAK502 067 C-4762A01 2P SPEAKER TERMINAL
CP501-504 068 B2P-VH 2P CONNECTOR POST
WN501 072 C-4750A03 WIRE ASSY 150mm
501 X-1403 PCB ASSY (POWER)
HS1-HS5 017 C-4682A11 SUB HEAT SINKER H=60 (BLK)
LF1050 021 2648701170 LINE FILTER COIL
IC1052,1053,1056 031 NJM7805FA IC (REGULATOR +5VDC)
IC1050 031 NJM7806FA IC (REGULATOR +6VDC)
IC1058 031 NJM7812FA IC (REGULATOR +12VDC)
IC1054,1059 031 NJM7818FA IC (REGULATOR +18VDC)
IC1051 031 NJM7906FA IC (REGULATOR -6VDC)
IC1055 031 NJM7918FA IC (REGULATOR -18VDC)
Q1051-1055 032 TC3708-ST TRANSISTOR 2SC3708AA-ST
DB1050,1051 034 MP254W POWER DIODE 400V25A
D1050-1077 034 T1N4004-TB DIODE 1N4004-F
DZ1052 034 TRD18JST1 ZENER DIODE 18V
DZ1053 034 TRD24JST1 ZENER DIODE 24V
DZ1057 034 TRD4.3EST1 ZENER DIODE 4.3V
DZ1051 034 TRD7.5JST1 ZENER DIODE 7.5V
T101,102 034 SCK0512 POWER THERMISTOR
F1051* (for 120V) 036 5ST1-R FUSE 250VT1A
F1051* (for 230V) 036 5ST2-R FUSE 250VT2A
F1090,1091 036 GSA15A LONG FUSE 250V15A
C1090-1093 041 AM1K153 ELECTROLYTIC CAPACITOR 80V15000uF
C1080,1083-1085 041 TUTES1C472-7TS ELECTROLYTIC CAPACITOR 16C4700uF
C1066-1073,1079,1096 041 TUTES1H010-7TF ELECTROLYTIC CAPACITOR 50V1uF
C1074,1075 041 TUTES1H220-7TF ELECTROLYTIC CAPACITOR 50V22uF
C1087 041 TUTES1J471-7TS ELECTROLYTIC CAPACITOR 63V470uF
C1065,1078,1086 041 TUTES1V471-7TS ELECTROLYTIC CAPACITOR 35V470uF
C1088 041 UTES1C103-7 ELECTROLYTIC CAPACITOR 16C10000uF
C1081,1082 041 UTES1V472-7 ELECTROLYTIC CAPACITOR 35V4700uF
C1052-1056 043 TC500V103 CERAMIC CAPACITOR 500V0.01uF
C1049-1051 044 DE2E3KH472MA3B SPARK KILLER 4700pF
C1043-1048,1060-1064,1094,1095 044 BQO14E0103J MP CAPACITOR 100V0.01uF
R1065,1072 053 CR14-102J-A CARBON RESISTOR 1/4W 1K
R1068-1070 053 CR14-220J-A CARBON RESISTOR 1/4W 22
R1056,1066,1067,1074 053 CR14-222J-A CARBON RESISTOR 1/4W 2.2K
R1073 053 CR14-3R3J-A CARBON RESISTOR 1/4W 3.3
R1063,1064,1075 053 CR14-471J-A CARBON RESISTOR 1/4W 470
R1071 053 CR14-473J-A CARBON RESISTOR 1/4W 47K
R1059,1060,1077 054 1WS1JF MOF RESISTOR 1W 1
016 X-1403E01-04 PCB ASSY
016 E-1402A00 PCB ASSY
10