Seers Medical SM3590 User manual

03-011-UM ISSUE 1
OPERATING INSTRUCTIONS
SEERS Medicare
Echocardiography Couch
Model No.’s: SM3590

03-011-UM ISSUE 1
INDEX
1. GENERAL INFORMATION –WARNINGS & CAUTIONS
2. HOW TO USE –
a. WHEEL SYSTEM
b. ADJUSTABLE FOOT
c. ADJUSTING THE HEIGHT OF THE COUCH
d. ALTERING THE BACKREST ANGLE
e. APPLYING TILT TO THE COUCH
f. OPTIONAL ACCESSORY –TRIPLE FOOTSWITCH
g. ALTERING THE FOOT SECTION ANGLE
h. ARM SUPPORT
i. SEAT SIDE EXTENSION LEAF
j. FOLD DOWN SIDE SUPPORT
k. PATIENT SUPPORT HANDLE
3. CLEANING INSTRUCTIONS
4. MAINTENANCE
5. WARRANTY
6. TECHNICAL DATA
7.
SEERS ECHOCARDIOGRAPHY COUCH –OPERATING INSTRUCTIONS
PAGES
ISSUE
DATE
ALL
1.0
01/06/2009
1. GENERAL INFORMATION.

03-011-UM ISSUE 1
CONGRATULATIONS on the purchase of your SEERS MEDICAL Product. If these operating instructions
are adhered too, this product will provide many years of safe use.
IF THESE OPERATING INSTRUCTIONS ARE NOT FOLLOWED - YOUR WARRANTY COULD BE INVALID!
Always keep these Operating Instructions available for reference.
ALL User Interfaces are identified by the DARK GREY COLOUR.
WARNINGS!
Warnings identify potential hazards which if not followed correctly, could result in serious injury, or
possibly even death!
Ensure electric couches are not used in the presence of flammable gasses such as
an anaesthetic agent.
DO NOT EXCEED the Maximum Safe Working Load of 240 Kg (528 lbs) –which
must be distributed evenly across the working surface
Do not concentrate uneven weight on either side of the couch.
When the plug is disconnected, this acts as a disconnect device.
Use only accessories that have been designed or approved for use with this
couch.
Children must not play with the couch at any time.
Adequately supervise children in the proximity of the couch.
CAUTIONS!
Cautions identify circumstances which if not followed correctly, could result in failure or damage of
the equipment!
Attention refer to these Operating Instructions for further information

03-011-UM ISSUE 1
2. HOW TO USE.
a. WHEEL SYSTEM
b. ADJUSTABLE FOOT
CAUTION!
Ensure Wheels are retracted before
adjusting the adjustable foot.
1. Ensure the couch is off of the wheels
2. Adjust the foot by turning clockwise or
anticlockwise until the couch is stable.
3. Secure the foot by tightening the nut until it
locks against the threaded cap.
WARNING!
This Couch is not designed for patient transportation
Ensure Wheels are retracted prior to patient transfer or treatment.
Disconnect the electric lead prior to re-locating the couch, ensuring the lead is not
trapped in the mechanism.
Lever Down = Wheels retracted and OFF
Lever Down = Wheels activated and ON

03-011-UM ISSUE 1
c. ADJUSTING THE HEIGHT OF THE COUCH
d. ALTERING THE BACKREST OF THE COUCH
e. APPLYING TILT TO THE COUCH
f. OPTIONAL ACCESSORY –TRIPLE FOOTSWITCH CONTROL.
To adjust the height of the couch, simply
press the raise or lower button of the top
button indicated by the symbol, until desired
height is achieved. Once the button is
released the couch height is locked in that
position ready for use.
To apply tilt to the couch, simply press the
raise or lower button of the bottom button
indicated by the tilt symbol, until desired
angle is achieved. Once the button is
released the tilt angle is locked in that
position ready for use.
To adjust the backrest, simply press the raise
or lower button of the middle button
indicated by the symbol, until desired angle is
achieved. Once the button is released the
backrest is locked in that position ready for
use.
To adjust couch, press the relevant button to
adjust height, tilt or backrest angle up or
down.

03-011-UM ISSUE 1
g. ALTERING THE FOOT SECTION ANGLE
h. ARM SUPPORT (optional)
1. To raise the backrest or foot section,
simply grasp the release lever towards
the upholstery and adjust the backrest
to the angle desired.
2. Releasing the lever automatically locks
the section at that angle.
3. To lower, grasp the lever again, and
lower the backrest or foot section to
the required angle.
4. Releasing the lever automatically locks
the section.
WARNING!
ENSURE the switch operating cable does not become entangled in the couch frame
mechanism.
When the foot switch is used, ensure it is located where the patient cannot stand on
the switch when mounting or dismounting the couch.
1. To adjust position of Arm Support
Pad, undo the locking clamp on
underside of pad anticlockwise.
2. Once loosened, move pad to
desired position and re-tighten
locking clamp to secure.
3. If height adjustment is required,
undo the locking clamp on the
vertical stem.
4. Once loose, adjust height of stem
to raise or lower pad accordingly.
5. Once at right height, re-tighten
locking clamp to secure.

03-011-UM ISSUE 1
i. SEAT STOOL
WARNING!
THE STOOL MUST NOT BE UNDERNEATH THE UPHOLSTERY WHEN RAISING OR
LOWERING THE COUCH
When the clinician is using the seat stool, ensure legs and feet do not enter the
mechanism of the couch as entrapment could occur.
Ensure the stool is adjusted to the same height as the couch

03-011-UM ISSUE 1
j. FOLD DOWN SIDE SUPPORT
k.
l.
k. PATIENT SUPPORT HANDLE
To Raise the side support rail, simply lift and
rotate 180 degrees, and then engage fully
into socket.
To Lower the side support rail, simply lift out
of socket and rotate down 180 degrees to
disengaged position.
WARNING!
Children must not play with the couch at any time.
Adequately supervise children in the proximity of the couch.
Ensure the Side Support Rails are Fully Engaged into Socket prior to use
To secure the Patient Support Handle in
desired position, simply tighten the locking
clamp on the underside of the upholstery
section.

03-011-UM ISSUE 1
3. CLEANING INSTRUCTIONS
General Cleaning:
To get rid of any dust or marks on the surface the Faux Leather MUST be wiped DAILY
with a moist soft cotton cloth. Visible and loose dirt can be picked up with a vacuum
cleaner (Do not use a brush type vacuum) Use a soapy cotton cloth and gently rub
stains with circular movements.
For more stubborn marks a dilute bleach solution can be used 5% Bleach to 95% Water.
Stain Removal:
Blot excess liquid as quickly as possible with a clean 100% cotton white absorbent cloth
or sponge. If necessary use clean warm water. Clean the entire area where the spot
occurred on the cushion, arm etc. Water may dissolve dirt particles and make cleaning
easier. Spills that are still moist are the easiest to remove. Leave to air dry naturally, do
not use a hair dryer etc to speed up the drying.
Coffee, tea etc spills: Use an absorbent white cloth or piece of paper. DO NOT RUB.
Allow the stain to be absorbed and removed from the material surface. Then rub gently
with white tissue paper in circular movements to remove any remaining dampness and
residue.
Ink, Ball point pen, Denim, hard stains: Rub the stain by means of gentle circular
movements with tissue dampened with 96°alcohol and water (1:1) After this rub the
surface with gentle circular movement with tissue paper to dry it.
Butter, oil, grease stains: Wipe excess butter, oil or grease off the surface with a clean
100% Cotton white dry cloth. Use a soapy cotton cloth and gently rub the stain with
circular movements. Use a clean damp cloth to wipe the area and dry the surface.
Chewing gum: Place ice cubes in a plastic bag and apply on the chewing gum. Wait
several minutes, lift the ice bag and remove the chewing gum.
DO NOT USE CHEMICALS, SADDLE SOAP, CLEANING SOLVENTS, FURNITURE POLISH,
OILS, VARNISH, ABRASIVE CLEANERS OR AMMONIA IN WATER.
WARNING!
Disconnect the couch from the mains power supply prior to carrying out any cleaning
or decontaminating.
DO NOT SATURATE PRODUCT
IF PRODUCT GETS SATURATED DURING CLEANING, THIS COULD ACCELERATE
CORROSION, REDUCING PRODUCTS LENGTH OF SERVICE.

03-011-UM ISSUE 1
Frequency of routine couch cleaning will depend on exact application.
1. Ensure the couch is in a suitable area for cleaning.
2. The couch must be OFF of the wheels.
3. Disconnect from mains power supply if electric model.
4. Control handsets can be wiped over using an alcohol wipe.
5. Prepare a solution from the guidelines detailed above.
6. DO NOT SATURATE PRODUCT –This should be a wipe down –not a soaking!
7. Start by cleaning the top surface of the couch, working down onto the frames below,
ensuring to not accidentally activate any of the release levers, or user interface parts.
8. Ensure the couch is dry before re-use.
9. Safely discard of cleaning materials.
10. Wash hands thoroughly.
If DECONTAMINATING the couch then repeat steps above using a dilute Hypochlorite &
warm water mixture (mixed at 10,000ppm) instead of warm water and soap.
It is crucial that any staining is treated as soon as possible but never later than 24
hours. Delays in cleaning will give stains time to react with the plasticiser in the faux
leather making it more and more difficult to remove.
Note: These are recommended or suggested methods of cleaning. The manufacturer is not
responsible for damage incurred while cleaning. Always try the cleaning method in a hidden area first
to see the results.
Remember if you are not sure contact you customer representative before proceeding.

03-011-UM ISSUE 1
4. MAINTENANCE
1. A visual inspection should be carried out daily prior to use.
2. Regular servicing should be carried out a minimum of every six months or more frequently if
the couch is in constant use.
3. Routine servicing or repair must only be performed by suitably qualified people.
4. Look for any visual signs of damage. Ensure all nuts, bolts and other fasteners are present and
fitted where expected. If loose (can be undone by hand), re- tighten using suitable tools –but
taking care to not over tighten as this could cause binding, juddering, identifiable by a likely
noise.
5. Upholstery fixings should be checked regularly and tightened if loose. DO NOT USE PRODUCT
IF ANY UPHOLSTERY FIXING SCREWS ARE MISSING!
6. Check hinge pins are secured correctly by the e clips. IF THESE ARE MISSING DO NOT USE
COUCH!
7. Check gas struts operate smoothly and correctly throughout all ranges of movement. The
upholstered section should lock once the release lever is no longer operated.
8. Check hydraulic pump (hydraulic variant only) for smooth operation and any signs of leakage.
ELECTRIC MODELS ONLY
9. On electric models ,check the power cable and air pipes on hand and foot switch controls,
looking for any cuts, abrasions or any other deterioration that may have occurred and replace
if necessary.
10. Ensure that the mains power supply plug is attached securely to the motor.
11. Check mains plug connections are tight and the correct fuse is fitted.
WARNING!
Disconnect the couch from the mains power supply prior to carrying out any
maintenance.
All electrical maintenance should be performed by a suitably qualified person.
BLUE or BROWN wires must not be connected to any earth terminal.

03-011-UM ISSUE 1
5. WARRANTY
SEERS MEDICAL Limited standard terms and conditions apply to this device.
A copy of this is available upon request. This contains full details of warranty terms and does not
affect your statutory rights.
For any further information on this product, regarding spares, warranty, service or maintenance
information, please contact:
SEERS MEDICAL Limited
Kenton Road
Debenham
Suffolk
IP14 6LA
T: [phone]
F: [phone]
E: [e-mail]
W: www.seersmedical.com
© SEERS MEDICAL Limited
Manufactured in the UK by SEERSMEDICAL Limited.
As part of our ongoing development programme SEERS MEDICAL Limited reserves the right to alter or
modify specifications and materials without prior notice.

03-011-UM ISSUE 1
6. TECHNICAL DATA
Index
SM3590
Elevation Control
ELECTRIC
Overall Length (cm)
210
Mid Section Length (cm)
50
Head Length (cm)
64
Foot Section Length (cm)
94
Width (cm)
65
Minimum Height (cm)
55
Maximum Height (cm)
108
Safe Working Load &
Lifting Capacity
240 Kg (528lbs)
Electrical Data
230v
120v
Actuator
24v 6A
24v 6A
Internal Fuse Rt
-
-
Current
0.8A
1.6A
Power
24v 6A
24v 6A
Mains Plug Fuse Rt (UK)
13A
-
IEC 601-1 Classification
Class
Insulated
Class 1
Type B Equipment

03-011-UM ISSUE 1
SEERS MEDICAL Limited
Kenton Road
Debenham
Suffolk
IP14 6LA
t: [phone]
f: [phone]
e: [e-mail]
w: www.seersmedical.com
© SEERS MEDICAL Limited
The mark on this product demonstrates conformity with the Medical Device Directive 93/42/EEC.