Stryker Medical 720 User manual

720 Transport Stretcher
Operations Manual
For Parts or Technical Assistance
800-327-0770

Table of Contents
Introduction 2, 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Applying the Brake System 4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating Directional Steering Caster/5th Wheel Options 5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting Stretcher Height 5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Using Siderails 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Using the Patient Transfer Board 7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating The Fowler 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Using the Optional 2-Stage I.V. Pole 9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Using the Optional 3-Stage I.V. Pole 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating the Optional Tethered I.V. Pole 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating the Optional Foot Extension/Defibrillator Tray 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Preventative Maintenance Checklist 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limited Warranty
Obtaining Parts And Service 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Supplemental Warranty Coverage 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Return Authorization 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Freight Damage Claims 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Introduction
2
INTRODUCTION
This manual is designed to assist you with the operation of the 720 Transport Stretcher. Read it thoroughly
before using the equipment or beginning any maintenance on it.
SPECIFICATIONS
Maximum Weight Capacity 500 pounds
Overall Bed Length/Width 81”, 30”
Fixed Height Options 28”, 30” ,32”
Fowler Angle 0 to 90_
Stryker reserves the right to change specifications without notice.
WARNING / CAUTION / NOTE DEFINITION
The words WARNING, CAUTION and NOTE carry special meanings and should be carefully reviewed.
WARNING
The personal safety of the patient or user may be involved. Disregarding this information could result in injury
to the patient or user.
CAUTION
These instructions point out special procedures or precautions that must be followed to avoid damaging the
equipment.
NOTE
This provides special information to make maintenance easier or important instructions clearer.

Introduction
3
Before operating this stretcher, it is important to read and understand all information in this manual. Carefully
read and strictly follow the warnings listed on this page.
WARNING
Always apply the caster brakes when a patient is getting on or off the stretcher. Push on the stretcher to en-
sure the brakes are securely locked. Always engage the brakes unless the stretcher is being moved. Injury
could result if the stretcher moves while a patient is getting on or off the stretcher. If brakes do not hold proper-
ly, refer to your stretcher maintenance manual for a brake adjustment procedure.
Do not attempt to adjust the stretcher height with a patient on the stretcher.
When using the SAFRtBoard to transfer a patient, alwayslock the brakes on all stretchers, beds, etc. being
used and always be certain the transfer board is placed securely on the surface of the mating stretcher or
bed.Thepatient stretcher and the mating surface must be at the same height before the patient is transferred.
Be sure the siderail latching mechanism is working properly at all times. If it is not, refer to your stretcher
maintenance manual for ”Siderail Latch Adjustment”.
When lowering the siderail to the collapsed position, keep extremities of patients and staff away from the side-
rail spindles or injury could occur.
To avoid injury or damage to the equipment, do not allow the siderail to lower on its own.
Be sure the brace assembly is securely locked in the Fowler supports before removing hands from handles.
Keep fingers/hands clear of the area around the Fowler release handle and Fowler frame when lowering.
Injury could result if care is not taken when lowering the Fowler.
Keep fingers/hands clear of the area around the Gatch riser and the foot section frame when lowering the
foot section. Injury could result if care is not taken when lowering the foot section.
If pneumatic system appears to be difficult to operate, refer to the stretcher maintenance manual for “Pneu-
matic Fowler Adjustment”
The weight of the I.V. bags should not exceed 40 pounds.

Stretcher Operation
4
APPLYING THE BRAKE SYSTEM
A
(A) Brake and Steer Functions (Head End)
B
(B) Brake and Steer Functions (Foot End)
To engage the brakes from the head (non-control) end of the stretcher, push fully down on the left side of
pedal (A). To engage the brakes from the foot (control) end of the stretcher, push fully down on the right side
of pedal (B).
WARNING
Always apply the caster brakes when a patient is getting on or off the stretcher. Push on the stretcher to en-
sure the brakes are securely locked. Always engage the brakes unless the stretcher is being moved. Injury
could result if the stretcher moves while a patient is getting on or off the stretcher. If brakes do not hold proper-
ly, refer to your stretcher maintenance manual for a brake adjustment procedure.
NOTE
Your stretcher may be equipped with optional side control brake and steer functions in addition to the standard
head and foot end controls. The side control brakes operate the same as the head and foot end versions.
They are indicated by a label on each side of the stretcher base.
RIGHT SIDE
LEFT SIDE
OPTIONAL SIDE CONTROL BRAKE/STEER

Stretcher Operation
5
OPERATING THE DIRECTIONAL STEERING CASTER/5TH WHEEL OPTIONS
The purpose of the steer wheel and 5th wheel options is to help guide the stretcher when transporting a patient
along a straight line and also for pivoting at corners.
To engage the steer from the head (non-control) end of the stretcher, push fully down on the right side of pedal
(A). To engage the steer from the foot (control) end of the stretcher, push fully down on the left side of pedal
(B).
NOTE
Stretchers cannot be equipped with both steering caster and fifth wheel options. The choice was made at
the time the stretcher was purchased.
The steer wheel is located at the foot end of the stretcher on the patient’s left. The 5th wheel is located under-
neath the center of the base assembly.
ADJUSTING STRETCHER HEIGHT
NOTE
The 720 Transport Stretcher is available from the factory in three ”fixed”heights: 28”, 30”, and 32”. The
stretcher height was determined at the time of purchase. Follow the procedure below to change the stretcher
height.
Required Tools:
1/2”Open End Wrench 1/2”Socket with Ratchet
Adjustment Procedure:
WARNING
Do not attempt to adjust the stretcher height with a patient on the stretcher.
1. Using a 1/2”open end wrench and 1/2”socket with ratchet, loosen the 2 bolts and 2 self-locking nuts
located on the head and foot end upper tower assemblies.
2. Remove only the 4 self-locking nuts.
3. Lift the litter top from both ends simultaneously only enough to relieve the pressure on the 4 bolts and
remove the bolts and 8 washers.
4. Adjust to the desired height by aligning the appropriate holes located in both the head and foot end upper
and lower tower assemblies.
5. Reinstall the 4 bolts, 8 washers and 4 self-locking nuts and tighten securely.

Stretcher Operation
6
USING THE SIDERAILS
CAUTION
Be sure the siderail latching mechanism (B) is working properly at all times. If it is not, refer to your stretcher
maintenance manual for ”Siderail Latch Adjustment”.
A
B
To engage siderails: Pull up siderail (A) and raise to full up position so that latch (B) engages.
To disengage siderails: Pull up on latch (B) and guide siderail to the full down position.
WARNING
When lowering the siderail to the collapsed position, keep extremities of patients and staff away from the side-
rail spindles or injury could occur.
To avoid injury or damage to the equipment, do not allow the siderail to lower on its own.

Stretcher Operation
7
USING THE PATIENT TRANSFER BOARD
WARNING
When using the transfer board to transfer a patient, always lock the brakes on all stretchers, beds, etc. being
used and always be certain the transfer board is placed securely on the surface of the mating stretcher or
bed.Thepatient stretcher and the mating surface must be at the same height before the patient is transferred.
Transferring Patients:
Note
The transfer board (C) is located between the siderail (A) and the mattress (B). (See illustration).
1. Lower siderail (A) to full down position.
2. Raise the transfer board (C) from the bottom while lifting
from the top.
3. When the transfer board is fully raised, it can be pivoted
downward onto the surface of the mating bed or stretcher.
Important: Be sure the brakes have been applied on both
the stretcher and the mating bed or stretcher before begin-
ning step 4.
4. Using a sheet, draw the patient onto the mating bed or
stretcher.
BA
C
MATING
BED
MATING
BED
MATING
BED

Stretcher Operation
8
OPERATING THE FOWLER
NOTE
There are two types of fowler options: 1) manually operated, 2) pneumatic operated.
Manual Fowler:
Lift up on the Fowler handles (A). The brace as-
sembly (B) will fall into position as the Fowler is
raised to the desired height.
CAUTION
Be sure the brace assembly (B) is securely locked
in the Fowler supports before removing hands
from handles.
Pneumatic Fowler:
Squeeze handle (A) for pneumatic assist in lifting
the Fowler to the desired height. Remove hand(s)
from handle when desired height is achieved.
To lower, squeeze handle (A) and push down until
Fowler has reached desired height. Remove
hand(s) from handle when desired height is
achieved.
CAUTION
If pneumatic system appears to be difficult to oper-
ate, refer to the Stretcher Maintenance Manual for
“Pneumatic Fowler Adjustment”
WARNING
Keep fingers/hands clear of area around Fowler
release handle and Fowler frame when lowering.
Injury could result if care is not taken when lower-
ing the Fowler.
A
B
A
B

Stretcher Operation
9
OPERATING THE OPTIONAL 2-STAGE PERMANENTLY ATTACHED I.V. POLE
A
C
B
A
C
DETAIL OF I.V. POLE LATCH
NOTE
The 2-stage permanently attached I.V. pole is an option and may have been installed at either the head, foot
or both ends of the stretcher. The choice was made at the time the stretcher was purchased.
To use the 2-stage permanently attached I.V. pole:
1. Lift and pivot the pole from the storage position and push down until it is locked into the receptacle.
2. To raise the height of the pole, pull up on the telescoping portion (A) until it locks into place at its fully raised
position.
3. Rotate the I.V. hangers (B) to desired position and hang the I.V. bags.
4. To lower the I.V. pole, turn the latch (C) clockwise until section (A) lowers.
CAUTION
To avoid damage, the weight of the I.V. bags should not exceed 40 pounds.
To avoid damage while transporting the stretcher, verify the I.V. pole is at a low enough height to allow it to
safely pass through door openings and under light fixtures.

Stretcher Operation
10
OPERATING OPTIONAL 3-STAGE PERMANENTLY ATTACHED I.V. POLE
B
D
A
C
E
A
E
DETAIL OF I.V. POLE LATCH
DETAIL OF I.V. POLE GRIP
B
D
C
NOTE
The 3-stage permanently attached I.V. pole is an option and may have been installed at either the head, foot
or both ends of the stretcher. The choice was made at the time the stretcher was purchased.
To use the 3-stage permanently attached I.V. pole:
1. Lift and pivot the pole from the storage position and push down until it is locked into the receptacle.
2. To raise the height of the pole, pull up on the telescoping portion (A) until it locks into place at its fully raised
position.
3. For a higher I.V. pole, pull up on section (B). Release section (B) at any desired height and it will lock
into place.
4. Rotate the I.V. hangers (C) to the desired position and hang the I.V. bags.
5. To lower the I.V. pole, push up on the red portion of grip (D) while holding onto section (B) until it lowers.
Turn latch (E) clockwise until section (A) lowers.
CAUTION
To avoid damage, the weight of the I.V. bags should not exceed 40 pounds.
To avoid damage while transporting the stretcher, verify the I.V. pole is at a low enough height to allow it to
safely pass through door openings and under light fixtures.

Stretcher Operation
11
OPERATING THE OPTIONAL TETHERED I.V. POLE
1. Remove the I.V. pole from the storage trough under the litter
and insert into the receptacle on the corner of the litter frame.
2. To raise the height of the pole, turn knob (A) counterclockwise
and pull up on the telescoping portion (B) of the pole to raise
it to the desired height.
3. Turn knob (A) clockwise to lock the telescoping portion in place.
OPERATING THE OPTIONAL FOOT EXTENSION/DEFIBRILLATOR TRAY
1. To use as a defibrillator tray, pull out the top knob
(A) and pivot the tray (B) over the foot extension (C)
until the tray extends flat over the foot end of the
stretcher.
2. To use as a foot extension, pull out knob (A) and
pivot the defibrillator tray back until it locks against
the foot extension (C). While holding onto the as-
sembly, pull out the bottom knob (D) and lower the
foot extension down until it is flat.
WARNING
If the stretcher is equipped with the optional foot end I.V.
pole, the I.V. pole must be in the raised position when
the foot extension/defibrillator tray is installed. If the I.V.
pole is not raised, the foot extension will not function
properly and injury could occur.
A
B
A
B
C
D
FOOT END

12
Preventative Maintenance
CHECKLIST
All fasteners secure
Siderails move and latch properly
Engage brake pedal and push on the stretcher to ensure all casters lock securely
Steer function working properly
All casters secure and swivel properly
Body restraints working properly
I.V. pole intact and operating properly
Oxygen bottle holder intact and operating properly
Fowler operates and latches properly
No rips or cracks in mattress cover
Transfer boards intact and operating properly
Ground chain intact
Lubricate where required, including the brake adjuster assembly and brake cam
Accessories and mounting hardware in good condition and working properly
Serial No.______________
______________
______________
______________
______________
Completed By:_________________________________ Date:_____________
NOTE
Preventative maintenance should be performed at a minimum of annually. A preventative maintenance pro-
gram should be established for all Stryker Medical equipment. Preventative maintenance may need to be
performed more frequently based on the usage level of the product.

13
Cleaning
Hand wash all surfaces of the stretcher with warm water and mild detergent. Dry thoroughly. DO NOT
STEAM CLEAN, PRESSURE WASH, HOSE OFF OR ULTRASONICALLY CLEAN. Using these methods
of cleaning is not recommended and may void this product’s warranty.
Clean Velcro AFTER EACH USE. Saturate Velcro with disinfectant and allow disinfectant to evaporate. (Ap-
propriate disinfectant for nylon Velcro should be determined by the hospital.)
In general, when used in those concentrations recommended by the manufacturer, either phenolic type or
quaternary type disinfectants can be used. Iodophor type disinfectants are not recommended for use be-
cause staining may result. The following products have been tested and have been found not to have a harm-
ful effect WHEN USED IN ACCORDANCE WITH MANUFACTURERS RECOMMENDED DILUTION.*
TRADE NAME DISINFECTANT
TYPE
MANUFACTURER *MANUFACTURER’S RECOMMENDED
DILUTION
A33 Quaternary Airwick (Professional Products Division) 2 ounces/gallon
A33 (dry) Quaternary Airwick (Professional Products Division) 1/2 ounce/gallon
Beaucoup Phenolic Huntington Laboratories 1 ounce/gallon
Blue Chip Quaternary S.C. Johnson 2 ounces/gallon
Elimstaph Quaternary Walter G. Legge 1 ounce/gallon
Franklin
Phenomysan
F2500
Phenolic Purex Corporation 1 1/4 ounce/gallon
Franklin Sentinel Quaternary Purex Corporation 2 ounces/gallon
Galahad Phenolic Puritan Churchill Chemical Company 1 ounce/gallon
Hi-Tor Quaternary Huntington Laboratories 1/2 ounce/gallon
LPH Phenolic Vestal Laboratories 1/2 ounce/gallon
Matar Phenolic Huntington Laboratories 1/2 ounce/gallon
Omega Quaternary Airwick (Professional Products Division) 1/2 ounce/gallon
Quanto Quaternary Huntington Laboratories 1 ounce/gallon
Sanikleen Quaternary West Chemical Products 2 ounces/ gallon
Sanimaster II Quaternary Service Master 1 ounce/gallon
Vesphene Phenolic Vestal Laboratories 1 1/4 ounce/ gallon
Quaternary Germicidal Disinfectants, used as directed, and/or Chlorine Bleach products, typically 5.25% So-
dium Hypochlorite in dilutions ranging between 1 part bleach to 100 parts water, and 2 parts bleach
to 100 parts water are not considered mild detergents. These products are corrosive in nature and
may cause damage to your stretcher if used improperly. If these types of products are used to clean
Stryker patient handling equipment, measures must be taken to insure the stretchers are rinsed with clean
water and thoroughly dried following cleaning. Failure to properly rinse and dry the stretchers will leave a cor-
rosive residue on the surface of the stretcher, possibly causing premature corrosion of critical components.
NOTE
Failure to follow the above directions when using these types of cleaners may void this product’s warranty.
REMOVAL OF IODINE COMPOUNDS
This solution may be used to remove iodine stains from mattress cover and foam footrest pad surfaces.
1. Use a solution of 1-2 tablespoons Sodium Thiosulfate in a pint of warm water to clean the stained area.
Clean as soon as possible after staining occurs. If stains are not immediately removed, allow solution to
soak or stand on the surface.
2. Rinse surfaces which have been exposed to the solution in clear water before returning bed to service.

Warranty
14
Limited Warranty:
Stryker Medical Division, a division of Stryker Corporation, warrants to the original purchaser that its products
should be free from defects in material and workmanship for a period of one (1) year after date of delivery.
Stryker’s obligation under this warranty is expressly limited to supplying replacement parts and labor for, or
replacing, at its option, any product which is, in the sole discretion of Stryker, found to be defective. Stryker
warrants to the original purchaser that the frame and welds on its beds will be free from structural defects
for as long as the original purchaser owns the bed. If requested by Stryker, products or parts for which a
warranty claim is made shall be returned prepaid to Stryker’s factory. Any improper use or any alteration or
repair by others in such manner as in Stryker’s judgement affects the product materially and adversely shall
void this warranty. Any repair of Stryker products using parts not provided or authorized by Stryker shall void
this warranty. No employee or representative of Stryker is authorized to change this warranty in any way.
Stryker Medical stretchers are designed for a 10 year expected life under normal use conditions and appropri-
ate periodic maintenance as described in the maintenance manual for each device.
This statement constitutes Stryker’s entire warranty with respect to the aforesaid equipment. STRYKER
MAKES NO OTHER WARRANTY OR REPRESENTATION, EITHER EXPRESSED OR IMPLIED, EXCEPT
AS SET FORTH HEREIN. THERE IS NO WARRANTY OF MERCHANTABILITY AND THERE ARE NO
WARRANTIES OF FITNESS FOR ANY PARTICULAR PURPOSE. IN NO EVENT SHALL STRYKER BE
LIABLE HEREUNDER FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM OR IN ANY
MANNER RELATED TO SALES OR USE OF ANY SUCH EQUIPMENT.
To Obtain Parts and Service:
Stryker products are supported by a nationwide network of dedicated Stryker Field Service Representatives.
These representatives are factory trained, available locally, and carry a substantial spare parts inventory to
minimize repair time. Simply call your local representative, or call Stryker Customer Service at (800)
327-0770.
Service Contract Coverage:
Stryker has developed a comprehensive program of service contract options designed to keep your equip-
ment operating at peak performance at the same time it eliminates unexpected costs. We recommend that
these programs be activated before the expiration of the new product warranty to eliminate the potential of
additional equipment upgrade charges.
A SERVICE CONTRACT HELPS TO:
SEnsure equipment reliability
SStabilize maintenance budgets
SDiminish downtime
SEstablish documentation for JCAHO
SIncrease product life
SEnhance trade-in value
SAddress risk management and safety

Warranty
15
Stryker offers the following service contract programs:
SPECIFICATIONS GOLD SILVER PM* ONLY
Annually scheduled preventative maintenance X X
All parts,** labor, and travel X X
Unlimited emergency service calls X X
Priority one contact; two hour phone response X X X
Most repairs will be completed within 3 business days X X
JCAHO documentation X X X
On-site log book w/ preventative maintenance & emergency service records X
Factory-trained Stryker Service Technicians X X X
Stryker authorized parts X X X
End of year summary X
Stryker will perform all service during regular business hours (9-5) X X X
* Replacement parts and labor for products under PM contract will be discounted.
** Does not include any disposable items, I.V. poles (except for Stryker HD permanent poles), mattresses, or damage re-
sulting from abuse.
Stryker Medical also offers personalized service contracts.
Pricing is determined by age, location, model and condition of product.
For more information on our service contracts,
please call your local representative or call [phone] (option #2).
Return Authorization:
Merchandise cannot be returned without approval from the Stryker Customer Service Department. An autho-
rization number will be provided which must be printed on the returned merchandise. Stryker reserves the
right to charge shipping and restocking fees on returned items.
SPECIAL, MODIFIED, OR DISCONTINUED ITEMS NOT SUBJECT TO RETURN.
Damaged Merchandise:
ICC Regulations require that claims for damaged merchandise must be made with the carrier within fifteen
(15) days of receipt of merchandise. DO NOT ACCEPT DAMAGED SHIPMENTS UNLESS SUCH DAMAGE
IS NOTED ON THE DELIVERY RECEIPT AT THE TIME OF RECEIPT. Upon prompt notification, Stryker
will file a freight claim with the appropriate carrier for damages incurred. Claim will be limited in amount to
the actual replacement cost. In the event that this information is not received by Stryker within the fifteen
(15) day period following the delivery of the merchandise, or the damage was not noted on the delivery receipt
at the time of receipt, the customer will be responsible for payment of the original invoice in full.
Claims for any short shipment must be made within thirty (30) days of invoice.
International Warranty Clause:
This warranty reflects U.S. domestic policy. Warranty outside the U.S. may vary by country. Please contact
your local Stryker Medical representative for additional information.

DH 8/03 0720-100-126 REV G
European Representative
Stryker EMEA RA/QA Director
Stryker France
ZAC Satolas Green Pusignan
Av. De Satolas Green
69881 MEYZIEU Cedex
France
6300 S. Sprinkle Road, Kalamazoo, MI 49001-9799 [phone]
www.strykermedical.com