Sundance Spas ALTAMAR User manual
AltamarTM • CameoTM • CapriTM • MajestaTM • MarinTM • MaxxusTM • OptimaTM
6530-395S, Rev. B
Attention New Hot Tub Owner!
Congratulations on the purchase of your new Sundance® hot tub! The following is
a list of automated functions performed by your hot tub. These functions are listed
below in an attempt to suppress any operational concerns you may have during the
-
mendations you should observe on a regular basis to protect your new investment.
Automated Spa Operations
Your new hot tub is equipped with an automated “blow-out” cycle that clears all
turn on for a period of one minute, then go off. Then pump 1 will turn on and run
for one minute to complete the blow-out cycle. Be aware, the factory programmed
blow-out cycle cannot be canceled or altered!
Maintain Healthy Spa Water
Always maintain your hot tub’s water chemistry within the following parameters as
pH 7.4 - 7.6
Free Chlorine 3.0 - 4.0 ppm
Free Bromine 2.0 - 4.0 ppm
Total Alkalinity 100 - 120 ppm
Calcium Hardness 150 -250 ppm
Refer to for additional information.
Required Filter Maintenance
Your new hot tub is equipped with an advanced MicroClean
system that provides unsurpassed water quality! To ensure maximum water quality
necessary. Attempts to reuse
hot tub. See
Required Water Replacement
You should replace the hot tub’s water every 3 to 6 months. The frequency
depends on a number of variables including frequency of use, number of users,
change when you cannot control sudsing and/or you can no longer get
the normal
all within the proper parameters. See page 59 for additional information.
Table of Contents
1.0 Important Hot Tub Owner Information ..................................1
2.0 Important safety instructions ................................................2
3.0 Locating Your Sundance Hot Tub..........................................6
3.1 Outdoor Location.......................................................................7
..........................................................................7
4.0 General Electrical Safety Instructions ..................................8
5.0 Electrical Installation Instructions (240V Service)...............9
6.0 Maxxus Power Requirements ..............................................13
7.0 Altamar/Cameo/Capri/Marin/Majesta/Optima Power
Requirements ........................................................................14
8.0 Hot Tub Fill Up Procedure....................................................15
9.0 Hot Tub Features (All Models) .............................................20
.................................................0
............................................................1
10.0 Operating Instructions .........................................................29
10.1 View Button .............................................................................9
...........................................9
10.3 AquaTerrace™.........................................9
..............................................................................30
...............................................................30
.................................................30
...................................31
.....................................................31
10.9 Air Controls..............................................................................3
10.10 Waterfall Control......................................................................3
...............................................................3
TM Audio System .......................................3
.......................3
..................................................35
.......................36
...................................................37
.......................38
...................................................39
......................0
..................................................1
.......................
..................................................3
..........................
.....................................................5
..........................6
......................................................7
11.0 Heating Modes ......................................................................48
............................................8
.......................................................................8
11.3 Selecting Standard or Economy Mode....................................8
.....................................................8
12.0 Programming Instructions ...................................................49
.....................9
....................................................9
.............................................................51
.........................................................51
...............................................................5
.......................................................5
............................5
13.0 Hot Tub Maintenance............................................................54
................................................5
..............................................................55
.................................................56
1 ..............................................................................57
13.5 Maintaining The Synthetic Cabinet..........................................57
13.6 Maintaining The Cover ............................................................57
13.7 Winterizing...............................................................................58
13.8 Restarting Your Hot Tub in Cold Weather ...............................59
14.0 Water Quality Maintenance ..................................................59
...............................................................................59
.................................................................................59
........................................................................60
..........................60
.............................................................60
15.0 Troubleshooting - Display Messages..................................61
16.0 Troubleshooting - Procedures.............................................63
17.0 US/Canada 60Hz Maxxus Electrical Wiring Diagram ........66
18.0 US/Canada 60Hz Altamar/Cameo/Capri/Majesta/Optima/
Marin Electrical Wiring Diagram..........................................67
19.0 Export 50Hz Maxxus Electrical Wiring Diagram ...............68
20.0 Circuit Board Pin Assignments ..........................................69
21.0 Typical Hot Tub Wiring Diagrams A-B ................................70
22.0 Optional SunSound™Stereo Receiver Features...............71
...........................71
.........................71
Stereo Receiver Operation....................................7
..........................7
...................75
...............................................76
........................77
.................79
...............................................................80
...............................................81
1.0 Important Hot Tub Owner Information
Your Sundance® hot tub is constructed to the highest standards and is
capable of providing many years of trouble-free use. However, because
heat retentive materials are utilized to insulate the hot tub for effi-
cient operation, an uncovered hot tub surface and wall fittings directly
exposed to sunlight and high temperatures for an extended period is
exposing the hot tub to this abuse is not covered under warranty. We
cover in place at all times when the hot tub is not in use. Read and
carefully follow the requirements for your hot tub’s support base found
in the section 3.0 titled, “Locating Your Sundance Hot Tub” (page 6) or
Sundance hot tubs constantly strives to offer the finest hot tubs
available, therefore, modifications and enhancements may be
made which affect the specifications, illustrations and/or instruc-
tions contained herein.
FCC Notice
This equipment has been tested and found to comply with the limits for
limits are designed to provide reasonable protection against harmful
interference in a residential installation. This equipment generates, uses
and can radiate radio frequency energy and, if not installed and used
in accordance with the instructions, may cause harmful interference to
radio communications. However, there is no guarantee that interference
harmful interference to radio or television reception, which can be deter-
mined by turning the equipment off and on, the user is encouraged to try
1. Rearrange or relocate the receiving antenna;
3. Connect the equipment into an outlet on a circuit different from the
circuit connected;
operate this equipment.)
2.0 Important safety instructions
READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY
When installing and using this electrical equipment, basic safety precau-
1. WARNING:
this product unless they are closely supervised at all times.
WARNING: A grounding wire connector is provided on this unit to
) solid copper conductor
between this unit and any metal equipment, metal enclosures of
electrical equipment, metal water pipe, or conduit within 5 feet (1.5m)
of the unit.
3. DANGER:
exercised to prevent unauthorized access by children. To avoid ac-
cidents, ensure that children cannot use this hot tub unless they are
supervised at all times.
DANGER:
-
5. DANGER:
metal surfaces. As an alternative, a hot tub may be installed within 5
feet of metal surfaces if each metal surface is permanently connected
) solid copper conductor
attached to the wire connector on the grounding lug, inside the equip-
ment compartment on the equipment box.
6. DANGER:-
ance, such as a light, telephone, radio, television, etc. within 5 feet
(1.5m) of a hot tub unless such appliances are built-in by the manu-
facturer.
7. ELECTRICAL SUPPLY: The electrical supply for this product must
-
-
cessible and visible to the hot tub occupant but installed at least 5 feet
(1.5m), from the hot tub water.
8. WARNING: To Reduce the Risk of Injury:
-
ered safe for a healthy adult. Lower water temperatures are recom-
mended for young children and when hot tub use may exceed 10
minutes.
10. Since excessive water temperatures have a high potential for caus-
ing fetal damage during the early months of pregnancy, pregnant or
possibly pregnant women should limit hot tub water temperatures to
a hot tub.
11. Before entering the hot tub, the user should measure the water tem-
perature with an accurate thermometer since the tolerance of water
may lead to unconsciousness with the possibility of drowning.
low or high blood pressure, circulatory system problems, diabetes,
-
culties in association with using or operating your hot tub, discontinue
use and consult your physician.
hot tub since some medication may induce drowsiness, while other
medication may affect heart rate, blood pressure, and circulation.
15. Always shower before and after using your hot tub. To reduce the
possibility of contracting a waterborne illness, always maintain water
chemistry within the parameters listed on the inside cover of this man-
IMPORTANT CSA SAFETY INSTRUCTIONS (CANADA ONLY)
When using this electrical equipment, basic safety precautions should
1.
symbol* is located inside the supply terminal
-
nal must be connected to the grounding means provided in the elec-
tric supply service panel with a continuous copper wire equivalent in
size to the circuit conductors that supply this equipment.
surface or on the inside of the supply terminal box/compartment. To
grid in the area of the hot tub to these terminals with an insulated or
or other similar hardware within 10 feet (3m) of the hot tub shall be
bonded to the equipment grounding buss with copper conductors not
5. SAVE THESE INSTRUCTIONS.
WARNING: Children should not use hot tubs without adult supervision.
WARNING:
prevent body and hair entrapment.
WARNING:
WARNING: To avoid injury, exercise care when entering or exiting the
hot tub.
WARNING:
tub to avoid unconsciousness and possible drowning.
WARNING:
physician before using a hot tub.
WARNING:-
rious to your health.
WARNING: Before entering the hot tub, measure the water temperature
with an accurate thermometer.
WARNING:-
cise.
WARNING:
health.
WARNING:
radio, television, etc.) within 5 feet (1.5m) of this hot tub unless such
appliances are built-in by the manufacturer.
CAUTION: Maintain water chemistry in accordance with manufacturer’s
instructions.
WARNING:
fatal hyperthermia in hot tubs.
SAVE THESE INSTRUCTIONS
HYPERTHERMIA
-
tion of the causes, symptoms, and effects of hyperthermia are as fol-
Hyperthermia occurs when the internal temperature of the body reaches
and an increase in the internal temperature of the body. The effects of
A warning sign is provided in your warranty packet. Please install
it at a location near your hot tub, where it is visible to the user of
the hot tub. For additional or replacement signs please contact
your local Sundance Hot tubs dealer and reference item number
#6530-082.
CAUTIONS
pressure, and any condition requiring medical treatment, pregnant
women, the elderly, or infants should consult with a physician before
using a hot tub.
your health.
3. Observe a reasonable time limit when using the hot tub. Long ex-
posures at higher temperatures can cause high body temperature.
Symptoms may include dizziness, nausea, fainting, drowsiness, and
reduced awareness. These effects could possibly result in drowning.
serious consequences.
5. Always test the hot tub water temperature before entering the hot
tub. Enter and exit the hot tub slowly. Wet surfaces can be very slip-
pery.
6. Never bring any electrical appliances into or near the hot tub. Never
operate any electrical appliances from inside the hot tub or when
you are wet unless such appliances are built-in by the manufacturer.
maintain safe water and prevent possible damage to hot tub
components.
use. This will help to discourage unsupervised children from entering
-
tions. There is no representation that the cover, clip tie-downs, or
3.0 Locating Your Sundance Hot Tub
IMPORTANT: Because of the combined weight of the spa, water and us-
ers, it is extremely important that the base upon which the spa rests be
-
placed on a surface which does not meet these requirements, damage
owner to assure the integrity of the support over time. We recommend a
that it meets the requirements outlined above.
The spa must be installed in such a manner as to provide drainage away
drainage could allow rain, overflow and other casual water to flood the
-
certain that there are no obstructions which would prevent removal of all
side cabinet panels and access to the jets components, especially on
the side with the equipment bay doors.
3.1 Outdoor Location
• The proximity to changing area and shelter (especially in regions
subject to cold weather).
• The pathway to and from your hot tub (this should be free of debris
• The closeness to trees and shrubbery (remember that leaves and
• A sheltered environment (less wind and weather exposure can result
in lowered operation and maintenance costs).
to place the hot tub under an unguttered roof overhang since run-off
water will shorten the life expectancy of the hot tub cover.
3.2 Indoor Location
• PROPER FOUNDATION-
sidering a foundation that will adequately support the spa the entire
-
nies, roofs or other platforms not specifically tied into the main struc-
tural support, you should consult a professional Structural Engineer
with experience in this type of application.
• PROPER DRAINAGE
measures to sufficiently handle excessive water spillage. Be sure
the flooring in which the spa rests on has adequate drainage and can
provisions for ceilings or any other structures that may be below the
spas installation. Areas around your spa can become wet or moist
so all flooring and subsequent furniture, walls and adjacent structures
should be able to withstand or resist water and moisture.
• PROPER VENTILATION
with an Engineer or authority competent enough to understand the
necessary provisions needed to vent moist or heated air and air asso-
ciated with chemical odors outdoors. When the spa is in use consid-
erable amounts of moisture will escape potentially causing mold and
mildew, over time this can damage certain surfaces and or surround-
ings.
• SUFFICIENT ACCESS
need to access or gain entry to any portion of the spa for servicing, it
is highly recommended that you plan your indoor installation to pro-
vide full access to the entire spa.
• WARRANTY
any improper installation not in accordance with local codes or au-
local state or city building ordinances.
WARNING:
chemistry, proper ventilation is recommended to reduce
present in the air or water. Consult a licensed architect
installing your hot tub indoors.
4.0 General Electrical Safety Instructions
Your new Sundance® hot tub is equipped with the “state-of-the-art”
Sentry™
self-protective equipment in the industry. Nonetheless, this hot tub must
local Sundance dealer or local building department should you have any
questions regarding your installation.
equipped with a current collector system. A pressure wire connector is
provided on the surface of the control box, located inside the equipment
) to permit connection of a bonding wire between
this point and any ground metal equipment, metal water pipe or conduit
within 5 feet (1.5m) of the hot tub, or copper clad grounding rod buried
within 5 feet (1.5m) of the hot tub. Bonding wire must be at least No. 8
) solid copper wire. This is a most important safety assur-
ance feature.
to ensure installation conforms to local building codes.
5.0 Electrical Installation Instructions (240V Service)
IMPORTANT NOTICE: The electrical wiring of this hot tub must meet
the requirements of the National Electrical Code (NEC) and any appli-
cable state or local codes. The electrical circuit must be installed by a
-
tion authority.
1. This hot tub must be permanently connected (hard-wired) to the
power supply. No plug-in connections or extension cords are to
be used in conjunction with the operation of this hot tub. Sup-
plying power to the hot tub which is not in accordance with these
instructions will void both the independent testing agency listing and
the manufacturer’s warranty.
no other appliances or lights sharing the power provided by the
circuit.
3. To determine the current, voltage and wire size required, refer to
hot tub model.
• Wire size must be appropriate per NEC and/or local codes.
• We recommend type THHN wire.
• All wiring must be copper to ensure proper connections. Do not use
aluminum wire.
• When using wire larger than #6 (10mm²), add a junction box near
-
nect to the hot tub.
the hot tub’s occupant but installed at least 5 feet (1.5m) from hot
tub water.
5. The electrical circuit supplied for the hot tub must include a suitable
four screws securing the center cabinet panel on the side of the
hot tub under the controls. Then remove the four control box door
).
page 11) and remove the short cabinet panel from the front of the
hot tub to allow you to feed the cable through to the control box.
in the bottom of the control box.
-
up securely or damage could result.
Figure-A (Maxxus Equipment Area)
1. Sentry Control Box
6. Blower
7. Heater
11. Optional Subwoofer Behind
Option Only.)
5
34
SENTRY
SPA CONROLLER
1
11
9
9
10
22
8
7
6
12
5
34
SENTRY
SPA CONROLLER
1
11
9
9
10
22
8
7
6
12
1. Sentry Control Box
6. Air Blower
10. Optional Subwoofer Behind
Option Only.)
SPA CONROLLER
Note: Pump Locations Vary by Model
8
1
7
7
10 9
4
6
2 2
5
3
11
SPA CONROLLER
Note: Pump Locations Vary by Model
8
1
7
7
10 9
4
6
2 2
5
3
11
Figure-B (Equipment Area for All Models Except Maxxus)
TB1
Red (L2)
Green
Black (L1)
TB1
TB3
1. Terminal Block
2. Bonding Lug
3. Receptacle for Optional Ozone Purification System
4. Grounding Terminal
SENTRY
SP
A CONROLLER
1
3
4 2
Figure-C
Sentry Control Box
Figure-D
Terminal Block 240V
Wire Connection
6.0 Maxxus Power Requirements
Sundance® hot tubs are designed to provide optimum performance
a qualified technician can perform a minor circuit board
service (see table below).
US/Canada 60Hz Maxxus
US/Canada 60Hz Model
Number of Wires 3 3
*60A**
* will not operate while any two
jets pumps are running.
** will operate while any two jets
pumps and the blower are running but will not operate when
all three jets pumps are running.
Export 50Hz Maxxus
Number of Wires 3 3
*50A**
* will not operate while any two
jets pumps are running.
** will operate while any two jets
pumps and the blower are running but will not operate when
all three jets pumps are running.
7.0 Altamar/Cameo/Capri/Marin/Majesta/Optima Power
Requirements
Sundance hot tubs are designed to provide optimum performance and
**
a qualified technician can perform a minor circuit board
service (see table below).a
US/Canada 60Hz Altamar/Cameo/Capri/Marin/Majesta/Optima
60Hz Altamar/Cameo/Marin/Majesta/Optima Models
Number of Wires 3 3 3
*50A** 60A***
* will not operate while either
jets pump is running or when the blower is running.
** will not operate while both jets
pumps are running.
*** will operate while both jets
pumps and the blower are running.
60Hz Capri Models
Number of Wires 3 3 N/A
*50A** N/A
* will not operate while either
jets pump is running or when the blower is running.
** will not operate while both jets
pumps are running.
This manual suits for next models
4
Table of contents
Other Sundance Spas Hot Tub manuals
Sundance Spas
Sundance Spas Camdenl Certa User manual
Sundance Spas
Sundance Spas 780 series User manual
Sundance Spas
Sundance Spas CAMDEN 780 User manual
Sundance Spas
Sundance Spas CONSTANCE 6530-512X User manual
Sundance Spas
Sundance Spas 850 Series User manual
Sundance Spas
Sundance Spas Denali 680 Series User manual
Sundance Spas
Sundance Spas Export 680 Series User manual
Sundance Spas
Sundance Spas ALTAMAR 880 Use and maintenance manual
Sundance Spas
Sundance Spas Marin 880 User manual
Sundance Spas
Sundance Spas Architectural Series User manual
Sundance Spas
Sundance Spas 680 Series User manual
Sundance Spas
Sundance Spas 880 Series User manual
Sundance Spas
Sundance Spas Kingston 980 Series User manual
Sundance Spas
Sundance Spas 850 Series Operating instructions
Sundance Spas
Sundance Spas Spas User manual
Sundance Spas
Sundance Spas Portofino Series Installation instructions
Sundance Spas
Sundance Spas CAMEO Operating instructions
Sundance Spas
Sundance Spas CAMDEN 780 User manual
Sundance Spas
Sundance Spas maxxus 880 Series User manual
Sundance Spas
Sundance Spas Maxxus User manual
Popular Hot Tub manuals by other brands
Jacuzzi
Jacuzzi Fuzion 7260 Installation & operation instructions
Jacuzzi
Jacuzzi J-ALLURE J-ALLURELuxury Bathing and Entertainment... Installation and operation instructions
Westerbergs
Westerbergs Enjoy Installation instructions and user manual
Strong
Strong Monaco 20 owner's manual
Victory Spa
Victory Spa Aruba technical information
American Standard
American Standard Cadet Elite Corner Whirlpool 2775E parts list
Jacuzzi
Jacuzzi Amiga T700-LH Specification sheet
ThermoSpas
ThermoSpas 100 Series owner's manual
Jacuzzi
Jacuzzi ENJOY Instructions for preinstallation
glass 1989
glass 1989 capri 150 manual
Down East
Down East 2002 model year owner's manual
American Standard
American Standard Acrylux Builder Series 6030Y2A.102.XXX installation instructions