Toyotomi TAD-T40LW User manual

IMPORTANT POINTS ON SERVICE OPERATING SAFETY
Please follow these instructions carefully :
FLOW CHART FOR INSPECTING AND REPAIRING THE UNIT
- 1 -
Unplug the unit to avoid any danger from electric shock before disassembling the unit for
repair.
If there is any sound of the refrigerant circulating when in operation, avoid touching the
cooling coils.
If you need to perform any welding or soldering, be sure you are in a well ventilated area.
Only a qualified professional should perform any welding on the unit.
When repairing the unit, the specifications listed in this manual must be strictly adhered
to when replacing any components.
When replacing any electrical components they should be factory approved units.
Be sure that any electrical components are properly wired and in place.
PLUG AND SOCKET
ARE LOOSE
RE-PLUGING THE
POWER SUPPLY CORD
AIR CONDITIONER
WON'T COOL
PROPERLY
AIR CONDITIONER
WON'T START
COMPRESSOR WON'T
START
TIMER FAILURE
CHANGE THE
PROTECTOR
RUNNING TEST
RE-CONNECTING
NO POWER
PROTECTOR FAILURE
USE OXYACETYLENE AND PLUS 5%
SILVER SOLDER TO WELD THE
CRACKED POINTS
WIRING IS LOOSE
CAPACITOR FAILURE
CHANGE THE SWITCH
CHANGE THE
CAPACITOR
TESTING BY
ELECTROSCOPE
POWER TRIPPED CHECK THE POWER
SWITCH
REFRIGERANT
LEAKAGE
TROUBLE SHOOTING
THE SYSTEM
RUNNING THE VACUUM
EVACUATION FOR MORE
THAN 15 MINUTES
CHANGE COOLANT AND
PROCEED RUNNING TEST
CHANGE THE AIR CONDITIONER WITH 15 KG/CM 2
NITROGEN GAS FROM LOW-PRESSURE SIDE AND
DETECT THE LEAKING POINT BY SOAP

TROUBLESHOOTING
Problem
- 2 -
Analysis
Does not run
·If the protector trip or fuse is blown.
·Please wait for 3 minutes and start again, protector
device may be preventing unit to work.
·If batteries in the remote controller exhausted.
·If the plug is not properly plugged.
Run a short while
only
Run but not cool
Do not run and water
full indicator lights
·If the set temperature is close to room temperature,
you can low the set temperature.
·Air outlet be blocked by obstacle.
Take the obstacle away.
·If the door or window open.
·If there is other heater appliance work,
like heater or lamp, etc...
·The air filter is dirty, please clean it.
·Air outlet or intake be blocked.
·Set temperature is too high.
·Drain the water into a prepared container by the drainage
pipe on the rear panel of the unit.
If still doesn't work, please consult a qualified technician.

APPEARANCE
- 3 -
UNIT DIMENSIONAL
505 400
854
Control panel
Cold air outlet
Signal receptor
Handle hole
Caster
Air outlet hose
Air intake ( Evaporator )
Air intake hose
Power supply cord
Water outlet drain

TECHNICAL SPECIFICATIONS
- 5 -
ITEM UNIT
OUTER DIMENSION
RATED VOLTAGE
CAPACITY
DEHUMIDIFYING
CAPACITY
RUNNING CURRENT
POWER
CONSUMPTION
INDOOR AIR VOLUME
COMPRESSOR
MODEL
RATED
VOLTAGE
OPERATING
CYCLE
PROTECTOR
MODEL
INPUT
POWER
TURBINE
FAN MOTOR
CAPILLARY
CONDENSER
REFRIGERANT
WEIGHT
REFERENTIAL USING
AREA
500W*854H*400D
115 / 60
300
1007
55/300
RSH6870S1
12
9/250
2.6(O.D.)*1.4(I.D.)*1000(L)
(2+1)R17S19FPI
TOYOTOMI TAD-T40LW
14000
13～19
1.8
33.8
OPERATING
CYCLE
MODEL
OUTPUT
POWER
INDOOR
MOTOR
LS-23T3-6P
23
8/250
OPERATING
CYCLE
MODEL
OUTPUT
POWER
OUTDOOR
MOTOR
LS-53T1-4P
53
EVAPORATOR 2R14S21FPI
mm
2
m
V/Hz
B.T.U.
L/H
A
W
3
M /hr
W
uF/V
mm
uF/V
R410A/g
kg
W
uF/V
W
V
10.8
44N100-A2-BCAD
MRA12352-12081
690
COOLING HEATING
11000
10.8
---
---

SCHEMATI C WIRING DIAGRAM
REFRIGERATOR SYSTEM DIAGRAM
EVAPORATOR
CONDENSOR
COMPRESSOR
CAPILLARY
FILTER
- 6 -

EXPLODED VIEW
48
29
17
46
24
28
23 25
36
32
37
34
35
33
11
20 21 17
30
50
51
4
7
6
5
9
8
10
3
2
1
38
39
31
22
41
40
Date : 2012/05/11 Version : 1.0
57
58
ACCESSOR
60 61
42 43
62 64 65
47
49
56
55
63
59
18
52
53
14
16
12
13
54
15
26
27
44 45
TAD-T40LW

PARTS LIST
MATERIAL CODE PARTS NAME QUANTITY
1
4
1
1
1
1
1
1
1
1
3
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
PRICE
Version : 1.0
A4805-21B-A-11
A7402-020
A7307-060
A5408-250-H-11
A5408-230-H-11
A5405-110-H-11
A5404-090
A2506-040
A3010-010
A3203-130
A5600-170
A6214-350
A6214-290
A6228-630
A6209-690
A7317-221
A3422-600
D6210-060
A6204-300
A5802-530
A5600-160
A5301-610-AB-22
A5304-470-I-11
A3002-510
A5301-620-AB -22
A5806-250
A5600-140
A2509-410
A2509-940
A5702-170-A-22
A3419-540
A5301-590-A-22
A5304-310-AH-22
A3002-220
A5301-600-A-22
BASE PAN
TURNING WHEEL
SOFT CAP
DRAIN BUCKET COVER-B
DRAIN BUCKET COVER-A
TANK LID
FLOAT
MICRO SWITCH
WATER MOTOR
COMPRESSOR ASS'Y(44N100-A2)
RUBBER
CONNECTOR PIPE
SUCTION PIPE
4-WAY REVERSING VALVE ASS`Y
CONDENSER ASS'Y
Y TUBE
CAPILLARY TUBE
RUBBER
FAN CASING
BLOWER WHEEL
FAN MOTOR(LS-53T1-4P)
FAN CASING
METAL FIXTURE
RUBBER
CAPACITOR( 9uF/250V)(FOR FAN MOTOR(24))
CAPACITOR(55uF/300V)(FOR COMPRESSOR(10))
PLATE
EVAPORATOR ASS'Y
FAN CASING
BLOWER WHEEL
FAN MOTOR
FAN CASING
CONNECTOR PIPE
DISCHARGE PIPE
METAL FIXTURE
NO
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
TAD-T40LW
Date : 2012/05/11

PARTS LIST
MATERIAL CODE PARTS NAME QUANTITY
NO
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
PRICE
Version : 1.0
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
2
2
1
1
1
1
2
4
2
2
1
2
1
A7204-130
A2509-130
A6101-510-AF-11
A2517-010
A5812-570-AF-11
A5812-540-P-11
A2524-070
A2524-120
D5806-040
A2524-190
A3701-700
A4201-150-A-BS
A6101-110-A-AQ
A4258-030-A-BS
A4219-230-A-BS
A7301-110-A-BS
A6101-920-AF-11
A5825-050-AF-11
A6101-800-AF-11
A4243-170-A-BS
A2521-860
A4254-170-AF-11
A6930-010-B7
A6200-070
A5815-090-H-BS
A5812-210-H-BS
A6101-230-H-BS
A5700-210
A5700-200
A2529-090-AN01
SCREEN
COVER
CONTROL BOARD
FIX TURE
FIX TURE
SENSOR(FOR RC)
SENSOR(FOR EVAP)
FIX META L
SENSOR(FOR INDOOR)
POWER SUPPLY CORD COMPLETE
FRORT PANEL
COVER
HANDLE
REAR PANEL
AIR FILTER
COVER
FIX TURE
COVER
VAN-AIR DRFLECTOR
PC BOARD
CONTROL PLATE
CONTROL PLATE
HEAT EXHAUST HOSE
HEAT EXHAUST HOSE CONNECTOR
FIX TURE
COVER
PLATE
PLATE
REMOTE CONTROL ASS`Y
CAPACITOR(8uF/250V)(FOR FAN MOTOR(34))
TAD-T40LW
Date : 2012/05/11