Vulcan-Hart GHIR44 User manual

Item # __________________________
C.S.I. Section 11420
VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]
502-778-2791 QUOTE & ORDER FAX: [phone]
0
8
7
2
A
1
0
0
9
O
S
I
.
o
C
t
r
a
H
-
n
a
c
l
u
V
F-32419 (05-06)
SPECIFICATIONS
Battery matching heavy-duty single deck gas infrared broiler
with nishing oven over the broiler and storage base under the
broiler. Model No. GHIR44, manufactured by Vulcan-Hart.
Stainless steel body 6" adjustable legs. Power blower to mix
primary and secondary air with (natural) (propane) gas. Air and
gas mixture to move through overhead perforated ceramic tile
infrared generators. Four 20,000 BTU/hr. ceramic tile faced burners
reach approximately 1600°F through two innite heat valves with
high and low positions. 80,000 total BTU/hr. input. Pilot lights and
pressure regulator. Spring balanced broiler grid area to be
1⁄2"w x 29 1⁄2
"d. Grid is made of cold rolled steel bars and is
mounted on roller bearings. Insulated external handle and adjustable
to ve locking broiling levels. Contains and above broiler au gratin
oven with interior dimentions: 26" x 28" x 10". Bottom storage
base has two doors
Exterior dimensions: 34"w x 38 1/4"d x 82"h.
CSA design certied. NSF listed.
SPECIFY TYPE OF GAS AND FINISH WHEN ORDERING
GHIR44 With Au gratin oven and lower storage area
STANDARD FEATURES
Stainless steel front, top and legs.
High production infrared broiler with power blower supplied
primary and secondary air.
Reaches 1600°F broiling temperatures quickly and main-
tains broiling eciency during peak hours under repeated
loading.
Radiant infrared rays reduce broiling time up to 50% on
many products.
Quick preheating allows broiler to be turned o in slow
periods.
Spring balanced 5 position grid for raising and lowering.
Porcelain enameled steel liners in broiler compartment.
Four foot 120V power cord.
Gas pressure regulator.
Grid area 700 sq. in.; 25 1/2" x 29 1/2".
Grid moves on roller bearings.
Cold rolled steel grid bars for marking.
Insulation between outer and inner walls.
Au gratin oven.
One year limited parts and labor warranty.
OPTIONS
Stainless steel nishing back panel.
Stainless steel side(s).
Stainless steel front top ledge.
IR44 - less legs on 1 5/8" base.
Rear gas connection.
Second year extended limited parts and labor warranty.
ACCESSORIES
Quick disconnect gas hose.
GHIR44
INFRARED BROILER
4
4
R
I
H
G
:
L
E
D
O
Mr
e
l
i
o
r
B
d
e
r
a
r
f
n
I
SPECIFY ALTITUDE WHEN ABOVE 2,000 FT.
25

Printed On Recycled Paper
VULCAN-HART COMPANY, P.O. BOX 696, LOUISVILLE, KY 40201, TEL. [phone]
502-778-2791 QUOTE & ORDER FAX: [phone]
NOTE: In line with its policy to continually improve its products, Vulcan-Hart Company reserves the right to change materials and
specications without notice.
F-32419 (05-06)
GHIR44
INFRARED BROILER
IMPORTANT
1. A properly sized gas pressure regulator suitable for battery
or single unit application must be furnished and installed.
Natural gas 5.0" W.C., propane gas 10.0" W.C.
2. An adequate ventilation system is required for commercial
cookingequipment.Informationmaybeobtainedbywritingto
the National Fire Protection Association, Batterymarch Park,
Quincy, MA 02269. When writing refer to NFPA No. 96.
3. These units are manufactured for installation in accordance
with ANSZ223.1a (latest edition), National Fuel Gas Code.
Copies may be obtained from the American Gas Association,
1515 Wilson Blvd., Arlington, VA 22209.
4. This broiler requires a 6" clearance at both sides and rear
adjacent to combustible construction.
5. This appliance is manufactured for commercial installation
only and is not intended for home use.
MODEL GHIR44
Overall Dimensions
)mm468("43htdiW
83htpeD 1⁄4" (972 mm)
Height, including 6" legs 82" (2083 mm)
)gk473(.sbl528.tW.phS.xorppA
Broiler Grid Overall
52htdiW 1⁄2" (648 mm)
92htpeD 1⁄2" (749 mm)
000,08latoTgnitaR.rh/UTB
Finishing Oven Compartment
)mm056("62htdiW
)mm117("82htpeD
)mm452("01thgieH
Gas Manifold Across Front 1 1⁄4" std. pipe (32 mm)
)503("21x)mm251("6ralloCeulF
Top View
Side View
Front View